Mitsubishi Electric JG79J380H13 Manual

SPLIT-TYPE AIR CONDITIONERS
INSTALLATION MANUAL
1. BEFORE INSTALLATION
MEANINGS OF SYMBOLS DISPLAYED ON INDOOR UNIT AND/OR OUTDOOR UNIT
WARNING
5LVN RI ¿UH
5HDG WKH 23(5$7,1* ,16758&7,216 FDUHIXOO\ EHIRUH RSHUDWLRQ
6HUYLFH SHUVRQQHO DUH UHTXLUHG WR FDUHIXOO\ UHDG WKH 23(5$7,1* ,16758&7,216 DQG ,167$//$7,21 0$18$/ EHIRUH RSHUDWLRQ
)XUWKHU LQIRUPDWLRQ LV DYDLODEOH LQ WKH 23(5$7,1* ,16758&7,216 ,167$//$7,21 0$18$/ DQG WKH OLNH
1-1. THE FOLLOWING SHOULD ALWAYS BE OBSERVED FOR SAFETY
‡ %H VXUH WR UHDG ³7+( )2//2:,1* 6+28/' $/:$<6 %( 2%6(59(' )25 6$)(7<´ EHIRUH LQVWDOOLQJ WKH DLU FRQGLWLRQHU
‡ %HIRUH VWDUWLQJ WKH FRQQHFWLRQ VHWXS RI WKH :L)L LQWHUIDFH FKHFN WKH VDIHW\ SUHFDXWLRQV LQ 23(5$7,1* ,16758&7,216 RI WKH URRP DLU FRQGLWLRQHU
‡ %H VXUH WR REVHUYH WKH ZDUQLQJV DQG FDXWLRQV VSHFL¿HG KHUH DV WKH\ LQFOXGH LPSRUWDQW LWHPV UHODWHG WR VDIHW\
‡ $IWHU UHDGLQJ WKLV PDQXDO EH VXUH WR NHHS LW WRJHWKHU ZLWK WKH 23(5$7,1* ,16758&7,216 IRU IXWXUH UHIHUHQFH
■ Do not install the unit by yourself (user).
,QFRPSOHWH LQVWDOODWLRQ FRXOG FDXVH ¿UH HOHFWULF VKRFN
LQMXU\ GXH WR WKH XQLW IDOOLQJ RU OHDNDJH RI ZDWHU &RQ-
sult the dealer from whom you purchased the unit or a
TXDOL¿HG LQVWDOOHU
■ Perform the installation securely referring to the
installation manual.
,QFRPSOHWH LQVWDOODWLRQ FRXOG FDXVH ¿UH HOHFWULF VKRFN
LQMXU\ GXH WR WKH XQLW IDOOLQJ RU OHDNDJH RI ZDWHU
■ When installing the unit, use appropriate protective
equipment and tools for safety.
)DLOXUH WR GR VR FRXOG FDXVH LQMXU\
■ Install the unit securely in a place which can bear
the weight of the unit.
If the installation location cannot bear the weight of the
XQLW WKH XQLW FRXOG IDOO FDXVLQJ LQMXU\
■ Do not alter the unit.
,W PD\ FDXVH ¿UH HOHFWULF VKRFN LQMXU\ RU ZDWHU OHDNDJH
■ (OHFWULFDO ZRUN VKRXOG EH SHUIRUPHG E\ D TXDOL¿HG
experienced electrician, according to the installation
manual. Be sure to use an exclusive circuit. Do not
connect other electrical appliances to the circuit.
,I WKH FDSDFLW\ RI WKH SRZHU FLUFXLW LV LQVXI¿FLHQW RU WKHUH
LV LQFRPSOHWH HOHFWULFDO ZRUN LW FRXOG UHVXOW LQ D ¿UH RU
DQ HOHFWULF VKRFN
■ Earth the unit correctly.
Do not connect the earth to a gas pipe, water pipe,
OLJKWQLQJ URG RU WHOHSKRQH HDUWK 'HIHFWLYH HDUWKLQJ
FRXOG FDXVH HOHFWULF VKRFN
■ Do not damage the wires by applying excessive
pressure with parts or screws.
'DPDJHG ZLUHV FRXOG FDXVH ¿UH RU HOHFWULF VKRFN
■ Be sure to cut off the main power in case of setting
up the indoor P.C. board or wiring works.
)DLOXUH WR GR VR FRXOG FDXVH HOHFWULF VKRFN
■ 8VH WKH VSHFL¿HG ZLUHV WR FRQQHFW WKH LQGRRU DQG
RXWGRRU XQLWV VHFXUHO\ DQG DWWDFK WKH ZLUHV ¿UPO\ WR
the terminal block connecting sections so the stress
of the wires is not applied to the sections. Do not
extend the wires, or use intermediate connection.
,QFRPSOHWH FRQQHFWLQJ DQG VHFXULQJ FRXOG FDXVH ¿UH
■ 'R QRW LQVWDOO WKH XQLW LQ D SODFH ZKHUH ÀDPPDEOH
gas may leak.
If gas leaks and accumulates in the area around the
XQLW LW FRXOG FDXVH DQ H[SORVLRQ
■ Do not use intermediate connection of the power
cord or the extension cord and do not connect many
devices to one AC outlet.
,W FRXOG FDXVH D ¿UH RU DQ HOHFWULF VKRFN GXH WR GHIHFWLYH
FRQWDFW GHIHFWLYH LQVXODWLRQ H[FHHGLQJ WKH SHUPLVVLEOH
FXUUHQW HWF
■ %H VXUH WR XVH WKH SDUWV SURYLGHG RU VSHFL¿HG SDUWV
for the installation work.
The use of defective parts could cause an injury or
OHDNDJH RI ZDWHU GXH WR D ¿UH DQ HOHFWULF VKRFN WKH
XQLW IDOOLQJ HWF
REFRIGERANT
Model names are indicated in 1-3.
When installing multi units, refer to the
installation manual of the multi unit for
RXWGRRU XQLW LQVWDOODWLRQ
7KLV XQLW XVHV D ÀDPPDEOH UHIULJHUDQW
,I UHIULJHUDQW OHDNV DQG FRPHV LQ FRQWDFW ZLWK ¿UH RU KHDWLQJ SDUW LW ZLOO FUHDWH KDUPIXO JDV DQG WKHUH LV ULVN RI ¿UH
■ When plugging the power supply plug into the
outlet, make sure that there is no dust, clogging,
or loose parts in both the outlet and the plug. Make
sure that the power supply plug is pushed com-
pletely into the outlet.
If there is dust, clogging, or loose parts on the power
supply plug or the outlet, it could cause electric shock or
¿UH ,I ORRVH SDUWV DUH IRXQG RQ WKH SRZHU VXSSO\ SOXJ
UHSODFH LW
■ Attach the electrical cover to the indoor unit and the
service panel to the outdoor unit securely.
If the electrical cover of the indoor unit and/or the service
panel of the outdoor unit are not attached securely, it
FRXOG UHVXOW LQ D ¿UH RU DQ HOHFWULF VKRFN GXH WR GXVW
ZDWHU HWF
■ When installing, relocating, or servicing the unit,
make sure that no substance other than the speci-
¿HG UHIULJHUDQW 5 HQWHUV WKH UHIULJHUDQW FLUFXLW
Any presence of foreign substance such as air can
FDXVH DEQRUPDO SUHVVXUH ULVH DQG PD\ UHVXOW LQ H[SOR-
VLRQ RU LQMXU\ 7KH XVH RI DQ\ UHIULJHUDQW RWKHU WKDQ WKDW
VSHFL¿HG IRU WKH V\VWHP ZLOO FDXVH PHFKDQLFDO IDLOXUH
V\VWHP PDOIXQFWLRQ RU XQLW EUHDNGRZQ ,Q WKH ZRUVW
case, this could lead to a serious impediment to securing
SURGXFW VDIHW\
■ Do not discharge the refrigerant into the atmos-
phere. If refrigerant leaks during installation, ven-
tilate the room. Check that the refrigerant does not
leak after installation has been completed.
,I UHIULJHUDQW OHDNV DQG FRPHV LQ FRQWDFW ZLWK ¿UH RU
heating part of such a fan heater, kerosene heater, or
FRRNLQJ VWRYH LW ZLOO FUHDWH KDUPIXO JDV 3URYLGH YHQWLOD-
WLRQ LQ DFFRUGDQFH ZLWK (1
■ Use appropriate tools and piping materials for instal-
lation.
7KH SUHVVXUH RI 5 LV  WLPHV PRUH WKDQ 5 1RW
using appropriate tools or materials and incomplete
LQVWDOODWLRQ FRXOG FDXVH WKH SLSHV WR EXUVW RU LQMXU\
■ When pumping down the refrigerant, stop the com-
pressor before disconnecting the refrigerant pipes.
If the refrigerant pipes are disconnected while the
compressor is running and the stop valve is open, air
could be drawn in and the pressure in the refrigeration
F\FOH FRXOG EHFRPH DEQRUPDOO\ KLJK 7KLV FRXOG FDXVH
WKH SLSHV WR EXUVW RU LQMXU\
■ When installing the unit, securely connect the re-
frigerant pipes before starting the compressor.
If the compressor is started before the refrigerant pipes
are connected and when the stop valve is open, air could
be drawn in and the pressure in the refrigeration cycle
FRXOG EHFRPH DEQRUPDOO\ KLJK 7KLV FRXOG FDXVH WKH
SLSHV WR EXUVW RU LQMXU\
JG79J380H13
Phillips screwdriver
Level
Scale
Utility knife or scissors
75 mm hole saw
Torque wrench
Wrench (or spanner)
WARNING
&RXOG OHDG WR GHDWK VHULRXV LQMXU\ HWF
■ )DVWHQ D ÀDUH QXW ZLWK D WRUTXH ZUHQFK DV VSHFL¿HG
■ The unit shall be installed in accordance with na-
■ :KHQ XVLQJ D JDV EXUQHU RU RWKHU ÀDPHSURGXFLQJ
■ Do not use means to accelerate the defrosting pro-
■ The appliance shall be stored in a room without
■ Do not pierce or burn.
■ Be aware that refrigerants may not contain an odour.
■ Pipe-work shall be protected from physical damage.
■ The installation of pipe-work shall be kept to a
■ Compliance with national gas regulations shall be
■ Keep any required ventilation openings clear of
■ Do not install the indoor unit equipped with the Wi-Fi
■ Do not use the indoor unit equipped with the Wi-Fi
■ This indoor unit equipped with the Wi-Fi interface
Required Tools for Installation
 PP KH[DJRQDO ZUHQFK
Flare tool for R32, R410A
Gauge manifold for R32, R410A
Vacuum pump for R32, R410A
Charge hose for R32, R410A
Pipe cutter with reamer
in this manual.
,I IDVWHQHG WRR WLJKW D ÀDUH QXW PD\ EUHDN DIWHU D ORQJ
SHULRG DQG FDXVH UHIULJHUDQW OHDNDJH
tional wiring regulations.
equipment, completely remove all of the refrigerant
from the air conditioner and ensure that the area is
well-ventilated.
,I WKH UHIULJHUDQW OHDNV DQG FRPHV LQ FRQWDFW LQ ¿UH RU
heating part, it will create harmful gas and there is risk
RI ¿UH
cess or to clean, other than those recommended by
the manufacturer.
continuously operating ignition sources (for exam-
SOH RSHQ ÀDPHV DQ RSHUDWLQJ JDV DSSOLDQFH RU DQ
operating electric heater).
minimum.
observed.
obstruction.
interface nearby the automatic control devices such
DV DXWRPDWLF GRRUV RU ¿UH DODUPV
,W FDQ FDXVH DFFLGHQWV GXH WR PDOIXQFWLRQV
interface nearby the medical electrical equipment
or people who have a medical device such as a
cardiac pacemaker or an implantable cardioverter-
GH¿EULOODWRU
It can cause an accident due to malfunctions of the
PHGLFDO HTXLSPHQW RU GHYLFH
should be installed and operated with a minimum
distance of 20 cm between the device and the user
or bystanders.