Page 1
Self Diagnosis Supported model HISTORY INFORMATION FOR THE FOLLOWING MANUAL: SERVICE MANUAL LEVEL CONFIDENTIAL ELECTRICAL SERVICE INTERNAL DISTRIBUTION ONLY MODEL COMMANDER DESTINATION KDL-24R400A RM-YD092 Mexico / Latin America KDL-24R405A RM-YD093 Chile / Peru / Venezuela KDL-24R407A RM-YD093 Colombia KDL-32R400A RM-YD093...
Chassis: RB1FK, BA TABLE OF CONTENTS SECTION TITLE PAGE SECTION 1: DIAGRAMS ........................................3 1-1. Printed Circuit Boards and Schematic Diagrams Information ........................3 1-2. Connector Diagrams ......................................4 1-3. Main Board (A Board) ......................................5 A Board Component Side ....................................5 A Board Conductor Side ....................................6 A Board Schematic ......................................7 1-4.
Page 3
Ne les remplacer que par des composants Sony dont le numero de piece est indique dans le present manuel ou dans des supplements publies par present manuel. Suivre ces procedures lors de chaque remplacement de composants critiques, ou lorsqu’un mauvais fonctionnement suspecte.
Page 4
Chassis: RB1FK, BA SETTING UP AND CARRYING THE TV • Disconnect all cables when carrying the TV. • Carry the TV with the adequate number of people; larger size TVs require two or more people. • Correct hand placement while carrying the TV is very important for safety and to avoid damage. USE CAUTION WHEN HANDLING THE LCD PANEL When repairing the LCD panel, be sure you are grounded by using a wrist band.
Page 5
Chassis: RB1FK, BA SAFETY CHECK-OUT LEAKAGE TEST After correcting the original service problem, perform the following safety checks before releasing the set to the The AC leakage from any exposed metal part to earth customer: ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed Check the area of your repair for unsoldered or 0.5 mA (500 microamperes).
Page 6
Chassis: RB1FK, BA The circuit boards used in these models have been processed using Lead Free Solder. The boards are identified by the LF logo located close to the board designation e.g. H1 etc [ see example ]. The servicing of these boards requires special precautions to be taken as outlined below.
Chassis: RB1FK, BA SECTION 1: DIAGRAMS 1-1. PRINTED CIRCUIT BOARDS AND SCHEMATIC DIAGRAMS INFORMATION REFERENCE INFORMATION All capacitors are in µF unless otherwise noted. pF : µµF 50WV or CAPACITOR RESISTOR less are not indicated except for electrolytics and tantalums. : TA TANTALUM : RN...
Chassis: RB1FK, BA 1-3. MAIN BOARD (A BOARD) [SYSTEM POWER/YPBPR/AV/SPDIF/USB/HDMI/DDR/FLASH/PREAMP/AUDIO AMP/LVDS/DEMOD/TUNER/ETHERNET] A BOARD COMPONENT SIDE — — — — — — Chassis: RB1FK, BA —...
Chassis: RB1FK, BA [SYSTEM POWER/YPBPR/AV/SPDIF/USB/HDMI/DDR/FLASH/PREAMP/AUDIO AMP/LVDS/DEMOD/TUNER/ETHERNET] A BOARD CONDUCTOR SIDE — — — — — — Chassis: RB1FK, BA —...
Chassis RB1FK, BA A BOARD SCHEMATIC A BOARD SCHEMATIC DIAGRAM (1 OF 20) DDR3x1 NAND Flash (1GB) 64 MB DEMO LCM Panel S-Tuner CXD2817ER(PAD) RE227TN(PAD) CXD2837ER(COL) LVDS CXD2838ER(CHI) RA227TN(NA/MX) Demodulador RB221TN(COL/CHI) PAL/SECAM/ATSC Speaker Amplifier (8 Ω/10W) HP Driver MT5367/5389 Headphone/Line out Ypbpr/CVBS SPDIF Ypbpr-R/L/CVBS-R/L...
Page 12
Chassis RB1FK, BA A BOARD SCHEMATIC DIAGRAM (2 OF 20) Title Title Title Power Structure Power Structure Power Structure FY13 BA_MT5389 FY13 BA_MT5389 FY13 BA_MT5389 Thursday, February 28, 2013 Thursday, February 28, 2013 Thursday, February 28, 2013 Chassis RB1FK, BA...
Page 13
Chassis RB1FK, BA A BOARD SCHEMATIC DIAGRAM (3 OF 20) MT5367/MT5389 IC definition Definition Title Title Title GPIO list GPIO list GPIO list FY13 BA_MT5389 FY13 BA_MT5389 FY13 BA_MT5389 Thursday, December 20, 2012 Thursday, December 20, 2012 Thursday, December 20, 2012 Chassis RB1FK, BA...
Page 24
Chassis RB1FK, BA A BOARD SCHEMATIC DIAGRAM (14 OF 20) Analog Normal Power AVDD3V3 THE PLACE CLOSE TO MT5389 R402 R402 ADAC_3V3 AVDD33_MEMPLL R403 R403 [18] USB_PWR_EN0 AMP_SDA [19] AVDD33_DAC AVDD33_DAC [13] MAIN_IF_AGC AVDD12_VPLL C402 C402 C403 C403 AMP_BCK [19] C404 C404 0603...
Chassis RB1FK, BA 1-4. ELECTRICAL PARTS LIST / MAIN BOARD (A) RESISTORS NOTE: The components identified by a red outline and a mark contain Items marked with an asterisk are not NOTE: The components identified by shading • All resistors are in ohms confidential information.
A L L c a p a c i t o r s a r e i n u F ( p : p F ) u n l e s s o t h e r w i s e n o t e d . THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 36
A L L c a p a c i t o r s a r e i n u F ( p : p F ) u n l e s s o t h e r w i s e n o t e d . THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Page 37
A L L c a p a c i t o r s a r e i n u F ( p : p F ) u n l e s s o t h e r w i s e n o t e d . THIS DOCUMENT IS THE PROPRIETARY PROPERTY OF SONY. ITS USE IS AUTHORIZED ONLY FOR RESPONDING TO A REQUEST FOR QUOTATION, OR FOR THE PERFORMANCE OF WORK FOR SONY. ALL QUESTIONS MUST BE REFERRED TO THE LOCAL PURCHASING DEPARTMENT OF SONY.
Chassis RB1FK, BA SECTION 3: IR BOARD (H BOARD) [LED/SIRCS] H BOARD COMPONENT SIDE — — [LED/SIRCS] CONFIRM THESE FEATURES H BOARD CONDUCTOR SIDE — — — — — — — Chassis RB1FK, BA...
MUST BE RETURNED to Sony. b. and if the core charge is NOT covered under the product warranty, the defective un-repaired or modified board MUST BE DESTROYED.