Related Manuals for FlySynthesis STORCH CLASSIC
Summary of Contents for FlySynthesis STORCH CLASSIC
- Page 1 TWO-SEATERS ULTRALIGHT AIRCRAFT STORCH CLASSIC ENGINE JABIRU 2200 FLIGHT MANUAL REV.0...
- Page 2 Flight manual Storch Classic Jabiru STORCH CL FLIGHT MANUAL N° ..THIS FLIGHT MANUAL IS SUPPLIED WITH ULTRA LIGHT AIRCRAFT STORCH CL N°…………… AND MUST BE KEPT ON BOARD AT ALL TIMES. PILOT MUST BE AWARE OF ALL “NORMAL” AND “EMERGENCY” PROCEDURES IN ADDITION TO THE AIRCRAFT LIMITATIONS REPORTED IN THIS MANUAL.
-
Page 3: Log Of Revisions
Flight manual Storch Classic Jabiru LOG OF REVISIONS All the revisions to this manual, excluding data concerning weight and load tests, must be registered in the following table and, in case of approved sections, signed and stamped from CAAI. Rev. -
Page 4: Log Of Pages
Flight manual Storch Classic Jabiru LOG OF PAGES Chapter Pages Date Chapter Pages Date Pag. 4 Rev. 0 – 07/2002... - Page 5 Flight manual Storch Classic Jabiru INTRODUCTION This Flight Manual contains all the information necessary for a Correct and SAFE use of the two seats ultra light STORCH CL Such information includes: Procedures to prepare aircraft for flight; Normal Procedures; Emergency Procedures;...
- Page 6 Flight manual Storch Classic Jabiru GENERAL INDEX LOG OF REVISIONS ..............................3 LOG OF PAGES .................................4 FIGURES INDEX ...............................8 DESCRIPTION........................9 FUSELAGE.................................9 LANDING GEAR ..............................9 BRAKES ................................9 FLIGHT AND ENGINE INSTRUMENTS......................9 SEATS AND SEAT BELTS ..........................10 WINDSHIELD ..............................10 WING ..................................10 EMPENNAGE ..............................10 FLIGHT CONTROLS ...............................10...
- Page 7 Flight manual Storch Classic Jabiru BEFORE TAXIING ..............................23 TAXIING...................................23 CHECK ENGINE..............................24 TAKE OFF ................................24 CRUISING ................................24 NORMAL DESCENT ...............................24 FAST DESCENT ..............................25 FLYING IN RAINY CONDITIONS.........................25 LIMITATION ........................26 ENGINE LIMITATIONS (SEE ENGINE MANUAL SPECS.) ................26 SPEED LIMITATIONS (AT MAXIMUM WEIGHT) ....................26 MANOUVERING LIMITATIONS ..........................26...
- Page 8 Flight manual Storch Classic Jabiru FIGURES INDEX fig. 1 triptych, STORCH CL MODEL 3 views .................16 fig. 2 Sketch of Storch – part list –first part..................17 fig. 3 Sketch of Storch – part list –second part ..................17 fig. 4 Sketch of Storch – part list –inside cockpit ................19 fig.
- Page 9 Flight manual Storch Classic Jabiru Description In this charter the aircraft is described in all its parts: FUSELAGE THE FUSELAGE consists of a cockpit of composite materials with a self-support Ting shell structure. The cockpit shell contains five transverse frames of composite materials, which guarantee the rigidity of the structure and high degree of safety and reliability.
-
Page 10: Seats And Seat Belts
Flight manual Storch Classic Jabiru SEATS AND SEAT BELTS Seats The seats are fixed on the floor part and can be adapted to the size of the pilot or passenger. The bottom of the seat has an easy take away system to allow underlying inspection of flight commands. -
Page 11: Engine Description
Flight manual Storch Classic Jabiru TRIM PLANT The airplane is equipped with a manual trim command, which ensures adjustment to different CG positions and different speeds. The pitch-trim is installed on the cockpit ceiling. A blinded cable to the rear transmits the movement. By positioning the level, the attitude is changing descending or ascending. - Page 12 Flight manual Storch Classic Jabiru ELECTRIC ALIMENTATION CIRCUIT The electric power is ensured by two independent circuits, powered by the generator and controlled by a pick-up system. This assures a correct functioning electric system in case of failure of the general electric plant.
- Page 13 Flight manual Storch Classic Jabiru Technical data DIMENSION OVERALL DIMENSION Wing Span: 10.14 m Length: 6.25 Height: 2.44 WING Area: 13.0 Wing chord: 1.34 Wing load: 33.1 kg/m AILERON Area (each): Span: 4.58 Chord: 0.25 Travel (*): +2° -32° STABILATOR Area: 1.65...
-
Page 14: Landing Gear
Flight manual Storch Classic Jabiru LANDING GEAR Type: Trike with directional front wheel Main gear track: Main wheel – Nose wheelbase: Main wheel tire: 4.00x6’’ Nose wheel tire: 4.00x4’’ Inflation pressure: Nose wheel: kg/cm Inflation pressure: Main wheel: 2.0 - 2.2... - Page 15 Flight manual Storch Classic Jabiru PERFORMANCE WITH JABIRU 2200 ENGINE Data verified with following specifications: weight 450kg. Max efficiency (E max): 13.8 (at 89 km/h at ( at 55 Kts - 1 position flap position) 13,8 flap) Stall speed (Vso):...
- Page 16 Flight manual Storch Classic Jabiru fig. 1 triptych, STORCH CL MODEL 3 views Pag. 16 Rev. 0 – 07/2002...
- Page 17 Flight manual Storch Classic Jabiru fig. 2 Sketch of Storch – part list –first part FIG. 3 Sketch of Storch – part list –second part Pag. 17 Rev. 0 – 07/2002...
- Page 18 Flight manual Storch Classic Jabiru AIRCRAFT LIST OF PARTS 1. Right aileron 2. Connecting tube for aileron flight control 3. Stabilator 4. Vertical fin 5. Rudder 6. Trim tab, acting also as anti servo tab 7. Left aileron 8. Push pull wires for rudder and stabilator flight control 9.
- Page 19 Flight manual Storch Classic Jabiru fig. 4 Sketch of Storch – part list –inside cockpit COCKPIT LIST OF PARTS 1. Wing frame 2. Parachute handle (accessory) 3. Trim handle 4. Flap handle (located on ceiling back-side of cabin) 5. Instrument panel 6.
-
Page 20: Fuel Drain
Flight manual Storch Classic Jabiru ROUTINE SERVICES FUEL DRAIN CAUTION: Check that ignition key is switched off. Draining is accomplished by operating the cock located in the lower fuselage section, just after the firewall frame Draining 80-100 cc (5-6 cubic inch) is considered enough to completely eliminate the water in the tank. - Page 21 Flight manual Storch Classic Jabiru LEFT MAIN LANDING GEAR a) Disk and caliper (if installed) - state and tightness b) Tire - wearing check c) Tire pressure - well inflated d) Oil leakage (if installed) - not found e) Strut distortion...
- Page 22 Flight manual Storch Classic Jabiru RIGHT MAIN LANDING GEAR g) Disk and caliper (if installed) - state and tightness h) Tire - wearing check i) Tire pressure - well inflated j) Oil leakage (if installed) - not found k) Strut distortion...
-
Page 23: Engine Start Up
Flight manual Storch Classic Jabiru ENGINE START UP CAUTION: For safe aircraft operation a complete knowledge of engine. The operator requires LIMITATIONS and WARNINGS. Refer to operator’s manual issued by engine manufacturer. If possible, engine start-up should be carried out with engine positioned into the wind a) Electrical pump - ON for 5 sec. -
Page 24: Check Engine
Flight manual Storch Classic Jabiru CHECK ENGINE Brakes - engaged Safety belts - strapped Doors - closed and locked Fuel - open All temps. And press. - In the green Fuel quantity - check level Check during flight, quantity and... -
Page 25: Fast Descent
Flight manual Storch Classic Jabiru FAST DESCENT Throttle - at minimum Engine - inside limits Flaps - retracted Speed - inside limits NOTE: in hard wind condition or in wind-shear condition do not descend approach speed more Than 10 km/h, (5 knots). - Page 26 Flight manual Storch Classic Jabiru Limitation ENGINE LIMITATIONS (SEE ENGINE MANUAL SPECS.) SPEED LIMITATIONS (AT MAXIMUM WEIGHT) -Never exceed speed (V 180 km/h -Maneuvering speed (Va) 130m/h -Max. Speed with extended flaps 110 km/h MANOUVERING LIMITATIONS Correct turn at maximum 60°...
-
Page 27: Emergency Procedure
Flight manual Storch Classic Jabiru EMERGENCY PROCEDURE INTRODUCTION The following chapter contains a controls, checklist, and operation instruction to resolve emergency procedures. Problems due to engine failure, other than emergencies, due to a non correct use and a restraint Pre-flight check. -
Page 28: Engine Failure During Take-Off
Flight manual Storch Classic Jabiru RESTARTING Flaps - retracted Electrical pump - ON Magnetos - ON Fuel tanks valve - open Electric instruments - ALL OFF Push start button - START After engine recovering a. Oil pressure - in the green b. - Page 29 Flight manual Storch Classic Jabiru PRECAUTIONAL EMERGENCY LANDING NOTE: A precaution emergency landing can only be effectuated in case that the situation is such that the airport of departure or destination cannot be reached in safe conditions. This without endangering the occupants and, or the airplane.
- Page 30 Flight manual Storch Classic Jabiru FIRE IN FLIGHT DUE TO AN ELECTRICAL FAILL. (WITH SMOKE) Electrical users (avionics) - OFF Ventilation - open Avionics and master - OFF Electrical users - OFF Main switch - OFF Land as soon as possible FIRE ON THE GROUND DUE TO AN ELECTRICAL FAIL.
-
Page 31: Landing With A Flat Tire
Flight manual Storch Classic Jabiru LANDING WITH A FLAT TIRE Fulfill a normal procedure with a full flap setting landing after landing switch off contact and engine (magneto, main contact, fuel: OFF) Touch down must be effectuated on the inflated tire... - Page 32 Flight manual Storch Classic Jabiru LOW TENSION INDICATOR ILLUMINATED IN FLIGHT Volt meter - check value Switch off all electrical equipment not needed - check volt meter Landing light illuminated and low volt value Probable generator or fuse failure - land A.S.A.P.
-
Page 33: Wind Influence
Flight manual Storch Classic Jabiru SPECIFICATIONS / PERFORMANCES The performances is this chapter referring to the following airplane configuration: Empty weight - 283 kg TOTAL at minimum T.O.W. - 355 kg Maximum T.O.W. - 450 kg These take-off and landing limits referring to a dry grass runway ISA and ISA +13°C. - Page 34 Flight manual Storch Classic Jabiru LANDING The concerning diagrams referring the landing distance including a 15 meters obstacle at M.S.L. This diagram is related to the runway type, the number of occupant’s en the ambient temp. MAXIMUM RATE OF GLIDE CONFIGURATION In case of engine failure during climb without restarting possibility it is very important to assume the best rate of glide to reach a landing area.
- Page 35 Flight manual Storch Classic Jabiru Diagrams & CHARTS fig. 7 ROLL DISTANCE / TAKE-OFF DISTANCE - Second norm BCAR SECTION S , S-75 CONDITIONS I.S.A.: TEMP.: 15° C - PRESS.: 760 mmHg –M.S.L. TAXIING - I.S.A. - PILOT TAXIING - I.S.A. + 13° - PILOT TAXIING - I.S.A.
- Page 36 Flight manual Storch Classic Jabiru fig. 8 LANDING RUN / LANDING DISTANCE standard BCAR SECTION S CONDITIONS I.S.A.: TEMP.: 15° C - PRESS.: 760 mmHg – M.S.L. ROLLING DISTANCE - I.S.A. - PILOT ONLY ROLLING DISTANCE - I.S.A. + 13° - PILOT ONLY ROLLING DISTANCE - I.S.A.
- Page 37 Flight manual Storch Classic Jabiru WARNING Beware that between moment of engine failure and the max. rate of glide setting the loose of height is about 75 meters ( 250 ft;) . fig. 9 RELATIVE WIND DIAGRAM VERSUS WIND COMPONENT Pag.
- Page 38 Flight manual Storch Classic Jabiru fig. 10 MAX. RATE OF CLIMB DIAGRAM AT MAXIMUM RPM Second norm BCAR SECTION S , S-65 I.S.A. CONDITIONS: Temp.:15° C- Press.:760 mmHg- M.S.L. I.S.A. + 13° - PILOT + PASSENGER I.S.A. - PILOT + PASSENGER I.S.A.
- Page 39 Flight manual Storch Classic Jabiru fig. 11 FLIGHT ENVELOPE LEGEND Vso = Stall speed with extended flaps km/h Vs = Stall speed with retracted flaps km/h Vfe = Maximum speed with extended flaps (30°) km/h Va = Maneuvering speed km/h...
-
Page 40: Weight And Balance
Flight manual Storch Classic Jabiru WEIGHT AND BALANCE GENERAL To obtain the best flight performances, and to operate in safe conditions the airplane must be operated following the prescriptions for weight and balance according this flight manual. The pilot must be aware of the importance to the weight and balance and the limits of the airplane. -
Page 41: Weight And Balance Report
Flight manual Storch Classic Jabiru WEIGHT CONDITIONS. To obtain the correct weight the airplane must be under following conditions: The equipment must be complete as listed on the reference. Including: brake fluid, engine oil, anti-freeze liquid, and non-usable fuel. It is suitable to use an independent three balance and to maintain a fully horizontal setting of the airplane. - Page 42 Flight manual Storch Classic Jabiru MODEL“A” WEIGHT REPORT Model: STORCH CL - S/N :______________ - Registration:_______________ Data recording to the flight man. weight motif:__________________ Reference: Leading edge to the first wing section (RD) Equipment list – date:____________ Weight conditions: with brake liquid...
- Page 43 Flight manual Storch Classic Jabiru APPENDIX fig. 12 CONVERSION TABLE KILOMETERS/HOUR (km/h) – KNOTS KILOMETERS/HOUR (km/h) - KNOTS km/h knots km/h knots km/h knots 63,0 18,3 124,2 36,2 64,9 18,9 126,0 36,7 66,7 19,4 127,9 37,2 68,6 20,0 129,7 37,8...
- Page 44 Flight manual Storch Classic Jabiru fig. 14 VERTICAL SPEED (m/sec.) ’ (feet/min.) SPEED IN METERS PER SECOND (m/sec) RELATIVE TO SPEED IN 100 FEET PER MINUTE (l00 ft/min.) m/sec. 100 ft/min m/sec. 100 feet/min. m/sec. 100 feet/min. m/sec. 100 ft/min.
- Page 45 Flight manual Storch Classic Jabiru fig. 15 AIR CORRECTION TABLE ICAN (INTERNATIONAL COMMITTEE AIR NAVIGATION) TEMPEPATURE. RELATIVE PRESSURE AND RELATIVE DENSITY ALTITUDE DATA AND CORRECTION FACTORS BY WHICH THE INDICATED AIR SPEED (IAS) MUST BE MULTIPLIED TO OBTAIN THE TRUE AIR SPEED (TAS)
- Page 46 Flight manual Storch Classic Jabiru fig. 16 CONVERSION TABLE meters/feet METER S(m)/FEET (ft) 0,30 3,28 10,36 111,55 20,42 219,82 0,61 6,56 10,67 114,83 20,73 223,10 0,91 9,84 10,97 118,11 21,03 226,38 1,22 13,12 11,28 121,39 21,34 229,66 1,52 16,40 11,58...
- Page 47 Flight manual Storch Classic Jabiru fig. 17 CONVERSION OF ALTITUDE PRESSURE FROM mb TO inch Hg CONVERSION OF ALTITUDE PRESSURE FROM mb TO inch Hg z=-1000 mbar=1139,3 inch Hg= 33,6 z=1300 mbar=866,5 inch Hg= 25,6 z=-950 mbar=1132,8 inch Hg= 33,5...
- Page 48 Flight manual Storch Classic Jabiru fig. 18 TABLE WITH. STANDARD. ATM. CONVERSION n*10 1/S d exp 6 (mm.Hg) (Kg/m 2 ) (kgs 2 /m 4 ) (ft) (°C) (°K) (m/s) (Kg/m -1000 -3281 21,5 294,5 1,0226 854,6 11619 1,1245 0,1374...