Ranger Products RS-500 Installation And Operation Manual
  1. Manuals
  2. Brands
  3. Ranger Products Manuals
  4. Cleaning Equipment
  5. RS-500
  6. Installation and operation manual

Ranger Products RS-500 Installation And Operation Manual

Hide thumbs Also See for RS-500:
Table of Contents

Advertisement

Quick Links

INSTALLATION AND OPERATION MANUAL
MODELS
RS-500
RS-750
Rev B
SHIPPING DAMAGE CLAIMS
When this equipment is shipped, title passes
to the purchaser upon receipt from the carrier.
Consequently, claims for the material damaged in
shipment must be made by the purchaser against the
transportation company at the time shipment is received.
PLEASE READ THE ENTIRE CONTENTS OF THIS MANUAL PRIOR TO
INSTALLATION AND OPERATION. BY PROCEEDING YOU AGREE THAT
YOU FULLY UNDERSTAND AND COMPREHEND THE FULL CONTENTS OF
THIS MANUAL. FORWARD THIS MANUAL TO ALL OPERATORS. FAILURE TO
OPERATE THIS EQUIPMENT AS DIRECTED MAY CAUSE INJURY OR DEATH.
BE SAFE
Ranger™ spray wash cabinets are designed and
built with safety in mind. However, proper training
and thoughtful operation on the part of the operator
can increase your overall safety. DO NOT operate
or repair this equipment without reading this manual
and the important safety instructions shown inside.
Keep this operation manual near the
machine at all times. Make sure that
ALL USERS read this manual .
1645 Lemonwood Dr.
Santa Paula, CA. 93060, USA
Toll Free: 1-800-253-2363
www.rangerproducts.com
MAN REV C 09-21-10
pn#5900121
Tel: 1-805-933-9970
Fax: 1-805-933-9160

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the RS-500 and is the answer not in the manual?

Questions and answers

Related Manuals for Ranger Products RS-500

Summary of Contents for Ranger Products RS-500

  • Page 1 OPERATE THIS EQUIPMENT AS DIRECTED MAY CAUSE INJURY OR DEATH. MAN REV C 09-21-10 pn#5900121 INSTALLATION AND OPERATION MANUAL MODELS RS-500 RS-750 Rev B Keep this operation manual near the machine at all times. Make sure that ALL USERS read this manual .

  • Page 2: Warranty Policy

    Defective parts replaced at no charge must be returned Your parts washer is made with mild steel and will to your dealer or Ranger Products™ within 60 days of the rust unless you use the correct detergent and follow date that the replacement parts are shipped; otherwise, the correct start-up procedure.

  • Page 3: Environmental Issues

    EPA does not require special NOTE: storage, documentation, transportation, and processing. If a unit is seriously damaged, your Ranger Products Since your solution will have oils, however, you will dealer may be able to intervene, requesting that the probably not be able to dump the solution in the sewage damaged unit be returned and a new unit delivered.

  • Page 4: Controls Operation

    CONTROLS / OPERATION INSTALLATION Your parts washer is designed to clean parts (removing contaminants such as oil, grease, dirt, etc…) with a recirculated detergent and water solution. The washer cleans with a combination of mechanical force DANGER! (140-160F), and the chemical action of the detergent. This machine utilizes high voltage.

  • Page 5: Start-Up Procedure

    1 hour. Otherwise, rust may occur. Ranger Products does not warranty their product against Before turning on the electric power, make sure the rust. Rust will occur if the wrong detergent is used, if the heat and wash timers are off.
  • Page 6 Open the door, stand back, and turn on the spray pump. If it comes on, BendPak, Inc. / Ranger Products do not use the machine. Call your dealer. 1645 Lemonwood Dr., 7.

  • Page 7: Maintenance

    MAINTENANCE REMOVING SLUDGE FROM THE TANK Assign the responsibility for your parts washer to one person to avoid abuse and neglect. Daily: Check the water level, which should be inside the fiter basket. Never allow the water level to get below the filter basket.

  • Page 8: Troubleshooting Guide

    TROUBLE SHOOTING GUIDE SYMPTOM PROBLEM / REMEDY Nothing works-heat or pump Breaker is off, no power to machine Check all control fuses Cleaning is poor Wrong detergent, low detergent concentration or hard water Clogged nozzles Solution is too dirty Solution is not hot (see below) Low output from pump (see below) Solution won’t get hot One or more heating elements are bad...
  • Page 15 5155090 Ranger TM Aluma-Klean 125 lb Bucket 780 Gal Spray Wash Detergent 5155085 Ranger TM Aluma-Klean 300 lb Bucket 1750 Gal Spray Wash Detergent 5155080 Ranger TM Aluma-Klean 500 lb Bucket 2900 Gal Contact your Ranger Products Distributor for pricing.
  • Page 16 For Parts Or Service Contact: BendPak Inc. / Ranger Products 1645 Lemonwood Dr. Santa Paula, CA. 93060 Tel: 1-805-933-9970 Toll Free: 1-800-253-2363 Fax: 1-805-933-9160 www.bendpak.com www.rangerproducts.com pn#5900121...

This manual is also suitable for:

Rs-750

Table of Contents

Save PDF