Table of Contents
Advertisement
*
Installer:
Also be sure to check the grill box completely for ALL parts including
Renaissance Cooking Systems
America's Best Value in Outdoor Kitchen Equipment
Installation, Operation, Maintenance
Models:
These grills are tested and certified to the ANSI-Z21.58/CSA 1.6.standards.
Renaissance Cooking Systems grill, check out www.RCSGasGrills.com
1 |
P a g e
Leave this manual with the New Owner
the rotisserie spit rod (if applicable)
Owner's Manual
For Outdoor Use Only
Instructions & Parts List
RJC26A, RJC32A, RJC32AL,
RJC40A, RJC40AL, RON30A,
RON38A & RON42A
This owner's manual was updated March 2018
For the latest news, recipes and cooking tips for your new
*
Advertisement
Table of Contents
Troubleshooting
Subscribe to Our Youtube Channel
Related Manuals for RCS RJC32AL
Summary of Contents for RCS RJC32AL
- Page 1 Owner’s Manual For Outdoor Use Only America's Best Value in Outdoor Kitchen Equipment Installation, Operation, Maintenance Instructions & Parts List RJC26A, RJC32A, RJC32AL, Models: RJC40A, RJC40AL, RON30A, RON38A & RON42A These grills are tested and certified to the ANSI-Z21.58/CSA 1.6.standards.
-
Page 2: Table Of Contents
RJC26A, RJC32A, RJC32AL, RJC40A & RJC40AL – left side Premier Series: Cutlass Pro Series: RON30a, RON38a & RON42a – right side Thank you for purchasing your new RCS grill. We wish you years of grilling pleasure. P a g e... -
Page 3: For Your Safety
Safety and Installation Instructions GRILL INSTALLATION This gas grill must be installed in accordance with all local codes. If installation is planned in an area with no local codes, the gas grill must be installed in accordance with the National Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or CSA B149.1 natural gas and propane installation code. - Page 4 FOR YOUR SAFETY 1. Do Not store or use gasoline, caustic or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
-
Page 5: Clearance To Combustibles 5
Wind Guard: WARNING! Your RCS grill should NOT be installed with the back of the grill facing frequent, prevailing winds like a large body of water or open space unless there is a substantial back splash or some way of blocking the wind. In some rare occurrences, when... - Page 6 Model/Part Number RWGM - RJC26A/RJC32A/RON30A RWGL - RJC40A/RON38A/RON42A BEFORE AFTER Adequate Ventilation: Ensure there is adequate ventilation for both the barbecue and cylinder. This is required for proper combustion and to prevent gas build up. Firm Level Surface: Use your barbecue only on a firm level surface. This barbecue is not designed for recreational vehicles, and shall not be installed on a boat or any marine craft.
- Page 7 P a g e...
-
Page 8: Safety Rules
Clean grease tray often so that grease does not accumulate and stay in it which may cause a fire. Do not operate the grill in a windy area. For windy areas we recommend the RCS Wind Guard. (see page 5-6) Do not obstruct the flow of air into the front of the grill or any vent areas. - Page 9 Check gas type – use only the type of gas indicated in the rating plate. Do NOT connect an unregulated gas source to the appliance. You MUST use the regulator(s) that are available from RCS. Safe and satisfactory operation depends to a great extent on the proper installation of the appliance.
-
Page 10: Btu Ratings
11” – 14” W.C. Purchase a standard 20 LB. LP tank with QCC – 1 fitting, and an approved hose and regulator like the RCS RONHK. (Available From Your RCS Dealer) Assemble pipe/hose assembly as shown (not included). 10 |... -
Page 11: Lp Tank Requirement
The RONHK hose kit is shown here. To connect, insert the regulator inlet into the tank valve and turn the black coupler clockwise until the coupler tightens up. DO NOT OVER TIGHTEN THE COUPLER. After completion of assembly, make sure all appliance control valves are OFF then turn the tank supply valve on and then turn the control valves on the grill to the ‘HI/IGN’... -
Page 12: Installation Location/Cut Outs
Wind Guard: WARNING! Your RCS grill should NOT be installed with the back of the grill facing frequent, prevailing winds like a large body of water or open space unless there is a substantial back splash or some way of blocking the wind. In some rare occurrences, when... - Page 13 12 square inches of opening for each (running) 4 feet of counter top. See Item # RVNT1 for approved vents. In the event of an installation in a combustible (wooden) cabinet, you must use an insulated jacket available from RCS. 13 |...
- Page 14 21” 8 ¼” RON30A 33” 20” 11” RON38A 41” 20” 11” RON42A 45” 20” 11” Model Lid Clearance RJC26A 25” RJC32A / RJC32AL 25” RJC40A / RJC40Al 25” RON30A 23” RON38A 23” RON42A 23” 14 | P a g e...
-
Page 15: Gas Connections
15 | P a g e... - Page 16 RDB1EL side burner. HALOGEN LIGHT: The RJC32AL, RJC40AL, RON30A, RON38A & RON42A are provided with a low-wattage transformer. Connect 115V power to the grill. USE the transformer provided! Replacement light bulb is 12v, 5 watts. 16 |...
-
Page 17: Electrical/Wire Diagram
Electrical Wire Diagram 17 | P a g e... -
Page 19: Burner Adjustments
Leak Testing NEVER USE AN OPEN FLAME TO CHECK FOR LEAKS. All gas piping and connections must be tested for leaks after installation or service. All leaks must be corrected immediately. Remember-before exchanging an empty bottle for a new one, make sure all control valves are in the “off” position. With the LP regulator connected to tank and grill and the grill knobs turned to OFF. -
Page 20: Lighting Instructions
If flame is lifting, remove the front panel to access the burner front (air shutter) then turn the air shutter clockwise reducing this intake. The screw should be loosened before turning the air shutter. If the flame has more yellow than blue, the air shutter should be turned counter clockwise allowing more air in. -
Page 21: Operation
Operation DO NOT LEAVE YOUR GRILL UNATTENDED WHILE IN OPERATION. Grill: Grill burners are controlled individually with control knobs. After lighting, turn the knob to HI, LO or in between as desired. Turn on as many burners as required. The top cover may be closed during grilling. -
Page 22: First Time Operation
Remember-your heat indicator is just that, an INDICATOR not an actual thermometer. ALSO-the temperature at the cooking surface is significantly higher than what the heat indicator shows in the lid. Your RCS grill has been designed and manufactured to provide optimum cooking temperatures across a wide range of foods, without “cooking itself to death!”... -
Page 23: Cleaning And Maintenance
Cleaning and Maintenance Cleaning: Your Bar-B-Q grill works better and lasts longer if properly cleaned and maintained. Clean the grill after each use. Turn grill off before starting to clean. Protect your hand with a good mitt when cleaning the hot grill. Use a wire brush, dip in water and scrub the cooking grids to soften and loosen food spills. -
Page 24: Gas Conversion /Trouble Shooting
Check burner inlets, orifice hood (gas inlet to burner), igniter, sparkers, etc. thoroughly and clean before use. Fuel (Gas) Conversion Instructions for RCS grills. This should only be performed by a licensed gas professional Extra regulator: Currently all grills are supplied with a regulator installed. - Page 25 Fuel Conversion of Main Burners: 1- Determine the existing gas type. (LP or Natural gas) Changing the gas type and orifice change out is the same for both gases. 2- You must remove all grates and burner covers to expose the main burners in the grill.
-
Page 26: Troubleshooting
Rotisserie Burner Conversion: 1- Remove the back panel at the rear of the grill, this will expose the V shaped or pyramid shaped brass orifice. 2- Remove the existing orifice and replace with change out orifice. 3- Replace rear panel Trouble Shooting Problem Solution... -
Page 27: Parts Diagram
RJC26A/RJC32A/RJC40A Enlarged View 26 | P a g e... - Page 28 RJC26A/RJC32A/RJC40A Parts List QTY. ITEM PART NO. DESCRIPTION RJC26A RJC32A RJC40A RJC001P 26"-TOP HOOD RJC002P 32"-TOP HOOD RJC051P 40"-TOP HOOD RJC003P ACCESS DOOR RJC004P 26"-REAR HOOD RJC005P 32"-REAR HOOD RJC052P 40"-REAR HOOD RJC006P 26"-WARMING RACK RJC007P 32"-WARMING RACK RJC053P 40"-WARMING RACK RJC008P TOP GRATE RJC009P...
- Page 29 RJC32AL / RJC40AL Enlarged View...
- Page 30 RJC32AL/RJC40AL Parts List QTY. ITEM PART NO. DESCRIPTION RJC32AL RJC40AL RJC002P 32"-TOP HOOD RJC051P 40"-TOP HOOD RJC003P ACCESS DOOR RJC062P 32"-REAR HOOD RJC063P 40"-REAR HOOD RJC007P 32"-WARMING RACK RJC053P 40"-WARMING RACK RJC008P TOP GRATE RJC009P BRIQUETTE TRAY RJC010P CROSSOVER TUBE...
- Page 31 RON30A/RON38A/RON42A Enlarged View 28 | P a g e...
- Page 32 RON30A/RON38A/RON42A Parts List 29 | P a g e...
-
Page 33: Warranty
This warranty excludes normal surface corrosion, discoloration, surface scratches and surface rust which may occur during use. RCS will not be responsible for any damage caused as a result of not following owner’s manual instructions. This non-transferrable warranty is limited to the replacement of original (one- time) defective parts does not include shipping and labor to remove or install replacement parts, if necessary.
Need help?
Do you have a question about the RJC32AL and is the answer not in the manual?
Questions and answers