Toro LT-F3000 Operator's Manual
Hide thumbs
Also See for LT-F3000:
- Operator's manual (68 pages) ,
- Installation instructions manual (20 pages) ,
- Addendum (4 pages)
Related Manuals for Toro LT-F3000
Summary of Contents for Toro LT-F3000
- Page 1 Form No. 3443-356 Rev A Full Weather Cab LT-F3000 Triple Flail Mower or LT3340 4 Wheel Drive Triple Reel Mower Model No. 02955—Serial No. 400000000 and Up *3443-356* Register at www.Toro.com. Original Instructions (EN)
-
Page 2: Table Of Contents
Controls ............. 5 a dealer, or to register your product. Specifications ............ 7 Whenever you need service, genuine Toro parts, or Attachments/Accessories ........7 additional information, contact an authorized Toro Operation ..............7 distributor or Toro Customer Service and have the Using the Sunshade ........... -
Page 3: Safety
Manual for advice and guidance when operating a mower on slopes. To ensure optimum performance and continued safety certification of the machine, use only genuine Toro replacement parts and accessories. Replacement parts and accessories made by other manufacturers could be dangerous, and such use could void the product warranty. - Page 4 decal134-6005 134-6005 1. Warning—read the Operator’s Manual; when sitting in the 3. Tipping hazard—lower attachments when operating on hills/slopes; drive slowly when turning; do not turn sharply cab, always wear a seat belt; wear hearing protection; remove the key from the ignition before performing maintenance. while traveling fast;...
-
Page 5: Product Overview
Screen Wiper and Washer Switch Product Overview The switch is mounted on the left side in the roof lining. g018467 Figure 5 1. Screen wiper/washer switch g350665 Figure 3 1. Wiper 3. Rearview mirrors 2. Adjustable lower 4. Door and locking handle windscreen Controls Blower Controls... - Page 6 Interior Light Switch Rear Window Handle and Prop You can open the rear window for ventilation. Rotate Press the front of the interior light switch (Figure 6) to turn on the light. Press the rear of the switch to turn the rear window prop to hold the window open (Figure off the light.
-
Page 7: Specifications
To ensure optimum performance and continued safety certification of the machine, use only genuine Toro replacement parts and accessories. Replacement parts and accessories made by other manufacturers could be dangerous, and such use could void the... -
Page 8: Operating The Heating And Air-Conditioning System
Operating the Heating and Operating the Windscreen Air-Conditioning System Wiper and Washer Press the right side of the switch to run the Important: To prevent the battery discharge, windscreen wipers (Figure 12). ensure the air-conditioner switch is in the O position before you shut off the engine. -
Page 9: Operating The Windows
g347397 Figure 13 1. Cap (windscreen wash tank) Fill the wash tank with clean water and the recommended quantity of windscreen-wash g347572 fluid. Figure 14 Install the cap to the wash tank (Figure 13). 1. Latch handle 3. Socket Close and latch the hood. 2. -
Page 10: Operating The Doors
Adjusting the Rear Window Opening and Closing the Rear Window • To open the rear window, rotate the latch handle (Figure 16) counterclockwise. Note: The gas/spring cylinder pushes the window fully open. g347755 Figure 17 2. Window latch 1. Pin (prop rod) Rotate the window prop to the window latch, and align the pin of the rod through the hole in the handle... -
Page 11: Adjusting The Mirrors
To open the door from inside the cab, pull back on the door lock release lever while opening the door (Figure 19). g020353 Figure 19 1. Door lock 2. Release lever Adjusting the Mirrors While the sitting in the seat, have a another person adjust the side-view mirrors to provide you the best view along the side of the machine (Figure... -
Page 12: Maintenance
Remove the key from the ignition before you do any maintenance. Important: Maintenance or repairs on the heating system should be carried out by an authorized Toro distributor or a specialist in vehicle heating systems. Important: All work on the refrigerant part of the air-conditioning system should be carried out by qualified personnel. -
Page 13: Preparing For Maintenance
Important: Do not spill compressor oil on the vehicle surface. It can cause discoloration of vehicle paint and deterioration of acrylic or ABS plastic components. • When attaching the refrigerant hoses, oil the sealing rings with refrigerant oil. • After removal of refrigerant hoses from the air-conditioner system, always replace the O-rings with new ones specified for refrigerant 134A. -
Page 14: Locating The Fuses
bracket to the beam bracket with a latch pin and Insert the 2 latch pins (Figure 24) through the hairpin. holes in the cab-frame flanges and cross-beam brackets. Note: If the latch pins are difficult to insert, move the handles of the latch pins back and forth to help align the pins to the flange holes and beam bracket holes. -
Page 15: Checking The Air-Conditioner Compressor Clutch
g347426 Figure 29 1. Temperature control 2. Air-conditioner switch At the back of the machine, listen for the g350748 compressor clutch (Figure 30) engaging and Figure 27 disengaging (clicking). 1. 3 A (constant 5. 7.5 Amp (washer/wiper) power—radio and interior light) 2. -
Page 16: Installing The Roof
33). If there are more that the occasional bubble seen Checking the Refrigerant through the sight glass, contact your authorized Toro distributor for service. Level Note: If you see an occasional air bubble, Service Interval: Monthly (using the sight glass). -
Page 17: Checking The Drain Tubes
Checking the Examine the fins of the condenser and evaporator for accumulating dust and debris. Compressor-Fan Belt Service Interval: Every 500 hours Unlatch and open the hood (Figure 36). g350713 Figure 34 3. Fan wire harness 1. Back of the machine 2. -
Page 18: Checking The Refrigerant Pressure
Outside Low-Pressure High-Pressure Side Side Temperature Always use genuine Toro spare parts when repairing or servicing the air-conditioning system. 20° C (68° F) 1.7 to 2.1 bar 10 to 14 bar (24.7 to 30.5 psi) (145 to 203 psi) Washing the Machine and 25°... -
Page 19: Storage
Storage Refer to the traction unit Operator’s Manual for details on storing the machine. -
Page 20: Schematics
Schematics g350749 Radial blower Expansion valve Evaporator (combined with heat exchanger for heating) Evaporator—water drain Compressor Condenser Axial fans Dryer/filter Sight glass Drain A/C System Schematic (Rev. A) - Page 21 g350760 Hot water heating valve Compressor with magnetic clutch Twin axial rear fans Temperature sensor Electronic-regulator/temperature-control Radial blower fan Blower-speed switch Pressure switch A/C switch Relay Fuse (15 A)—position 4 Fuse (5 A)—position 7 Fuse (5 A)—position 6 Fuse (25 A)—position 3 A/C Electrical Schematic (Rev.
- Page 22 g350761 Constant power—radio and interior light Interior lights circuit Switched power—radio Washer/wiper License-plate light Flashing beacon Machine wire harness interface Fuse block Fuse (7.5 A)—position 5 Fuse (10 A)—position 2 Fuse (3 A)—position 1 Washer pump Washer/wiper switch Wiper motor Cab Electrical Schematic (Rev.
- Page 23 Notes:...
- Page 24 Notes:...
- Page 25 The method of transmission shall be electronic transmittal. This machinery shall not be put into service until incorporated into approved Toro models as indicated on the associated Declaration of Conformity and in accordance with all instructions, whereby it can be declared in conformity with all relevant Directives.
- Page 26 The Toro Company (“Toro”) respects your privacy. When you purchase our products, we may collect certain personal information about you, either directly from you or through your local Toro company or dealer. Toro uses this information to fulfil contractual obligations - such as to register your warranty, process your warranty claim or to contact you in the event of a product recall - and for legitimate business purposes - such as to gauge customer satisfaction, improve our products or provide you with product information which may be of interest.
- Page 27 Countries Other than the United States or Canada Customers who have purchased Toro products exported from the United States or Canada should contact their Toro Distributor (Dealer) to obtain guarantee policies for your country, province, or state. If for any reason you are dissatisfied with your Distributor's service or have difficulty obtaining guarantee information, contact your Authorized Toro Service Center.