Advertisement
Quick Links
SAFETY NOTICE
If this solid fuel room heater is not properly
installed, assembled and used, a house
fire may result. For your safety, follow
the installation directions. Contact local
building or fire officials about restrictions
and installation inspection requirements in
your area.
CAUTION
Tested and approved to use with dry, seasoned
wood only. Do not burn wet or green wood.
Burning any other type of fuel may be a danger
and will void your warranty.
Marcello
Wood-Burning Soapstone Stove
Installation, and Operating Manual
INSTALLER: Leave this manual with the party
responsible for use and operation.
OWNER: Save this manual for future reference.
Do not discard!
QUESTIONS: Call your Authorized Dealer.
Please read this entire manual before
installation and use of this wood-burning
room heater. Failure to follow these
instructions could result in property
damage, bodily injury, or even death.
1. Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2. Do not overfire - If any external part
starts to glow, you are overfiring. Close
air controls. Overfiring will void your
warranty.
3. Comply with all minimum clearances to
combustibles as specified.
WARNING
1
Advertisement
Related Manuals for NORSK KLEBER Marcello
Summary of Contents for NORSK KLEBER Marcello
- Page 1 Marcello Wood-Burning Soapstone Stove Installation, and Operating Manual INSTALLER: Leave this manual with the party responsible for use and operation. OWNER: Save this manual for future reference. Do not discard! QUESTIONS: Call your Authorized Dealer. WARNING Please read this entire manual before...
-
Page 2: Table Of Contents
When installed in the same room as the stove, a smoke • The Marcello is Listed to burn solid or detector should be located as far from the stove compressed wood only. Do not burn any other as possible to prevent it from sounding when fuels. -
Page 3: Stove Dimensions
When installing, operating and maintaining your Marcello Soapstone Stove Dimensions • Avoid creating a low pressure condition in the Marcello model, follow the guidelines presented room where the stove is operating. Be aware in these instructions, and make them available to that operation of an exhaust fan or clothes dryer anyone using or servicing the stove. -
Page 4: Design Considerations
Design Considerations When selecting a chimney type and the location for • Brick or modular block must be a minimum of 4” the chimney in the house, keep this in mind: It is the (10 cm) nominal thickness. Stone construction chimney that makes the stove work - not the stove that must be at least 12”... - Page 5 INSTALLATION NORSK KLEBER REQUIRES ALL INSTALLATION AND ASSEMBLY OF THIS STOVE TO BE PERFORMED BY TRAINED PROFESSIONALS. CAUTION: Chimney Flue Sizing Follow these installation instructions in all cases. • The chimney size should not be less than the cross- When installing, operating and maintaining your...
- Page 6 Prefabricated Chimneys • The maximum horizontal run should not exceed Connecting to the Chimney 3 ft. (92 cm) with a 1/4” rise per foot. Under no circumstance should horizontal pipe be allowed to Masonry Chimney When connecting the Babina+ to a prefabricated metal At least 2 ft.
- Page 7 Code for Solid-Fuel Burning Appliances and Consult your local building inspector, authorized Sill/ Equipment, also for acceptable materials, proper sizing Norsk Kleber Dealer, NFPA 211 in the U.S. or Support and construction guidelines. CAN/CSA-B635 in Canada for other approved 36.47 in.
- Page 8 15 inch 381 mm BWC Back Wall to Corner 12 inch 305 mm The Marcello is approved for use with Listed double wall pipe installed to conform to the clearances in Fig. BFC Back Wall Flue Collar 17 inch 432 mm...
-
Page 9: Installation Instructions
Marcello baffle stone 01-28-17 Marcello pillars for burn plate, tall 01-28-18 Marcello rear stone 01-28-25 Marcello top plate for exit, front part 01-28-26 Marcello top pltae for exit, rear part 01-80-30 Black door Marcello Part components in own box 01-00-75... -
Page 10: Exploded View
Marcello 140 Exploded View... -
Page 11: Assembly Manual
Model: Marcello Assembly Manual Before you begin: • Please read and follow the assembly instructions carefully. • Assembly should be done by two people as some of the components are very heavy. • We recommend that you first sort the stones by size and shape. - Page 12 Floor Protection Any floor that is not composed of concrete poured on earth requires protection from sparks and embers. The Babina is approved for installation using one of the following forms of hearth protection: IMPORTANT Any UL, ULC, or Warnock Hersey Listed Type 1 hearth board. • Before beginning assembling the stove, you must determine where the stove will be located.
- Page 13 Exploded view Step 2 Step 1 If you are assembling a stove with two sections below the fire chamber, go to step 2a. 1. Place the base plate on the floor/substrate of 1. Put in place the 30 mm 2-part steel ring non-flammable material.
- Page 14 Step 5 Step 2a Step 3 Sealing cord For stoves with 2 sections below the fire chamber 1. Place the door on the front stone. 1. Tuck the sealing cord down into the Metal sealing strips 2. Put in place two corner stones next to the door track around the fire plate.
- Page 15 Step 6 Step 7 Draft adjustment Step 8 Step 9 Sealing the joints Skamol assembly Sealing joints and seams 1. Disassemble the cover for the draft adjustment. (Use the enclosed 3 mm Allen After applying the silicone sealant to joints with silicone fire sealant 1.
- Page 16 Step 12 Step 13 Step 10 Step11 Skamol assembly Skamol assembly 1. Put in place the rear stones, 2 side stones, 1. Place the two-part Skamol bottom down onto front stones and 2 corner stones. the soap stone plate in the bottom, with the 1.
- Page 17 Step 15 Step 16 1. Place the labyrinth blocks as shown below. 1. Put in place the smoke hood stone. Labryrinth blocks 2. Assemble the side stones and the front stone. 3. Put in place the corner stones. 4. Place the 15 mm 2-part steel ring assembly. 5.
- Page 18 How to use your Norsk Kleber Soapstone Stove CAUTION: Do not use this stove in a manner that is not consistent with these instructions. Failure to do so can result in harm to people and property. Ventilation of the room Floors and walls • The floor on which the stove is mounted must...
- Page 19 A little more about wood Air control settings BURN ONLY SOLID WOOD DIRECTLY ON THE BOTTOM PLATE OF THE STOVE. DO Use dry wood with moisture content of less than 17%. This means that the wood has dried for about 1-2 years. A single lever regulates the primary air flow that NOT ELEVATE THE FIRE IN ANY WAY.
- Page 20 • Before you open the door, place the Air Control Exterior cleaning Cleaning the stove interior Cleaning the glass Lever in the full open position. 1. Remove dust and loose-fitting soot with a dry The stone can be washed easily with ordinary Caution: Make sure the stove is cold.
- Page 21 (use cord wood only). 2. Norsk Kleber has the option of either repairing or normal operation free of charge provided the stove 5. The warranty, as outlined within this document, 3.