Page 2
The DAHON Pedelec offers a perfect synergy between the cyclist’s pedal input and additional motor support. Please keep in mind that improper installation and operation of the Unio E20 can reduce the performance and the overall enjoyment of this product.
Features • Pedal Assist Concept. • Motor support only switches on when you start pedaling and switches off when you stop pedaling. • Perfect synergy between cyclist’s pedal input & additional motor support. • Direct relation between pedal force and motor support: 1) Level 0: Normal function.
7.Display 8.Grip 9.Handlebar 6.Charging port 24. Saddle 10.Brake lever 5.Battery switch 4.Seat tube battery 11.Handlepost (Internal) 3.Control system (Internal) 2.Mid-motor 1.Frame 23. Seat tube clamp 12. Brake 13. Front fork 14. Spokes 15. Rim 16. Tire 17. Air valve 18. Pedal 20.
Page 6
01. Power Button: Power ON/OFF switch function. • Please confirm the battery is turned on before starting. Press the “M” key for 3 seconds and it will turn on, which means it is in power-on state. • Press the “M” key for 3 seconds and it will turn off. Then press the battery power key to disconnect the power.
Page 7
• After entering the setting, the • Wheel diameter setting single mileage can be cleared by pressing the DOWN key. • Mileage unit options (KM/H or MPH) • Voltage setting (36V/48V) 14. Normal function / Boost function – Use for normal and flat road surfaces. 15.
Page 8
Error Code icon Error Code No. DESCRIPTION Excessive electric current is detected inside the controller, and a protection mechanism is implemented. Check whether the three-phase power cable terminal connector is short-circuited. Code If there is no short-circuit, restart it. If this state still occurs, means the internal power device of the controller is damaged.
Page 9
2. Tires are inflated to the recommended tire pressure. 3. Brakes are functioning properly. Note: 1. Fold your DAHON E-bike according to the manual. 2. When folding and unfolding please take care to check that the internal cables are not caught. Should this occur, simply push the two cables back inside the frame.
Page 10
Handlebar adjustment (1) Loosen the handlepost quick release and adjust the handlepost to an appropriate height (the safety scale line must not be exposed outside the tube), and then lock the handle. (2) Loosen the stem handle and adjust the handlebar to a proper angle. Safe position Safety line Seatpost and saddle adjustment...
Page 11
WARNING: Make sure no oil or lubricant touches the surface of the brake pads, discs or wheel rims. (2) Derailleur adjustment: Adjust the "H" and" L" corresponding screws of the derailleur. The specific operation is as follows (loosen "H" screw when the chain can’t reach the smallest gear.
A ssembl e How to Charge the Battery Only use the battery charger that was supplied with the Unio E20. Use of any other battery charger voids your warranty and may result in severe damage to the battery and electrical system of the bicycle, and may cause a fire hazard.
Always store and cool the battery in a well-ventilated place, out of direct sunlight. Terms of Warranty The Dahon Unio E20 warranty period is 2 Years (24 months) according to the date of purchase. For all electrical parts including charger, display (console), controller, BB sensor, electrical cables, carrier and motor, (Note: motor noise is not covered) the warranty period is 2 Years (24 months).
NOTE: Certain fitted parts of the bicycle can wear out at differ- ent rates depending on use, road condition, weather and so on. Typical items include tires, chains, sprockets, chain wheels, brake pads, grips etc. Can the motor be overheated? Yes.
Page 15
04. The manufacturer is not liable for incidental or consequential loss nor damage due directly or indirectly from the use of this product. 05. This Dahon pedelec carrier is not compatible with a rear baby seat. 06. As with all mechanical devices, the bicycle is subjected to wear and high stresses.
Page 16
H e a d q u ar t e rs Dahon North America INC. 3550 N.Union Dr., Olney, IL., USA 62450 Tel: +1 800-442-3511 Dahon China 8th Floor, Brilliance Plaza, Yizhan 4th road, Shapu Community, Songgang Sub-district , Bao'an district,...