Related Manuals for Audion Elektro SEALKID
Summary of Contents for Audion Elektro SEALKID
- Page 1 English Quick Start Guide For the complete operating manual, please refer to www.audion.com. Sealkid SK 236/321/421/621 QSG SK 236-621 Eng Rev.15...
- Page 2 (incorrect) interpretation of its contents. Audion Elektro BV is not liable for any damage or problems resulting from the use of any other than original parts. If this operating manual does not provide instructions for certain repairs,...
- Page 3 Quick Start Guide...
-
Page 4: Table Of Contents
Connecting the sealer ......... . . 13 Description Sealkid . -
Page 5: Introduction
Internet: www.audion.com 1.2 Machine type plate Figure 1-1: Machine type plate of the Sealkid The sealer has an EC mark. This means that the sealer satisfies the fundamental health and safety requirements of the European Communities. 1.3 Warranty Audion provides a 12-month warranty on the sealer. This warranty is limited to any manufacturing defects. -
Page 6: Safety
Quick Start Guide 2 Safety 2.1 Symbols used in this manual In this user manual, the following symbols are used: A tip to perform a task in a more convenient manner. Instructions for carrying out a task in the correct manner. Danger of injury to the user or damage to the sealer if the instructions are not carried out carefully. -
Page 7: User
Sealkid Quick Start Guide SK 236/321/421/621 2.2 User The sealer may only be operated by authorised personnel. Unskilled use of the sealer may lead to serious personal injury and considerable material damage. Keep bystanders at a distance. Do NOT allow unauthorised personnel to operate the sealer. -
Page 8: Safety Instructions
Quick Start Guide 2.3 Safety instructions The sealer meets the fundamental health and safety requirements of the European Community. This means that the sealer can be operated and maintained safely if all safety instructions are carefully observed. However, improper or careless use may give rise to dangerous situations. -
Page 9: What To Do In Case Of Fire
Sealkid Quick Start Guide SK 236/321/421/621 • While the machine is being used, both the user and the machine must be under observation. • Do not switch the machine back on until the malfunction has been repaired. • Should any liquid or foreign body enter the machine, switch off the machine and immediately remove the plug from the socket and have the machine checked by maintenance personnel before using it again. -
Page 10: Uses For Special Applications
Quick Start Guide 2.3.3 Uses for special applications If the machine is used in a specialistic environment, the company using the machine is responsible for making sure any specific instructions that apply are observed. • If the machine is used in a medically sterile environment or cleanroom, the company using the machine is responsible for making sure any specific instructions that apply there are observed. -
Page 11: Installation
2. Does the box contain a user manual? - Make sure the user manual for the right type was included. Only Sealkid 621: 3. Does the box contain a power cord? - Make sure a separate power cord has been included in the delivery. -
Page 12: Adjusting The Handle
Quick Start Guide 3.2 Adjusting the handle 1. Loosen the screw. 2. Slide the handle towards the end of the top bar. 3. Tighten the screw again. It should be impossible to slide the handle now. Installation... -
Page 13: Connecting The Sealer
Sealkid Quick Start Guide SK 236/321/421/621 3.3 Connecting the sealer Only Sealkid 621: 1. Connect the female plug of the power cord up to the Sealkid. 2. Put the plug into the socket. Installation... -
Page 14: Description Sealkid
Quick Start Guide 4 Description Sealkid 4.1 Function The Sealkid is a manual sealer for PE film and thin laminate films with a thickness between 20μm and 150μm. Do not use the Sealkid for any other applications. The sealer is not suitable for applications that include the following: •... -
Page 15: Control Panel
After the preset sealing time, the heating of the sealing wire is automatically switched off and the indicator light will go off as well. Description Sealkid... -
Page 16: Operation
Quick Start Guide 5 Operation If necessary, put the plug into the socket. During use, the seal bar gets hot - contact may cause serious burns. For operating instructions of the use of tubular film, refer to the complete user manual on www.audion.com. 5.1 Sealing of film bags Perform the following actions to seal a film bag: 1. -
Page 17: Setting The Sealing Time
Sealkid Quick Start Guide SK 236/321/421/621 4. Take the film bag from the seal bar. The Sealkid is now ready to make the next seal. Remove the plug from the socket when the Sealkid is not being used for a while. -
Page 18: Troubleshooting
Quick Start Guide 6 Troubleshooting Troubleshooting only performed authorised maintenance personnel. If a malfunction occurs, always pull the plug from the socket first, before attempting to solve the problem. If the problem cannot be solved using the troubleshooting table below, please contact your dealer or Audion. additional instructions about... -
Page 19: Maintenance
Sealkid Quick Start Guide SK 236/321/421/621 7 Maintenance Maintenance may only be performed by authorised maintenance personnel. Always pull the plug from the socket first, before carrying out any maintenance work. Do not use any water, abrasive cleaning agents, chemical solvents or other liquids when cleaning the machine. -
Page 20: Maintenance Schedule
Quick Start Guide 7.1 Maintenance schedule 7.1.1 Weekly maintenance Weekly maintenance may be carried out by the operating personnel (see foreword). Part Work Machine Clean the machine by means of a damp cloth and mild detergent (e.g. all-purpose cleaner). Sealing wires Check whether the sealing wire shows signs of damage. -
Page 21: Annex 1 Ce Declaration
Quick Start Guide Annex 1 CE declaration AUDION ELEKTRO B.V., located at the Hogeweyselaan 235 in Weesp, The Netherlands herewith declares that the SEALKID Type: 236 SK-2 ; 321 SK-2 ; 421 SK-2 ; 621 SK-2 is in conformity with the provisions of the following EEC directives: 2014/35/EU Low Voltage Directive ;... - Page 22 Represented by: Audion Elektro BV Hogeweyselaan 235 1382 JL Weesp Tel +31 (0)294 491717 Fax +31 (0)294 491761 E-mail holland@audion.nl www.audion.com...
Need help?
Do you have a question about the SEALKID and is the answer not in the manual?
Questions and answers