Related Manuals for Craftsman 944.362631
Summary of Contents for Craftsman 944.362631
- Page 1 Owner’s Manual ROTARY LAWN MOWER 6.25 Horsepower 21" Multi-Cut Model No. 944.362631 CAUTION: Read and follow all Safety Rules and In struc tions before operating this equipment Sears Canada, Inc., Toronto, Ontario M5B 2B8...
-
Page 2: Table Of Contents
Warranty service is available by returning the Craftsman Power Mower to the nearest Sears Service Centre/Department in Canada. This warranty applies only while this prod- uct is used in Canada. - Page 3 III. CHILDREN Tragic accidents can occur if the op er a tor is • Do not operate the mower when bare- foot or wearing open sandals. Al ways not alert to the presence of children. Children are often attracted to the ma chine and the wear substantial foot wear.
-
Page 4: Assembly/Pre-Operation
ASSEMBLY / PRE-OPERATION Read these instructions and this manual in Operator presence its entirety before you attempt to assemble control bar or operate your new lawn mower. Upper handle IMPORTANT: This lawn mower is shipped LIFT UP WITHOUT OIL OR GASOLINE in the engine. Your new lawn mower has been as sem - LIFT bled at the factory with the exception of... -
Page 5: Operation
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product. - Page 6 TO CONVERT MOWER The operation of any lawn mower can result in foreign Your lawn mower was shipped ready to be objects thrown into the used as a mulcher. To convert to bagging eyes, which can result in or discharging: severe eye damage.
- Page 7 1. Be sure lawnmower is level and area around oil fi ll is clean. 2. Remove oil dipstick from oil fi ll spout. Make sure that rim of spout is clean. 3. You receive a container of oil with the unit.
- Page 8 TO START ENGINE MULCHING MOWING TIPS NOTE: Due to protective coatings on the IMPORTANT: For best performance, engine, a small amount of smoke may be keep mower housing free of built-up present during the initial use of the prod- grass and trash. See “CLEANING” in the uct and should be considered normal.
-
Page 9: Maintenance Schedule
MAINTENANCE LUBRICATION CHART ➀ GENERAL RECOMMENDATIONS Wheel adjuster (on each wheel) The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain mower as instructed in this manual. -
Page 10: Product Specifications
PRODUCT SPECIFICATIONS Serial Number: Date of Purchase: Gasoline Capacity / Type: 1,41 Liters (Unleaded Regular) Oil Type (API-SF-SJ): SAE 30 (above 32°F/0°C); SAE 5W-30 (below 32°F/0°C) Oil Capacity: 0,58 Liters Spark Plug: Champion RJ19LM (Gap: 0,76 mm) Blade Bolt Torque: 35-40 ft. - Page 11 GRASS CATCHER 6. Wait one minute to allow oil to settle. Insert and tighten dipstick, then re- • The grass catcher may be hosed with move it to check oil level. water, but must be dry when used. 7. Continue adding small amounts of •...
-
Page 12: Service And Adjustments
MUFFLER CAUTION: Disconnect spark plug wire Inspect and replace corroded muffl er as it from spark plug and place wire where it could create a fi re hazard and/or dam age. cannot come in contact with the spark plug. • Clean the underside of your lawn mower SPARK PLUG by scraping to remove build-up of grass Replace spark plug at the beginning of... -
Page 13: Storage
ENGINE does not operate properly due to sus pect ed carburetor problems, take your lawn mower ENGINE SPEED to a Sears or other qualifi ed service center Your engine speed has been factory set. for repair and/or ad just ment. Do not attempt to increase engine speed IMPORTANT: Never tamper with the engine or it may result in personal injury. -
Page 14: Troubleshooting
1. Drain the fuel tank. 2. Pour 30 ml of oil through spark plug 2. Start the engine and let it run until the hole into cylinder. fuel lines and carburetor are empty. 3. Pull starter handle slowly a few times •... - Page 15 TROUBLESHOOTING - See appropriate section in manual unless directed to a Sears Service Center. PROBLEM CAUSE CORRECTION Loss of power 1. Rear of lawn mower 1. Set to “Higher Cut” housing or cutting blade position. dragging in heavy grass. 2. Cutting too much grass. 2.
-
Page 16: Repair Parts
REPAIR PARTS... - Page 18 CRAFTSMAN 4-CYCLE ENGINE MODEL NUMBER 143.026202...
- Page 19 CRAFTSMAN 4-CYCLE ENGINE MODEL NUMBER 143.026202 KEY PART KEY PART DESCRIPTION DESCRIPTION 37465 Cylinder (Includes Key 29752 Nut & Lock Washer, 1/4-28 Numbers 2, 20 and 150) 6201 Screw, 1/4-28 x 7/8" 26727 Dowel Pin 26756 * Carburetor To Intake Pipe Gasket...
- Page 20 CRAFTSMAN 4-CYCLE ENGINE MODEL NUMBER 143.026202 KEY PART DESCRIPTION 631615 Throttle Shaft & Lever Assembly 631767 Throttle Return Spring 631184 * Dust Seal Washer 631183 * Dust Seal 640070 Throttle Shutter 650506 * Shutter Screw 631807 Fuel Fitting 651025 Throttle Crack/Idle Speed Screw...
- Page 21 CRAFTSMAN 4-CYCLE ENGINE MODEL NUMBER 143.026202 KEY PART DESCRIPTION 590694 Recoil Starter 590599A Spring Pin (Includes Key No. 4) 590600 Washer 590696 Retainer 590601 Washer 590697 Brake Spring 590698 Starter Dog 590699 Dog Spring 590700 Pulley & Rewind Spring Assembly...
- Page 22 SERVICE NOTES...
- Page 23 SERVICE NOTES...
- Page 24 184149 03.04.03 BY Printed in U.S.A.
Need help?
Do you have a question about the 944.362631 and is the answer not in the manual?
Questions and answers