Table of Contents
Advertisement
Quick Links
2019-0967
2019-10-09
Installation and Operation Manual
Zodiac Aquapure Ei Series APURE35C
Maximum Overcurrent Protection - 15A
Use Copper Conductors Only
Disconnect Power before Opening Service Cover
For Outdoor or Indoor Use
Electrical Requirements: 120/240 VAC 50/60 Hz 3
WIRE, 1.3 AMP
Maximum Output of Hypochlorous Acid is Equivalent to 420 g
of Free Available Chlorine Per Day
4,000 parts per million of salt
The maximum volume of water that can be treated with
one unit of APURE35C is 132,000 litres
(35,000 gallons) (132.0 m
For swimming pools, a range of 1-3 ppm of free available
chlorine must be maintained.
Controls bacteria and algae in swimming pool water.
Do not use this device with bromide products.
BUILDER/INSTALLER: Please leave this manual with the pool owner.
POOL OWNER: Please save this manual.
FOR YOUR SAFETY - This product must be installed and serviced by a contractor who is licensed and qualified in pool
equipment by the jurisdiction in which the product will be installed where such local requirements exists. In the event no such
local requirement exists, the installer or maintainer must be a professional with sufficient experience in pool equipment
installation and maintenance so that all of the instructions in this manual can be followed exactly. Before installing this
product, read and follow all warning notices and instructions that accompany this product. Failure to follow warning notices
and instructions may result in property damage, personal injury, or death. Improper installation and/or operation will void
the warranty.
Improper installation and/or operation can create unwanted electrical hazard which can cause serious injury, property
damage, or death.
by Zodiac Pool Systems, Inc
Vista, California, 92081 USA
In US: (800) 822-7933 • In Canada (888) 647-4004
Swimming pool algicide/bactericide
Chlorine Generating Device
REGISTRATION NO. 30232 PEST CONTROL PRODUCTS ACT
Installation and Operation Manual
READ THE LABEL AND OPERATION MANUAL BEFORE USING
KEEP OUT OF REACH OF CHILDREN
3
)
2620 Commerce Way
www.ZodiacPoolSystems.com
For Residential Pools
DOMESTIC
WARNING
.
P a g e
| 1
Advertisement
Table of Contents
Related Manuals for Zodiac Pool Systems Ei Series
Summary of Contents for Zodiac Pool Systems Ei Series
- Page 1 2019-0967 2019-10-09 P a g e Installation and Operation Manual Zodiac Aquapure Ei Series APURE35C by Zodiac Pool Systems, Inc 2620 Commerce Way Vista, California, 92081 USA In US: (800) 822-7933 • In Canada (888) 647-4004 www.ZodiacPoolSystems.com Swimming pool algicide/bactericide...
- Page 2 P a g e Operating Zodiac Aquapure Ei Series APURE35C models without water flow through the cell can cause a buildup of flammable gases which can result in FIRE OR EXPLOSION. KEEP OUT OF REACH OF CHILDREN Notice to User This pest control product is to be used only in accordance with the directions on the label.
-
Page 3: Table Of Contents
Section 1. Important Safety Instructions ..... 5 Section 2. System Description ....... 8 Product Specifications (Zodiac Aquapure Ei Series APURE35C) ....8 Product Contents ............9 Section 3. Installation Instructions ..... 10 Materials and Tools ..........10 Installation Requirements ........10 Installing the Power Pack and Cell ...... - Page 4 P a g e Control Panel ............24 Turning Power Pack On/Off (Manually) ....24 Turning Power Pack On/Off (Using the Pump’s External Timer) ...... 24 Setting the Chlorine Output Level ......24 Connection to an AquaLink RS / PDA Control System ............
- Page 5 P a g e Figure 23. New Pool Plumbing for In-Floor Systems ..... 18 Figure 24. Example of Alternative Installation ..Figure 25. Control Panel on the Power Pack ..Figure 26. Undo Locking Ring ........ Figure 27. Remove the Cell ........Figure 28.
-
Page 6: Important Safety Instructions
To reduce the risk of electric shock, fire or injury, service should only be attempted by a qualified pool service professional. WARNING Zodiac AquaPure Ei Series APURE35C chlorine generating devices are designed for domestic (residential) swimming pool use only. Contrary use could affect performance, void warranty, and may result in property damage, serious injury, or death. - Page 7 WARNING Operating the Zodiac AquaPure Ei Series APURE35C chlorine generating device without water flow through the electrolytic cell can cause a buildup of flammable gasses which can result in FIRE OR EXPLOSION.
- Page 8 (e.g. acids, chlorine, salt, stabilizers, etc.). • Zodiac Pool Systems, Inc. does not warrant or guarantee that the chlorinated water generated by the Zodiac AquaPure Ei Series APURE35C chlorine generating device will not damage or destroy certain types of plants, decking, coping and other materials in and around your pool and/or spa.
- Page 9 P a g e Careful selection of masonry products. The porosity and hardness of natural stones varies greatly. Therefore we • recommend you consult with your builder or stone contractor on the best choice for stone materials around your pool or spa. •...
-
Page 10: System Description
| 10 P a g e Section 2. System Description Product Specifications (Zodiac AquaPure Ei Series APURE35C) Maximum Operating Pressure: 50 psi Input Freq: 47~63 Hz Minimum Flow Rate: 152 L/min (40 gpm) Output Voltage: 25V DC (max) Maximum Flow Rate: 348 L/min (92 gpm) Output Current: 5A DC Required Salt Level: 4,000 ppm (4.0 gpl) -
Page 11: Installation Instructions
Installation Requirements WARNING The Zodiac AquaPure Ei Series APURE35C chlorine generating device must be installed horizontally with the cell above the pipe to avoid buildup of flammable gases which can result in FIRE OR EXPLOSION. The installation requirements for the Zodiac AquaPure Ei Series APURE35C chlorine generating device are as follows: •... -
Page 12: Installing The Power Pack And Cell
Installing the Power Pack and Cell WARNING If you are installing the Zodiac AquaPure Ei Series APURE35C to a Goldline adaptor, it is necessary to disconnect the power to the Goldline controller. Zodiac recommends that any procedure requiring potential contact with live electrical wiring and/or parts other than cords and plugs connected to electrical outlets, be completed by a contractor who is licensed and qualified in pool equipment as described on the front cover of this manual. -
Page 13: Wiring The Power Pack To Power Source
The AquaLink RS or PDA is a multi-function pool controller which can fully control the function of the Zodiac AquaPure Ei Series APURE35C chlorine generating device. Adjustment of the chlorine production rate can be controlled from the main menu of the AquaLink RS or PDA. The AquaLink RS or PDA offers individual pool and spa settings for output percentage. -
Page 14: 3.6.1 Verify The Controller Type On The Power Pack Is Set Correctly
| 14 P a g e 3.6.1 Verify the Controller Type on the Power Pack is Set Correctly Before wiring to an AquaLink RS Control System, the controller type must be set to JANDY L/M to allow communication between the power pack and the AquaLink RS Control System. The default controller type setting on the power pack is Jandy L/M. -
Page 15: 3.6.3 Testing The Connection
| 15 P a g e ® In the AquaLink RS or PDA power center, wire the power pack directly to the LOAD SIDE of the filter pump relay (see Figure 20). ® The Jandy AquaLink RS or PDA and power pack use a four (4) wire connection to communicate and can be wired up to 152.4 m (500 ft) apart. -
Page 16: Pool Water Preparation
Super Chlorination is accomplished by raising the chlorine level quickly and dramatically. To super chlorinate the pool using the Zodiac AquaPure Ei Series APURE35C chlorine generating device, set the chlorine production to 100% and then set the pump and the cell to run for 24 hours. - Page 17 (e.g. acids, chlorine, salt, stabilizers, etc.). Zodiac Pool Systems, Inc. does not warrant or guarantee that the chlorinated water generated by the Zodiac AquaPure Ei Series APURE35C chlorine generating device will not damage or destroy certain types of plants, decking, coping and other materials in and around your pool and/or spa.
-
Page 18: Optimum Pool Water Conditions
The Zodiac AquaPure Ei Series APURE35C is warranted to operate properly only if the following conditions are met: Free Available Chlorine 1.0 - 3.0 ppm. -
Page 19: How Much Salt To Use
(e.g. acids, chlorine, salt, stabilizers, etc.). Zodiac Pool Systems, Inc. does not warrant or guarantee that the chlorinated water generated by the Zodiac AquaPure Ei Series APURE35C chlorine generating device will not damage or destroy certain types of plants, decking, coping and other materials in and around your pool and/or spa. - Page 20 | 20 P a g e IMPORTANT - Turn the power pack off by pressing the ON/Off button (OFF will be displayed on the screen). Test the water for salinity level using test strips, electronic meter, or by your local pool professional. Use the Table 1 to determine the amount of salt to add.
- Page 21 | 21 P a g e Table 2. Approximate Kilograms (Pounds) of Stabilizer Needed to Obtain 50 ppm Current Pool/Spa Size Litres (US gallons) Cyanuric Acid Level - 38,000 L 57,000 L 76,000 L 95,000 L 114,000 L 132,000 L (20,000 gal) (10,000 gal) (15,000 gal)
-
Page 22: Operating Instructions
RS / PDA Control System The Zodiac AquaPure Ei Series APURE35C chlorine generating device can be connected to an AquaLink RS or PDA Control System (see Section 3.5 and 3.6). For detailed instructions for the AquaLink RS or PDA Control System, see the respective manuals. - Page 23 | 23 P a g e WARNING • When cleaning the cell, wear protective eyeglasses and gloves. • When mixing acid with water, ALWAYS ADD ACID TO WATER. NEVER ADD WATER TO ACID. The power pack is fitted with a rechargeable battery which can last in excess of 500 hours without the power being connected.
-
Page 24: Maintenance Instructions
| 24 P a g e Section 6. Maintenance Instructions Before servicing the Zodiac AquaPure Ei Series APURE35C chlorine generating device please ensure you have read and understood the Important Safety Instructions section. IMPORTANT Always test the chlorine levels of your pool before each use. -
Page 25: Cleaning The Cell
Scale will form in excessively hard water or from pool water that is out of balance and in a scaling condition. Following the installation of the Zodiac AquaPure Ei Series APURE35C chlorine generating device, check the cell once a month for signs of scale. -
Page 26: Winterizing
| 26 P a g e Winterizing NOTE Do not use Ethylene Glycol (anti-freeze) in the system. Very little chlorine is needed in cold water. Operating the chlorinator below 11°C (51°F) is not recommended. Operating the chlorinator in cold water can shorten the life of the cell. If preventative measures are not taken, freezing water may cause severe damage to the cell. -
Page 27: Troubleshooting
| 27 P a g e Section 7. Troubleshooting Problems and Corrective Action Problem Possible Cause Corrective Action Low or no chlorine. Low stabilizer (cyanuric acid) level in pool Add stabilizer to maintain 10 - 50 ppm water (for outdoor pools only). (see Table 2). - Page 28 | 28 P a g e Problem Possible Cause Corrective Action Chlorine level too high. Chlorine output percentage set too high. Decrease the chlorine production rate by pressing the Output button (see Section 5.4). Power pack and cell turned on too long. If chlorine output is set at the lowest setting and it consistently provides excessive chlorine levels, decrease operation time as much as necessary.
- Page 29 | 29 P a g e Salt light is on and the display says “Check Salt Salt level is well below 3,000 Maintain a salinity level of or Low Temperature”. ppm, depending on water 4,000 ppm - 4,500 ppm temperature. (see Section 4.6 or contact NOTE The Salt light will turn on...
- Page 30 | 30 P a g e 4,000 ppm - 4,500 ppm (see Section 4.6.3). Heavy rainfall diluted the pool Add salt to pool until salinity returns to water. 4,000 ppm - 4,500 ppm (see Section 4.6.3). Leak in pool. Repair pool. Problem Possible Cause Corrective Action...
-
Page 31: Replacement Parts And Exploded Views
| 31 P a g e Section 8.Replacement Parts and Exploded Views Parts List Key No. Description Order Part No. Cell R-Kit, Terminal Cap, APURE Ei R0511200 R-Kit, Locking Ring R0511300 R-Kit, Electrode, APURE Ei 35 R0511400 R-Kit, O-Ring, Electrode Housing R0511600 R-Kit, Saddle Clamp Assy, APURE Ei R0511700... -
Page 32: Exploded Views
2620 Commerce Way, Vista, CA 92081 1.800.822.7933 | www.ZodiacPoolSystems.com ® ZODIAC is a registered trademark of Zodiac International, S.A.S.U., used under license. All trademarks referenced herein are the property of their respective owners. ©2011 Zodiac Pool Systems, Inc. H0368100 Rev- 1109... - Page 33 FIRE OR EXPLOSION. KEEP OUT OF REACH OF CHILDREN. The maximum volume of water that can be treated with one unit of model Zodiac AquaPure Ei Series APURE35C is 132,000 litres (132 m3).
- Page 34 Registration Number s 30232 PEST CONTROL PRODUCTS ACT. This cell must be only used on this model of chlorine generating device. Read the label, Installation and Operating Manual of the chlorine generating device Zodiac AquaPure Ei Series Zodiac AquaPure Ei Series APURE35C before using.