Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Porter & Charles CG60WOK-F
Summary of Contents for Porter & Charles CG60WOK-F
- Page 1 Operating and Installation Instructions CURRENT STANDARD: ANSI Z21.1-2016/CSA 1.1-2016 Gas Cooktop Model: CG60WOK-F CG76WOK-F CG90WOK-F To prevent accidents and machine damage, read the Operating Manual before installation or use.
- Page 2 WARNING: If the information in these instruction is not followed exactly, a fire or explosion may result causing property damage, personal injury or death. – Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. –...
-
Page 3: Gas Supply Requirements
WARNING This appliance is intended for use in the home only. Use this appliance only for its intended purpose. The manufacturer cannot be held liable for damage caused by improper use of this range. This appliance complies with current safety regulations. Improper use of this cooktop can result in personal injury and material damage. -
Page 4: Important Safety Instructions
WARNING:The appliance must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa). the maximum gas supply pressure in accordance with the inlet pressure rating of the gas appliance pressure regulator supplied. - Page 5 IMPORTANT SAFETY INSTRUCTIONS Correct usage Do not use pans that extend past the burner grate. Using larger pans Do not operate the cooktop until it is may cause the flames to spread out properly installed in the countertop. and damage the surrounding This appliance is intended for countertop or other countertop residential cooking only.
- Page 6 IMPORTANT SAFETY INSTRUCTIONS Personal safety Do not leave the cooktop unattended while in use. Boil-overs The burners become very hot when cause smoking, and greasy spill-overs in use. Make sure that no one comes in may ignite. contact with them. Do not use water on grease fires.
- Page 7 IMPORTANT SAFETY INSTRUCTIONS Damage to the appliance Further safety notes In the event of damage or a defect, When using a portable appliance near the cooktop, make sure that its turn off the appliance immediately. Turn power cord does not come in contact off the gas shut off valve and with the cooktop.
-
Page 8: Before Using The Cooktop
Before using the cooktop Cleaning the cooktop Metal components have a protective coating which may give off a slight odor Before using for the first time clean the the first time your new appliance is appliance as follows: heated. ^ Wash the gas burner assembly with a The harmless odor will dissipate after a mild solution of warm water and short time and does not indicate a... -
Page 9: Using The Cooktop
Using the cooktop Turning off Ignition-System ^ Turn the control knob clockwise to The gas cooktops are equipped with a “ß”. Fast-Ignition-System which incorporates the following features: This stops the flow of gas and turns off the cooktop. – The control knob can be released once it is turned to the largest flame The knob must only be turned left to symbol. -
Page 10: Suitable Pans
Using the cooktop Pan size Suitable pans – Set the cooktop to a high flame when Unlike pans used on an electric using a large diameter pan and low cooktop, the bases do not need to be flame when using small diameter even for good results. - Page 11 Using the cooktop Mini Trivet The mini-trivet included with this cooktop is to be used for cooking vessels of diameter 120 mm or smaller Examples of positioning of mini-trivet MODEL:CG60WOK-F MODEL:CG76WOK-F MODEL:CG90WOK-F 11 di 30...
-
Page 12: Cleaning And Care
Cleaning and care Cooktop Never use a steam cleaner to clean Let the appliance cool to a safe this cooktop. Pressurized steam temperature before removing the could cause permanent damage to grates. the surface and to components. ^ Clean the grates, cooktop and knobs Do not use any sharp or pointed with a sponge and a mild solution of objects which could damage the... - Page 13 Cleaning and care Burners The burners can be dismantled and cleaned when cool. ^ Remove the burner parts and wash them in a solution of hot water and liquid dish soap. Dry them thoroughly. Make sure that the flame holes are clean and completely dry. ^ Wipe the burner base clean with a damp cloth and then dry.
-
Page 14: Frequently Asked Questions
Frequently asked questions Repairs should only be carried out by an authorized technician in accordance with local and national safety regulations. Unauthorized repairs could cause injury or appliance damage. The burners do not ignite after several attempts. Possible fault – The burners are assembled –... -
Page 15: Technical Service
Technical Service In the event of a fault which you cannot easily fix yourself, please contact the Technical Service Department at the address on the back of this booklet. When contacting Technical Service please quote the serial number and model of the cooktop. This information is visible on the silver data plate supplied with the cooktop. -
Page 16: Installation Instructions
Installation Instructions To prevent accidents and machine damage read these instructions before 15 di 36 installation or use. - Page 17 IMPORTANT SAFETY INSTRUCTIONS Installation The minimum distances given in these Installation instructions are to 1.97" 50 mm combustible surfaces, and must be observed to ensure safe operation. Failure to do so increases the risk of fire. The cabinetry and venting hood should be installed first to prevent recommended damage to the cooktop.
- Page 18 IMPORTANT SAFETY INSTRUCTIONS The cooktop must not be installed This appliance must be installed over a dishwasher, washer, dryer, with its own shut off valve and the refrigerator or freezer. Heat radiated by included gas pressure regulator. the cooktop may damage the Both the valve and the regulator appliances.
- Page 19 IMPORTANT SAFETY INSTRUCTIONS MINIMUM REQUIRED CLEARANCES AROUND THE COOKTOP 1 Distance to the combustible surfaces measured from cooking surface (top of cooktop grate) 2 If installing with an overhead range hood, check the hood specification for minimum required clearances. 3 This specification does not apply for cabients located grater than a horizontal distance of 5 1/2"...
-
Page 20: Appliance Dimensions
Appliance dimensions Electrical Supply Gas Connection Cord 8,2" 2,7" MODEL:CG60WOK-F Depth of cooktop casing from benchtop surface : 2,7" 23" Gas Connection Electrical Supply Cord 20,4" 2,7" MODEL:CG76WOK-F Depth of cooktop casing from benchtop surface : 2,7" 30" 8 Gas Connection Electrical Supply Cord 24"... - Page 21 Appliance dimensions MODEL:CG60WOK-F MODEL:CG76WOK-F 10 di 30...
-
Page 22: Installation
Appliance dimensions MODEL:CG90WOK-F Installation ^ Prepare the work top cut-out as If during installation, the corners of shown in the diagram. the frame are not flush with the work top surface, the corner radius (max. ^ Seal the cut surfaces with a suitable "... -
Page 23: Setting The Cooktop Into Place
Installation Setting the cooktop into place Securing the cooktop ^ Secure the cooktop with the included fixing bracket. ^ After removing the protective backing, stick the supplied seal,under the edge of the cooktop. ^ Screw the gas regulator onto the nipple underneath the cooktop. - Page 24 Installation The sealing strip under the edge of the top part of the cooktop provides a sufficient seal for the worktop. Do not let sealant get in between the cooktop frame and the worktop. This could cause difficulties if the cooktop ever needs to be taken out for servicing and possibly result in damage to the cooktop frame or the...
-
Page 25: Electrical Connection
Electrical connection This appliance must be grounded This appliance is equipped with a according to local or national codes. three-prong grounding plug to prevent shock hazards. It should be All electrical work should be plugged directly into a properly performed by a qualified electrician grounded outlet. -
Page 26: Wiring Diagram
Electrical connection Wiring diagram MODEL: CG60WOK-F MODEL: CG76WOK-F / CG90WOK-F TRIPOLAR IGNITION TRIPOLAR IGNITION TERMINAL GENERATOR TERMINAL GENERATOR MICRO-UNIT MICRO-UNIT Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. -
Page 27: Gas Connection
Gas connection Installation and service must be The gas connection must be made performed by a qualified installer, in accordance with local codes or, in service agency or gas supplier. the absence of local codes, with In Massachusetts a licensed the National Fuel Gas Code, plumber / gas fitter is required. -
Page 28: Gas Pressure Regulator
Gas connection Gas pressure regulator For convenience, an AGA or CGA approved flexible stainless steel gas A pressure regulator that is convertible hose (accordion type) may be used from natural to LP gas (Propane) or vice between the gas connection and the versa is included with the appliance. -
Page 29: Nominal Rating Table
Gas connection Nominal Rating Table Technical Characteristics table Nominal Injector Burners Taap by-pass heat input N ormal N ormal Diameter Max. Pressure Diameter Pressure mbar in.w c 1/100mm (bTU/H) 1/100 mm DESCRIPTION N° 8.250 11.0" 1 SEMI-RAPID 7.600 REG. 4.0" 1 30 11.0"... -
Page 30: Converting To Another Type Of Gas
Converting to another type of gas GAS TRANSFORMATIONS AND ADJUSTMENTS Replacing the nozzles If the equipment is adjusted for a type of gas that is different from the original, it is necessary to replace the burner nozzles as well. The nozzles used to replace the original must be in accordance with the table of the technical characteristics enclosed. -
Page 31: Help Protect Our Environment
Help protect our environment Disposal of packing materials Disposal of an old appliance The cardboard box and packing Old appliances contain materials that materials are biodegradable and can be recycled. Please contact your recyclable. Please recycle. local recycling center about the possibility of recycling these materials. - Page 32 Warranty products are designed and built to the highest standards. Porter&Charles We expect your appliances to provide many years of trouble free enjoyment. In the event of an appliance requiring attention, each appliance is covered by a 2 year warranty from the date of purchase. Refer to warranty policy for complete terms and conditions.
- Page 33 COD. 208623-03 18.04.2018...
Need help?
Do you have a question about the CG60WOK-F and is the answer not in the manual?
Questions and answers