Table of Contents
Advertisement
Quick Links
INSTALLER:
Leave this manual with the appliance.
CONSUMER:
Retain this manual for future reference.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, leave the area
immediately.
4. After leaving the area, call your gas
supplier or fire department.
Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury, or death.
WARNING
Improper installation, adjustment, alteration,
service or maintenance can cause injury
or property damage. Read the installation,
operating and maintenance instructions
thoroughly before installing or servicing this
equipment.
WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
An Propane-cylinder not connected for use
shall not be stored in the vicinity of this or
any other appliance.
DANGER
INSTALLATION INSTRUCTIONS
AND OWNER'S MANUAL
OUTDOOR
VENTLESS DECORATIVE
APPLIANCE INTERMITTENT
IGNITION MODELS:
OLI-24-2
For Outdoor Use Only.
Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
If the information in these instructions are not followed
exactly, a fire or explosion may result causing property
damage, personal injury or loss of life.
If not installed, operated and maintained in accordance
with the manufacturer's instructions, this product
could expose you to substances in fuel or from fuel
combustion which can cause death or serious illness.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent, car or home.
OLI-30-2
GAS-FIRED
WARNING
WARNING
WARNING
Page 1
Advertisement
Table of Contents
Related Manuals for Empire OLI-24-2
Summary of Contents for Empire OLI-24-2
- Page 1 OUTDOOR Leave this manual with the appliance. VENTLESS DECORATIVE CONSUMER: APPLIANCE INTERMITTENT Retain this manual for future reference. IGNITION MODELS: OLI-24-2 OLI-30-2 DANGER GAS-FIRED FIRE OR EXPLOSION HAZARD If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame.
-
Page 2: Propane Gas Cylinder Information
PROPANE GAS CyLINDER INFORMATION DANGER - FLAMMABLE GAS UNDER PRESSURE. LEAKING LP-GAS MAy CAUSE A FIRE OR EXPLOSION IF IGNITED CAUSING SERIOUS BODILy INJURy OR DEATH. CONTACT LP GAS SUPPLIER FOR REPAIRS, OR DISPOSAL OF THIS CyLINDER OR UNUSED PROPANE-GAS. WARNING - FOR OUTDOOR USE ONLy.* DO NOT USE OR STORE CyLINDER IN A BUILDING,... -
Page 3: Table Of Contents
TABLE OF CONTENTS SECTION PAGE Propane Gas Cylinder Information .......................2 Carton Contents ............................4 Safety Information for Users of Propane Gas....................5 Introduction ..............................6 - 8 General Information ............................8 Clearances ..............................9 Specifications ...............................9 Before Fully Installing the Appliance......................9 Gas Supply ..............................10 Operation Instructions/Flame Appearance ....................11 OLI-(24,30) Lighting Instructions ........................12 Main Burner Flame Characteristics ......................13 Cleaning and Servicing..........................13 Wiring .................................13... -
Page 4: Carton Contents
CARTON CONTENTS CARTON CONTENTS HARDWARE PACK CONTENTS MODEL 1 Description Concrete Anchor Screws Quantity Index Number Description Supplied AA Battery Burner Assembly Battery Pack Remote Control w/Battery Hardware Pack Page 4 37139-8-1219... -
Page 5: Safety Information For Users Of Propane Gas
SAFETy INFORMATION FOR USERS OF PROPANE GAS Propane is a flammable gas which can cause fires and explo- members of your household. Someday when there may not sions. In its natural state, propane is odorless and colorless. be a minute to lose, everyone's safety will depend on knowing you may not know all the following safety precautions which exactly what to do. -
Page 6: Introduction
2. Installer must have owner fill out and mail warranty card supplied When installed on exterior walls: Empire Comfort Systems with the fireplace. recommends the fireplace chase be constructed outside the 3. Installer should show owner how to start and operate the fireplace. structure's weather envelope. Where the platform meets the wall, use a flashing detail similar to that required for attached decks. Chase... - Page 7 INTRODUCTION Qualified Installing Agency • For appliances for fixed fuel piping system and equipped Installation and replacement of gas piping, gas utilization equipment with an appliance gas pressure regulator, the appliance and or accessories and repair and servicing of equipment shall be its individual shut-off valve must be disconnected from the performed only by a qualified agency. The term "qualified agency"...
-
Page 8: General Information
INTRODUCTION 2. Ventilation opening(s) shall be provided at floor • Cylinder valves shall be readily accessible for hand opera- level and shall have a total free area of not less tion. A door on the enclosure to gain access to the cylinder than 1/2 square inch per pound (3.2 sq. cm/kg) of valves is acceptable, provided it is non-locking and can be stored fuel capacity and not less than a total free opened without the use of tools. -
Page 9: Clearances
CLEARANCES Minimum Dimensions For Solid Fuel Burning Fireplaces Model OLI-24 28" 9 /16 " 5 /16 " 3 /16 " OLI-30 32" 9 /16 " 5 /16 " 3 /16 " The dimensions shown and defined in the fireplace instructions are minimum clearances to maintain in installing this heater. Left and right clearances are determined when facing the front of the heater. -
Page 10: Gas Supply
GAS SUPPLy Check all local codes for requirements, especially for the size and type of gas supply line required. RECOMMENDED GAS PIPE DIAMETER Schedule 40 Pipe Tubing, Type L Pipe Inside Diameter Outside Diameter Length Natural Propane Natural Propane 0-10 feet 1/2”... -
Page 11: Operation Instructions/Flame Appearance
OPERATION INSTRUCTIONS/FLAME APPEARANCE NOTICE: all flames will be random by design, flame height will go up and down. During manufacturing, fabricating and shipping, various components of this appliance are treated with certain oils, films or bonding agents. These chemicals are not harmful, but may produce annoying smoke and smells as they are burned off during the initial operation of the appliance, possibly causing headaches or eye or lung irritation. This is a normal and temporary occurrence. -
Page 12: Oli-(24,30) Lighting Instructions
OLI-(24,30) LIGHTING INSTRUCTIONS FOR yOUR SAFETy READ BEFORE LIGHTING WARNING If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. BEFORE LIGHTING, smell around the appliance area for B. -
Page 13: Main Burner Flame Characteristics
MAIN BURNER FLAME CHARACTERISTICS Main Burner Flame Pattern Main Burner Flame Ignition and Extinction The main burner flame will be completely yellow. When the main burner is ignited it will take a few seconds for the full flame pattern to develop. When the main burner is extinguished it will take a few seconds for the flames to disappear. -
Page 14: Remote Control Installation And Operation
REMOTE CONTROL INSTALLATION & OPERATION TWO-FUNCTION WIRELESS REMOTE CONTROL SySTEM FOR ON/OFF-HI/LO OPERATION OF THE AF-4000 GAS CONTROL VALVE IF yOU CANNOT READ OR UNDERSTAND THESE INSTALLATION INSTRUCTIONS DO NOT ATTEMPT TO OPERATE INTRODUCTION This remote control system was developed to provide a safe, reliable, and user-friendly remote control system for use with the AF-4000 gas control valve used with some gas heating appliances. The system operates on radio frequencies (RF) within a 20’ range using non- directional signals. -
Page 15: Parts View
PARTS VIEW PARTS LIST PART NO. INDEX NO. DESCRIPTION OLI24 OLI30 28103 28105 Top Cover 28084 28084 Inlet Tubing P212 P212 Orifice Holder P245 P265 Orifice - Propane P209 P209 Orifice - Natural R10808 R10808 Air Shutter 28739 28740 Burner with Bracket R10814 R10814 Spark Probe 28089 28089 Valve Shield... -
Page 16: Fireplace Service History
FIREPLACE SERVICE HISTORy Date Dealer Name Service Technician Name Service Performed/Notes Page 16 37139-8-1219... - Page 17 FIREPLACE SERVICE HISTORy Date Dealer Name Service Technician Name Service Performed/Notes 37139-8-1219 Page 17...
-
Page 18: Master Parts Distributor List
MASTER PARTS DISTRIBUTOR LIST To Order Parts Under Warranty, please contact your local Empire dealer. See the dealer locator at www.empirecomfort. com. To provide warranty service, your dealer will need your name and address, purchase date and serial number, and the nature of the problem with the unit. -
Page 19: Warranty Terms
WARRANTy TERMS Empire Comfort Systems Inc. warranties this hearth product to be free from defects at the time of purchase and for the periods specified below. Hearth products must be installed by a qualified technician and must be maintained and operated safely, in accordance with the instructions in the owner’s manual. This warranty applies to the original purchaser only and is not transferable. All warranty repairs must be accomplished by a qualified gas appliance technician. - Page 20 Empire Comfort Systems Inc. Belleville, IL If you have a general question about our products, please e-mail us at info@empirecomfort.com. If you have a service or repair question, please contact your dealer. www.empirecomfort.com Page 20 37139-8-1219...