Page 2
When servicing this product, under no circumstances should the original design danger of electrical shock. DO NOT USE A LINE ISOLATION be modified or altered without permission from Zenith Electronics Corporation. TRANSFORMER DURING THIS TEST. Use an AC voltmeter having 5000...
Page 3
CRT at a safe operating Anode voltage and provide proper shutdown thresholds. If replacement of any of these components are deemed necessary, it is important to use original type Zenith replacement components. After replacement is made, confirm proper Anode voltage using the following procedure.
Page 4
All manuals and user guides at all-guides.com TABLE OF CONTENTS DESCRIPTION OF CONTROLS ...........5 SPECIFICATIONS...............10 PROGRAMMING CODES...........11 ADJUSTMENT INSTRUCTIONS ........15 PURITY & CONVERGENCE ADJUSTMENT......18 PRINTED CIRCUIT BOARDS ..........21 BLOCK DIAGRAM...............29 EXPLODED VIEW...............30 EXPLODED VIEW PARTS LIST .........31 REPLACEMENT PARTS LIST ..........32 SCHEMATIC DIAGRAM............
All manuals and user guides at all-guides.com DESCRIPTION OF CONTROLS Front Panel Controls tv/video menu power Power Standby indicator (Illuminates brightly when the TV is in standby mode. Dims when the TV is switched on.) Remote control sensor TV/VIDEO Menu VOL LEFT / RIGHT Volume( ) button increases the sound level and vol-...
Page 6
All manuals and user guides at all-guides.com DESCRIPTION OF CONTROLS Rear Connections Panel Connecting external equipment to your TV. RF Connectors: Antenna 1 Input, Antenna 2 Input Used to connect cable or antenna Digital Audio signals to the televi- CALIBRATION Output Optical sion, either directly Connects to exter-...
Page 7
All manuals and user guides at all-guides.com DESCRIPTION OF CONTROLS Front Connections Panel (Front Video) There are four jacks on the lower-right front side of your TV that make connecting Audio/Video devices like video games and camcorders very simple. The jacks are like those found on the back jack connection panel.
Page 8
All manuals and user guides at all-guides.com DESCRIPTION OF CONTROLS Remote Control Functions in TV Mode MODE Selects the remote operating MODE INDICATOR mode: TV, VCR, Cable, DVD or LIGHTS Satellite. Select other operating Show active remote mode modes, for the remote to oper- ate external devices.
Page 9
All manuals and user guides at all-guides.com DESCRIPTION OF CONTROLS Remote Control Functions in TV Mode vcr cable dvd sat mode light power RATIO POWER Changes the aspect ratio. Turns your TV or any other tv/video front comp/dvi programmed equipment on or off, depending on mode.
All manuals and user guides at all-guides.com SPECIFICATIONS Product Specifications Models C34W37 Horizontal Size (inches) 41.7 Height (inches) 24.7 Thickness (inches) 23.2 Weight (lbs) 168.2 Power requirement 120V, 60Hz Television system American TV Standard, NTSC, ATSC with STB Television Channel VHF: 2 - 13 UHF: 14 - 69 CATV: 1 - 125...
All manuals and user guides at all-guides.com ADJUSTMENT INSTRUCTIONS 1. Application Object 4-2. Adjustment (1) Select EZ Adjust 3. CUT-OFF, pressing ADJ key on the These instructions are applied to the AC-02SA chassis. SVC Remote control. When it enters to adjustment mode, the pattern(14CH.) being selected, it becomes with Normal image 16:9 and the 2.
Page 16
All manuals and user guides at all-guides.com ADJUSTMENT INSTRUCTIONS 5-4. Raster H-center(H.CENTER) Adjustment 7. White Balance Adjustment Select 77. H Postion in the adjustment mode and adjust until Do screen adjustment first. left and right screen are symmetrically equal. Color Temp must be adjusted from Medium Mode. (The image condition must be adjusted from Normal condition) 5-5.
Page 17
All manuals and user guides at all-guides.com ADJUSTMENT INSTRUCTIONS (1) Select EZ Adjust 5. Sub Bright pressing ADJ key on the SVC Remote control. (2) Adjust to the point where “2” is not visible. 8-2. Sub COLOR, TINT Adjustment WHITE YELLOW CYAN GREENMAGENTA...
All manuals and user guides at all-guides.com PURITY & CONVERGENCE ADJUSTMENT Caution: 5. Reconnect the internal degaussing coil. Convergence and Purity have been factory aligned. Do not 6. Position the beam bender locking rings at the 9 o'clock attempt to tamper with these alignments. position and the other three pairs of tabs (2,4 and 6 pole However, the effects of adjacent receiver components, or magnets) at the 12 o'clock position.
Page 19
All manuals and user guides at all-guides.com PURITY & CONVERGENCE ADJUSTMENT 1.ADJUST YOKE Z-AXIS FIRST 2 .ADJUST BEAM BENDER 2 POLE TO GET EQUAL BLUE MAGNET TO GET FOUR EQUAL COLOR CIRCLES COLOR CIRCLES MAGNETS 8. Referring to above, perform the following two steps: 5.
Page 20
All manuals and user guides at all-guides.com PURITY & CONVERGENCE ADJUSTMENT ROTATION DIRECTION RING MOVEMENT OF RED OF BOTH TABS PAIRS AND BLUE BEAMS OPPOSITE POLE SAME OPPOSITE POLE SAME UP/DOWN ROCKING OF THE YOKE CAUSES LEFT/RIGHT ROCKING OF THE YOKE UP/DOWN ROCKING OF THE YOKE LEET/RIGHT ROCKING OF THE YOKE OPPOSITE ROTATION OF RED AND BLUE...
All manuals and user guides at all-guides.com EXPLODED VIEW PARTS LIST Part No. Description 6335V36002B CPT ASSEMBLY,W86LQQ350X94 0.35G 0G TOSHIBA V2 VERSION 120-C77M SPEAKER,FULLRANGE C122P02K1459 ESTEC 8 OHM 10/15W 4810V00088A BRACKET,SPEAKER CE-29K30 NON PP NONE 6140VC2006B COIL,DEGAUSSING 70TURN 10.7OHM ASSY 6140VC2007B AND 150-D07D 170-797U CPT EARTH,34 48T 0LUG RING 174-225Y...
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST For Capacitor & Resistors, the CC, CX, CK, CN : Ceramic RD : Carbon Film charactors at 2nd and 3rd digit CQ : Polyestor RS : Metal Oxide Film RUN DATE : 2003.6.14 in the P/No.
Page 33
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION CHIP 2SA1504S(ASY) KEC CHIP 2SC3875S(ALY) KEC Q1017 0TR150400BA Q1905 0TR387500AA Q102 0TR387500AA CHIP 2SC3875S(ALY) KEC Q1906 0TR387500AA CHIP 2SC3875S(ALY) KEC Q104 0TR387500AA CHIP 2SC3875S(ALY) KEC...
Page 34
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION CHIP 2SC3875S(ALY) KEC 1SS133 T72 DO34 90V Q601 0TR387500AA D1604 0DS113379BA Q601 0TR830009BA BSS83 NON NCHANNEL S/W TR D1605 0DS113379BA 1SS133 T72 DO34 90V Q602 0TR387500AA...
Page 35
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION SDC15 TVS DIODE SOT23 12.8V 1UF STD 50V M ZD100 0DRSE00038A C1201 0CE105DK618 ZD101 0DRSE00038A SDC15 TVS DIODE SOT23 12.8V C1202 0CE105DK618 1UF STD 50V M...
Page 36
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 1000UF STD 25V M 1UF STD 50V M C1414 0CE108DH618 C1528 0CE105DK618 C1415 0CK1020K515 1000P 50V C1602 0CE106DF618 10UF STD 16V M C1416 0CE227BK618 220UF KME 50V M...
Page 37
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 0.1UF 2012 50V 10% 10UF MVG 16V 20% C1955 0CK104DK56A C394 0CE106SF6DC C1956 0CK104DK56A 0.1UF 2012 50V 10% C397 0CE226SF6DC 22UF MVG 16V M 0CE107DD618 100UF STD 10V M...
Page 38
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 22UF STD 16V M C536 0CE226DF618 C822 0CK4710W515 470PF 500V K B TR 0CE107DH618 100UF STD 25V M C823 0CE228DK650 2200UF STD 50V M 0CE107BK618 100UF KME 50V M...
Page 39
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 0.1UF 2012 50V 10% CONNECTOR ASSEMBLY,10P 2.5MM R1977 0CK104DK56A P905 387-A10G JACK RESISTOR AR100 0RRZVTA001C 4.7K OHM 1 / 16 W 1608 5% IC501 6612BBBHN4A JACK,DIN TOTX179...
Page 40
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 5.6 OHM 2 W 5.00% 6.8K OHM 2 W 5.00% R1418 0RF0561K607 R1554 0RS6801K607 R1419 0RS2403J607 240K OHM 1 W 5.00% R1555 0RS6801K607 6.8K OHM 2 W 5.00%...
Page 41
All manuals and user guides at all-guides.com REPLACEMENT PARTS LIST LOCA. NO PART NO DESCRIPTION LOCA. NO PART NO DESCRIPTION 22K OHM 2 W 5.00% SWITCH,TACT 2LEAD 160G(TA) R837 0RS2202K607 140-313B R838 0RD2403F609 240K OHM 1/6 W 5.00% 140-313B SWITCH,TACT 2LEAD 160G(TA) R840 0RD1002F609 10K OHM 1/6 W 5%...
Need help?
Do you have a question about the C34W37 Series and is the answer not in the manual?
Questions and answers