Subscribe to Our Youtube Channel
Related Manuals for Door Controls DC One
Summary of Contents for Door Controls DC One
- Page 1 INSTALLATION MANUAL Automatic Sliding Door Retrofit Drive Assembly 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050219...
-
Page 3: Table Of Contents
Installation Manual DC One V3 TABLE OF CONTENTS Page 1. Components ......................4 2. Header Preparation ....................4 3. Door Preparation ....................4 4. Motor and Controller Installation ................4 5. Wiring of Accessories .................... 5 6. Drive Belt and Bracket Installation ................. 5 7. -
Page 4: Components
4. MOTOR AND CONTROLLER INSTALLATION · Install DC One motor/gearbox and controller per the instructions shown on the enclosed drawing. 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com... -
Page 5: Wiring Of Accessories
· Perform a factory reset - Refer to Sections 12 and 13. · Press the TEST button on the DC One control to trigger an activation cycle. · When the learn cycle is complete, normal operation will resume according to default values set in the control. -
Page 6: Safety Test And Documentation
DC One V3 9. SAFETY TEST AND DOCUMENTATION When all DC One and sensor adjustments are complete, perform a thorough safety test to validate proper and safe performance in accordance with current ANSI A156.10 guidelines as well as recommendations prescribed by the American Association of Automatic Door Manufacturers (AAADM). -
Page 7: I/O Connector Layout And Description
Installation Manual DC One V3 11. I/O CONNECTOR LAYOUT AND DESCRIPTION Note: The control should be tested prior to connecting any external devices, sensors, push pads, or locks. J6 - Multifunction Switch - Pins 1 to 6 Common + Compatible with DC position... -
Page 8: How To Enter Program Mode
Common + J8 - Lock - Sensor Monitoring DC One Lock · Pins 1 to 6 are used to control the DC One lock DC One Lock · Lock voltage is selectable between 12 and 24 volts with toggle switch. - Page 9 Installation Manual DC One V3 · Lists the fault that the control is currently Door Position under DOOR POSITION 00258 · None act sf ro bo 0 X Y · Broken or Loose Belt This is a status only screen that gives the ·...
- Page 10 Installation Manual DC One V3 Open Speed Close Torque CLOSE TORQUE OPEN SPEED 072.0% 056.3% · Ranges from 5 to 100% · Ranges from 0 to 100% · Not adjustable. They are set during auto Close Speed...
-
Page 11: Part Numbers
-4F to 158F (-20C to +70C) 30% to 85% Relative Humidity 16. WARRANTY TERMS 1 Year from date of purchase form Door Controls USA, Inc. 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com... -
Page 12: Troubleshooting Tips
17. TROUBLESHOOTING TIPS Before wiring any sensors into the DC One control, it is a good idea to apply power and test the door to ensure it will power open and closed when the TEST button is pressed. · Use caution during this test as the sensors will not be operational ... - Page 13 DO NOT compromise proper performance. If repairs cannot be immediately made, shut the door OFF and inform the owner of any special instructions and corrective actions. Contact Door Controls USA for further technical support when needed: Door Controls USA, Inc.
-
Page 14: Wiring Diagrams
Installation Manual DC One V3 18. WIRING DIAGRAMS ON / OFF SWITCH ON / OFF / HO SWITCH COMMON + COMMON + ONE WAY ONE WAY PARTIAL OPEN PARTIAL OPEN HOLD OPEN HOLD OPEN RESET RESET 24 VDC 24 VDC... - Page 15 Installation Manual DC One V3 DURAGLIDE FUNCTION SWITCH ORANGE PURPLE BROWN BLUE BLUE PURPLE YELLOW On Stanley Duraglide replace label for function switches with the one included in kit (DC-3392). 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com...
- Page 16 Installation Manual DC One V3 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050819...
- Page 17 Installation Manual DC One V3 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050819...
- Page 18 Installation Manual DC One V3 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050819...
- Page 19 Installation Manual DC One V3 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050819...
-
Page 20: Ixio Dt1 Sensor Monitoring Schematic And Setup
Installation Manual DC One V3 19. IXIO DT1 SENSOR MONITORING SCHEMATIC AND SETUP TEST PURPLE TEST PURPLE SAFETY BLUE SAFETY BROWN WHITE YELLOW GREEN BLUE INT SAFETY PURPLE COM + POWER BLACK BLUE EXT SAFETY POWER PURPLE SENSOR MON 24VDC... -
Page 21: Optex I-Onex T Sensor Monitoring Schematic And Setup
Installation Manual DC One V3 20. OPTEX i-ONE X T SENSOR MONITORING SCHEMATIC AND SETUP YELLOW INT SAFETY GREY BLACK WHITE BLACK GREY COM+ YELLOW EXT SAFETY WHITE BLACK BLACK SENSOR MON YELLOW WHITE BLACK YELLOW BLACK BLACK GREY GREY... - Page 22 321 VZ County Road 4500 · Ben Wheeler, TX 75754 · Phone: 800.437.3667 · Fax: 800.356.8858 · DoorControlsUSA.com Rev050819...
Need help?
Do you have a question about the DC One and is the answer not in the manual?
Questions and answers