Related Manuals for Frymaster PF50 Series
Summary of Contents for Frymaster PF50 Series
- Page 1 SERIES PF50 & PF50S Please read all sections of this manual and retain for future reference. Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 12/2017 24-Hour Service Hotline 1-800-551-8633 *8197503*...
- Page 2 Installation, maintenance, and repairs should be performed by your Frymaster Dean Factory Authorized Service Agency. WARNING Safe and satisfactory operation of your equipment depends on its proper installation. Installation MUST conform to local codes, or in the absence of local codes, with the latest edition of the National Electric Code, N.F.P.A.
- Page 3 SERVICE CENTERS, AND/OR THE PART BEING USED IS MODIFIED FROM ITS ORIGINAL CONFIGURATION, THIS WARRANTY WILL BE VOID. FURTHER, FRYMASTER DEAN AND ITS AFFILIATES WILL NOT BE LIABLE FOR ANY CLAIMS, DAMAGES OR EXPENSES INCURRED BY THE CUSTOMER WHICH ARISE DIRECTLY...
-
Page 4: Table Of Contents
PF50 Series Portable Filtration Systems Operation Manual TABLE OF CONTENTS Page INTRODUCTION IMPORTANT INFORMATION FILTER PREPARATION OPERATING/FILTER INSTRUCTIONS CLEANING AND MAINTENANCE TROUBLESHOOTING... -
Page 5: Introduction
PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1.1 Parts Ordering Place parts orders directly with your local Frymaster/Dean Factory Authorized Service agency. A list is accessible on our website at: www.frymaster.com. To help speed your order, the following information is required:... - Page 6 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1.3 After Purchase In order to improve service, fill out the following chart with the nearest Frymaster Authorized Service Technician and FAS in your area. Authorized Service Technician/FAS Address Telephone/Fax Filter Model Number Filter Serial Number 1.4 Safety Information...
- Page 7 Frymaster/Dean to perform service on Frymaster/Dean equipment. All authorized service personnel are required to be equipped with a complete set of service parts manuals and stock a minimum amount of parts for Frymaster/Dean equipment. A list of FAS agencies is accessible on our website at: www.frymaster.com.
-
Page 8: Important Information
PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2.1 General PF50 portable filters can be used with a variety of Frymaster fryers, as well as other manufacturers’ equipment. Oil capacity is approximately 50 pounds. Unit specifications are listed below. Model... - Page 9 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2.1 General (cont.) Oil is gravity-drained from the fryer into the filter ("S" Models), or pumped from the frypot into the filter pan, and then filtered through filter paper. Filter powder, which enhances the filtering process, is distributed over the paper prior to filtering.
- Page 10 This should be done within 15 days of date of delivery. Retain the shipping container for inspection. NOTE: Frymaster does not assume responsibility for damage or loss incurred in transit.
-
Page 11: Filter Preparation
Irreversible pump damage will result if water is allowed into the system, and the warranty will be voided. PF50 Series portable filtration systems use a filter support grid, one sheet of filter paper and a hold- down ring to secure the filter paper in place. - Page 12 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3.1 Assembling The Filter System (cont.) 1. Ensure the filter pan is clean and free of all food and breading particles that could prevent the filter paper from sealing against the bottom of the pan.
- Page 13 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4.1 Filter Operation WARNING Use care when draining and filtering oil to avoid the possibility of a serious burn. 1. Sprinkle 8 ounces (1 cup) of filter powder over the filter paper, distributing the powder as evenly as possible.
- Page 14 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4.1 Filter Operation (cont.) 5. Ensure the oil is at operating temperature [~350° (177°C)]. Turn the fryer off. WARNING The filter pan maximum capacity is 50 lbs. DO NOT OVERFILL THE FILTER PAN.
- Page 15 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4.1 Filter Operation (cont.) To flush residual shortening and sediment from the frypot, place a clean metal container under the frypot drain valve. Open drain valve and place the hose nozzle inside the frypot.
-
Page 16: Cleaning And Maintenance
PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5.1 General Cleaning operations fall into three general categories: Wiping unit clean after each filter session; Cleaning, changing filter paper and preparing the unit for the next day’s business. - Page 17 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5.3 Daily— Close Of Business At the close of a working day, filter the oil in all fryers. When the last fryer is filtered, follow these steps: Ensure the flexible hose and pump lines are clear by running the filter pump for an additional 15–30 seconds after air bubbles start coming from the oil return line.
-
Page 18: Troubleshooting
PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING 6.1 Operating Problems Plugged lines and plugged filter paper account for over 90 percent of filtration system malfunctions. A general troubleshooting chart, included in this chapter, provides instructions in diagnosing common malfunctions. Contact a factory-authorized service technician for troubleshooting beyond the scope of the operator. - Page 19 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING 6.2 General Troubleshooting (cont.) Pump won't · Tripped thermal overload switch. start. · Incorrect or no line voltage. · Allow filter unit to cool for at least 45 minutes and then press (reset) the motor thermal overload Pump stops switch.
- Page 20 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING Wiring Diagrams 6.3.1 PF50 115V Wiring PUMP MOTOR CONTROL SWITCH PUMP MOTOR FILTER HEATER LIGHT LIGHT 8051171A HEATER WHITE BLACK FEMALE EXT. CORD HEATER/FILTER SWITCH GREEN 6.3.2 PF50 230V Wiring PUMP MOTOR...
- Page 21 PF50 SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING 6.3.3 PF50S 115/230V Wiring PUMP MOTOR CONTROL SWITCH PUMP MOTOR HEATER FILTER LIGHT LIGHT HEATER WHITE EXTERNAL FILTER CORD SWITCH 115V OPTION BLACK GREEN WHITE CORDSET 230V OPTION BLACK GREEN 6.3.4 PF50/PF50S 115/230V Pump Motor Wiring...
- Page 22 Foshan Manitowoc Foodservice Col, Ltd. No.12 Chuang Ye North Road, Song Gang Song Xia Industry Park Nanhai District, Foshan Guangdong, China 528234 SERVICE 1-318-865-1711 8197503 12/2017...
Need help?
Do you have a question about the PF50 Series and is the answer not in the manual?
Questions and answers