Summary of Contents for Marantz professional PMD580
Page 1
All manuals and user guides at all-guides.com For U.S.A., Canada, Europe, & Japan model SERVICE MANUAL PMD580 MODEL Network Solid State Recorder Please use this service manual with referring to the user guide ( D.F.U. ) without fail. 修理の際は、必ず取扱説明書を準備し操作方法を確認の上作業を行ってください。 M Holdings Inc.
All manuals and user guides at all-guides.com TABLE OF CONTENTS SECTION PAGE 1. TECHNICAL SPECIFICATIONS ..................... 1 2. SERVICE MODE ..........................2 3. SETTING THE MAC ADDRESS ..................... 4 4. UPDATING THE FIRMWARE ......................5 5. WIRING DIAGRAM ........................11 6. BLOCK DIAGRAM ........................13 7.
All manuals and user guides at all-guides.com 1. TECHNICAL SPECIFICATIONS Digital Audio System Balanced Digital output Type ........XLR (1:GND, 2:HOT, 3:COLD) System ..........Solid State Recorder Output impedance ..........110 ohms Usable Media ....CF memory cards, Microdrive cards Standard output level ........... 3.5 Vp-p Recording and media methods MP3 ........MPEG1 Layer III compression Format ...
2. SERVICE MODE 以下の手順に従い、 サービスモードを実行できます。 Service mode can be performed with the following procedures: 1. POWER ON/OFF スイッチを押し、 PMD580 の電源を入 1. Press the POWER ON/OFF switch to turn on the power. れます。電源を入れた後、ディスプレイに Booting When the power is turned on, “Booting” then “Initial”...
Page 5
All manuals and user guides at all-guides.com Press the Jog wheel while The default values for the destination this display is shown. (Europe, United States, or Japan) are set for initialization. 表示中にジョグダイヤル 1) Select “US” for the United States, “EU” for を押します。...
Page 6
All manuals and user guides at all-guides.com (For Japan) (日本向けのみ) The lighting condition of the LED of each button Press the Jog wheel while can be checked with the special tool connected this display is shown. to the parallel connector. •...
3. SETTING THE MAC ADDRESS サービスモードにある Mac アドレス 設定を行います。 Set “Mac Address” in Service mode. 1. POWER ON/OFF スイッチを押し、 PMD580 の電源を入 1. Press the POWER ON/OFF switch to turn on the power. れます。 2. If you press and hold both the STOP/CANCEL button 2.
Service mode. For details, see “EEPROM” settings in の “EEPROM” 設定をご覧ください。 Service mode. ファームウェアの更新作業に必要なもの Requirements for updating the firmware • 書き換えたい PMD580 • PMD580 to be updated • CF カード • CF card • パーソナル・コンピュータ • Personal computer • ファームウェア更新用ファイル...
Page 9
All manuals and user guides at all-guides.com ファームウェアの更新作業 Updating the fi rmware Load the prepared CF card into the PMD580 to update the 前準備した CF カードを PMD580 に挿入してファームウェ fi rmware. アを更新します。 1. Insert the CF card to the Card compartment with the 1.
Page 10
All manuals and user guides at all-guides.com 更新作業の実施 Updating procedures 1. To update the firmware, first press the Jog wheel with 1. ファ ー ムウェアを更 新 するときは、ディスプレ イに “Update? Yes” displayed. “Update? Yes” が表示されている状態で、 ジョグダイヤル を押してく ださい。 The following confirmation display appears. このとき、...
Page 11
All manuals and user guides at all-guides.com 更新を終了し通常モードへの移行 Terminating updating and returning to the normal mode 1. ディスプレイに “Update? Yes” が表示されている状態 1. Turn right the Jog wheel one click with “Update? Yes” で、ジョグダイヤルを時計方向に 1 クリック回します。 displayed. “Update? No” appears on the display. ディスプレイが...
Page 12
All manuals and user guides at all-guides.com ファームウェアのバージョン確認 Checking the fi rmware version In Stop mode, you can check the fi rmware version with “F/W 停止状態においてユーティリティメニューの“F/W version”に version” of the Utility menu. よりファームウェアバージョンを確認することができます。 1. Press both the MENU/STORE button and the SHIFT 1.
Page 20
All manuals and user guides at all-guides.com TPF209 TPF203 TPF204 +14V P201 00MWI09CS2010 TPF045 TPF228 XLR INPUT TPF229 RA17 CA09 TPF193 +14V RA09 RA03 4 7k 5 6k CA07 LA01 TPF305 CA11 TPF303 DA01 TPF192 CA27 0 1u 47u/25 BLM11B601 TPF258 CD43 I/O A UNIT...
Page 21
All manuals and user guides at all-guides.com +3VU TPF949 P203 00MWI09CS2030 P202 00MWI09CS2020 TPF932 Q852 TPF934 TPF578 NJU3716AM-TE1 D-GND TPF935 I/O C UNIT PANEL UNIT D500 R898 13 DATA R509 TPF544 TLGU1002A(T02) TPF108 R899 14 CLK TO MAIN UNIT R900 15 STB# TPF528 R901...
Page 22
All manuals and user guides at all-guides.com +3VU Q703 R727 TPF752 NJM2387DL2 0 1/10W VADJ 4 R729 CNT 2 D719 OPEN C721 R728 0.1u R730 TPF753 R732 C720 100k 10u/50 R731 R797 C724 L704 Q704 680u/35V TPF754 56uH BD9781HFP RJH-35V681MI6#-S1 CDRH127/LD TO W005 1 VIN...
Page 23
All manuals and user guides at all-guides.com P302 00MWG09CS3020 -14V HP JACK UNIT +14V +14V C805 +14V 〜J506(I/O A UNIT) J800 C802 C801 S6B-PH-SM3 CON.BASE TO W004 R810 47u/25 47u/25 TPF801 R807 OPEN (MUTE_ON) L806 -14V BLM21PG221SN1D GND_A GND_A TPF802 C807 D801 L807...
All manuals and user guides at all-guides.com 8. PARTS LOCATION B101 D018 R057 R235 R421 P101 A C002 D025 R058 R236 R422 C004 D110 R060 R240 R423 C006 D118 R061 R245 R434 C007 J001 R062 R246 R435 C010 J004 R063 R247 R436 C011...
Page 25
All manuals and user guides at all-guides.com P101 B C001 G6 CU35 B5 R099 F3 R305 D2 R469 B9 C003 D2 CU36 B5 R100 F3 R306 D5 R474 G4 C005 F7 CU38 B4 R101 F3 R307 D2 R475 G3 C008 D1 CU39 B5 R102 F3 R308 F2...
Page 26
All manuals and user guides at all-guides.com BD04 CB15 P201 A BD05 CB16 BD08 CB17 CA01 CB18 CA02 CB19 CA03 CB20 CA04 CB21 CA05 CB22 CA06 CB23 CA07 CB24 CA08 CB25 CA09 CB26 CA10 CB27 CA11 CB28 CA12 CB29 CA13 CB30 CA14 CB31...
Page 27
All manuals and user guides at all-guides.com P201 B 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
Page 28
All manuals and user guides at all-guides.com P202 A P202 B C850 A5 C866 B7 D862 B14 D878 B14 R855 A6 R871 B13 R887 B14 R903 A9 C851 A5 C867 B8 D863 A13 D879 A11 R856 A6 R872 B14 R888 B14 R904 A9 C852 A5 C868 B7...
Page 29
All manuals and user guides at all-guides.com P203 A P203 B C500 B3 C511 C1 C527 C3 R500 B3 R514 B1 C501 B3 C512 C2 D500 B2 R501 B2 R515 A1 C502 C3 C513 C2 J501 A1 R502 A2 R516 A1 C503 B2 C514 B2 J502 A2...
Page 30
All manuals and user guides at all-guides.com P301 A BD02 F6 D720 A2 R736 C9 BD03 D6 G700 C1 R737 C9 BD06 B6 J701 B1 R738 C9 BD07 D6 J702 A8 R739 B10 C700 C2 J703 A4 R740 A3 C701 D1 J704 F6 R741 C10 C702 E1...
Page 31
All manuals and user guides at all-guides.com P301 B 鉛フリー半田 半田付けには、鉛フリー半田 (Sn-Ag-Cu) を使用してください。 Lead-free Solder When soldering, use the Lead-free Solder (Sn-Ag-Cu).
Page 32
All manuals and user guides at all-guides.com P302 A P302 B BD01 A1 C813 C1 L806 B2 R805 C2 R818 C1 C801 B1 C814 C1 L807 B2 R806 C2 R819 C1 C802 B2 C815 C1 L808 B2 R807 C2 R820 C1 C803 D2 C816 C1 L810 B2...
Page 33
All manuals and user guides at all-guides.com P303 A P303 B C650 A1 D662 B2 C651 A1 J651 B3 C652 A2 J652 A1 C653 A2 R654 A2 C654 B2 R655 A2 C655 B2 R657 A1 D652 A2 R658 A2 D653 A2 R659 A2 D655 A2 R660 A1...
All manuals and user guides at all-guides.com 10. PACKING AND PARTS LIST VERS. POS. NO. PART NO. PART NAME DESCRIPTION COLOR 006B 00M238H355020 LENS LENS ACCESS LED 002T 008B 00M204N122110 ADHESIVE ADHESIVE FOR LENS 010B 00M09CS105022 FRONT CHASSIS FRONT INNER CHASSIS 014B 00M43BS160010 HP BRACKET...
Page 36
All manuals and user guides at all-guides.com...
All manuals and user guides at all-guides.com 11. IC DATA 78Q2120 PACKAGE PIN DESIGNATIONS (TOP VIEW) AT24C16B PIN CONFIGURATION 8-LEAD SOIC Pin Name Function A0 - A2 No Connect Serial Data Serial Clock Input Write Protect Ground Power Supply...
Page 38
All manuals and user guides at all-guides.com CS4271 3.3 V to 5 V 2.5 V to 5 V Hardware or Left and Internal Voltage Internal External C/SPI Right Mute Reference Oscillator Mute Control Control Data Controls Register / Hardware Configuration Reset Selectable Left...
Page 39
All manuals and user guides at all-guides.com CS8420 VA+ AGND FILT RERR RMCK VD+ DGND ILRCK OLRCK Serial Sample Serial ISCLK OSCLK Audio Rate Audio SDIN Input Converter Output SDOUT Clock & AES3 C & U bit AES3 Receiver Driver Data S/PDIF Data...
Page 40
All manuals and user guides at all-guides.com EP9315 PIN BGA PINOUT...
Page 41
All manuals and user guides at all-guides.com ISP1582 BLOCK DIAGRAM 12 MHz DREQ DIOR to or from USB DACK DIOW XTAL1 XTAL2 3.3 V ISP1582 1.5 kΩ HANDLER INTERFACE SoftConnect 30 to 33, 35 to 40, RREF HI-SPEED USB 42 to 47 MEMORY DATA TRANSCEIVER...
Page 42
All manuals and user guides at all-guides.com JS28F128P30 56-LEAD TSOP PINOUT (64/128/256-MBIT) WAIT A 16 A 17 DQ15 DQ14 DQ13 DQ12 ADV# Intel StrataFlash ® Embedded Memory (P 30) RST# 56-Lead TSOP Pinout DQ11 14 mm x 20 mm DQ10 Top View VCCQ OE #...
Page 43
All manuals and user guides at all-guides.com MT48LC64M4A2 Pin Assignment (Top View) 54-Pin TSOP DQ15 VssQ DQ14 DQ13 VssQ DQ12 DQ11 VssQ DQ10 VssQ DQML DQMH CAS# RAS# Note: The # symbol indicates signal is active LOW. A dash (–) indicates x8 and x4 pin function is same as x16 pin function.
Page 44
All manuals and user guides at all-guides.com SN65LVDM179 (TOP VIEW) FUNCTION TABLE Receiver INPUTS OUTPUT Open H = "H" Level, L = "L" Level, ? = indeterminate Driver INPUT OUTPUTS Open H = "H" Level, L = "L" Level SN65LVDS3487 (TOP VIEW) LOGIC DIAGRAM 1,2EN...
Page 45
All manuals and user guides at all-guides.com SN74LV04A FUNCTION TABLE H : High Level L : Low Level SN74LV125A (TOP VIEW) LOGIC DIAGRAM (POSITIVE LOGIC)
Page 46
All manuals and user guides at all-guides.com SN74LV138A (TOP VIEW) FUNCTION TABLE ENABLE INPUTS SELECT INPUTS OUTPUTS SN74LV244A FUNCTION TABLE H : High Level L : Low Level X : Don't care Z : High impedance...
Page 47
All manuals and user guides at all-guides.com SN74LV273A (TOP VIEW) FUNCTION TABLE H : High Level L : Low Level X : Don't care SN74LV541A (TOP VIEW) FUNCTION TABLE (each buffer/driver) INPUTS OUTPUT OUTPUT LOGIC DIAGRAM (POSITIVE LOGIC) To Seven Other Channels...
Page 48
All manuals and user guides at all-guides.com TC74HCU04A 16244 (TOP VIEW) 1A1-1A4 1Y1-1Y4 3Y1-3Y4 3A1-3A4 2A1-2A4 2Y1-2Y4 4Y1-4Y4 4A1-4A4 2Y3 11...
Page 49
All manuals and user guides at all-guides.com TC74LCX16245 (TOP VIEW) 1DIR 2DIR 1DIR 1B7 11 2DIR...
Page 50
All manuals and user guides at all-guides.com TC9459BFG (TOP VIEW) BLOCK DIAGRAM Same as L-ch Lch 7 to 91 decoder Rch 7 to 91 decoder Lch latch circuit Rch latch circuit Shift register (24 bit) Level shift circuit...
Page 51
All manuals and user guides at all-guides.com uPD4721 EC11B15242AE...
Page 52
All manuals and user guides at all-guides.com NJU3716A BLOCK DIAGRAM SHIFT LATCH REGISTER CIRCUIT CONTROL CIRCUIT...
Page 53
All manuals and user guides at all-guides.com RCU7276Y-B BLOCK DIAGRAM PIN CONFIGURATION Backlight Power Supply LCD Connector Connector Pin No. Signal Pin No. Name...
Page 54
All manuals and user guides at all-guides.com CR2032 (SANYO) The exchange of the battery (IEC60065, UL60065). 電池 (IEC60065, UL60065) の交換について CAUTION 注意 Danger of explosion if battery is incorrectly replaced. 電池を誤って交換すると爆発する危険があります。 Replace only with the same or equivalent type. 同一又は同等の型のものにのみ交換してください。...
All manuals and user guides at all-guides.com 12. ELECTRICAL PARTS LIST PARTS INFORMATION ABBREVIATION AND MARKS ANT. : ANTENNA BATT. : BATTERY CAP. : CAPACITOR CER. : CERAMIC CONN. : CONNECTING DIG. : DIGITAL : HEADPHONE MIC. : MICROPHONE μ-PRO : MICROPROCESSOR REC.
Page 59
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR 0 Ω ± 5% 1/10W P101 R008 00MNI05000110 0Ω ±5% 1/10W 0 Ω ± 5% 1/10W P101 R014 00MNI05000110 0Ω ±5% 1/10W 0 Ω ± 5% 1/10W P101 R256 00MNI05000110...
Page 60
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P201 CA91 00MOA10702520 100µF M 25V RA-2 P201 CA92 00MOA10702520 100µF M 25V RA-2 P201 CA94 00MOA10702520 100µF M 25V RA-2 P201 CB13 00MOA10702520 100µF M 25V RA-2 P201 CB14...
Page 61
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P201 DC01 00MHI10202050 TLOU1002A(T02) P201 DC02 00D3939631903 TLGU1002A(T02) P201 DC03 00D2760560901 DAN202KT146 P201 DC04 00D2760559909 DAP202KT146 P201 DD01 00D2760560901 DAN202KT146 P201 DD02 00D2760559909 DAP202KT146 P201 DD03 00D2760560901...
Page 62
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P201 LD02 00MFN31010030 BLM18B102SN1D BLM11B102S 1608 EMIFILTER P201 LD03 00MFN31010030 BLM18B102SN1D BLM11B102S 1608 EMIFILTER P201 LD06 00MTP41042010 PULS TRANS FOR CD PULS TRANS FOR CD P201 QA01 00D2730414906...
Page 63
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P201 QD07 00D2622515900 SN74LV04APW-EL2 P201 QD08 00D2622785905 SN74LV125APWRG4 P201 RB85 00MNI05000110 0Ω ±5% 1/10W P201 RB86 00MNI05000110 0Ω ±5% 1/10W P201 RC50 00MNI05000110 0Ω ±5% 1/10W P201 RC51 00MNI05000110...
Page 64
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR 5202 FRONT PCB ASSY P202 D850 00MHI10124210 SML-512MW P202 D851 00MHI10124210 SML-512MW P202 D852 00MHI10124210 SML-512MW P202 D853 00MHI10124210 SML-512MW P202 D854 00MHI10124210 SML-512MW P202 D855 00MHI10124210...
Page 65
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P203 C510 00MOA47505020 4.7µF M 50V RA-2 P203 C512 00MOA47505020 4.7µF M 50V RA-2 P203 C514 00MOA47505020 4.7µF M 50V RA-2 P203 C516 00MOA47505020 4.7µF M 50V RA-2 P203 C521...
Page 66
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P301 C747 00MOA10701620 100µF M 16V RA-2 P301 C755 00MDF17224570 # ECQU2A224ML 0.22µF/250V #DE1E3KX152MB4BL01 P301 D700 00MHD20031290 S1WB(A)60 30A 600V S1WB(A)60 30A 600V P301 D701 00MHV00001290 ST03D-170 TRANKILLER...
Page 67
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P301 Q713 00D2690083901 DTA114EKT96 P301 Q714 00D2690082902 DTC114EKT96 P301 Q715 00MHC10226210 BA9741FS-E2 2CH DC/DC P301 Q716 00MHX117971A0 2SA1797 2SA1797 P301 Q717 00MHX117971A0 2SA1797 2SA1797 P301 Q718 00MHX346721A0...
Page 68
All manuals and user guides at all-guides.com POS. VERS. PART NO. PART NAME DESCRIPTION NAME COLOR P302 Q804 00D2730414906 2SC3326(A/B) P302 Q805 00D2730414906 2SC3326(A/B) P302 R802 00MRM01031250 RK0971220 10K A (D-CUT REV) RK0971220 10K A (D-CUT REV) 5303 PARALLEL IO PCB ASSY P303 C650 00MOA10701620...
Need help?
Do you have a question about the PMD580 and is the answer not in the manual?
Questions and answers