Table of Contents
Advertisement
Quick Links
RRM-RTM Series
Riser and Tank Mounted
Oil-less Air Compressors
Installation, Operation and
Maintenance Manual
Reliable Automatic Sprinkler Co., Inc.
103 Fairview Park Drive, Elmsford, New York 10523
800-55-RASCO (800-557-2726) Technical Support
www.reliablesprinkler.com
Reliable RRM-RTM Series IOM_Rev 1.7_2-4-20
Advertisement
Table of Contents
Related Manuals for Reliable RRM Series
Summary of Contents for Reliable RRM Series
- Page 1 RRM-RTM Series Riser and Tank Mounted Oil-less Air Compressors Installation, Operation and Maintenance Manual Reliable Automatic Sprinkler Co., Inc. 103 Fairview Park Drive, Elmsford, New York 10523 800-55-RASCO (800-557-2726) Technical Support www.reliablesprinkler.com Reliable RRM-RTM Series IOM_Rev 1.7_2-4-20...
-
Page 2: Table Of Contents
Section 5 - Lubrication Section 6 - Piping 6.1 - Piping Instructions 6.2 - RRM Series Riser Mounted Oilless Air Compressor Installation Drawing 6.3 - RTM Series Tank Mounted Oilless Air Compressor Installation Drawing Section 7 - Wiring 7.1 - Wiring Instructions 7.2 - Oilless Air Compressor Single Phase Wiring Drawing... -
Page 3: Section 1 - Safety & Warnings
Section 1 - Safety & Warnings 1.1 Safety Guidelines This manual contains information that is very important to know and understand. This information is provided for SAFETY and to PREVENT EQUIPMENT PROBLEMS. To help recognize this information, observe the following symbols. - Danger indicates an imminently hazardous situation which, if not avoided, WILL DANGER result in death or serious injury. -
Page 4: Section 2 - Receiving
Section 4 - Mounting RRM Series (Riser mounted units) may be mounted to a firm level floor, wall or system riser. A mounting bracket and straps are provided. RTM Series (Tank mounted units) must be leveled and anchored to the floor; the vibration isolators supplied with the unit must be used. -
Page 5: Section 6 - Piping
Section 6 - Piping 6.1 Piping Instructions - Compressed air contains liquid water and is saturated with water vapor, which can WARNING freeze when surrounding temperatures are lower than 32°F (0°C). Component selection to minimize the effects of water vapor must be considered. Piping between the compressor, accessory items and the sprinkler system must be at least ½”... -
Page 6: Rrm Series Riser Mounted Oilless Air Compressor Installation Drawing
6.2 RRM Series Riser Mounted Oilless Air Compressor Installation Drawing... -
Page 7: Rtm Series Tank Mounted Oilless Air Compressor Installation Drawing
6.3 RTM Series Tank Mounted Oilless Air Compressor Installation Drawing... -
Page 8: Section 7 - Wiring
Section 7 - Wiring 7.1 Wiring Instructions - Wiring should be in accordance with the national electrical code and any local codes or WARNING regulations. Have a licensed and competent electrician ensure that the voltage supplied matches the compressor voltage. CAUTION - Inadequate wiring size can cause insufficient voltage at the compressor during start-up. -
Page 9: Oilless Air Compressor Single Phase Wiring Drawing
7.2 Oilless Air Compressor Single & 3 Phase Wiring Drawing... -
Page 10: Section 8 - Adjusting The Pressure Switch
*Differential Pressure is defined as the difference between cut-out and cut-in pressure. Turning the differential pressure screw clockwise increases the differential pressure, which increases the cut-out pressure without changing the cut-in pressure. RRM-RTM Replacement Parts Without Tank Reliable P/N 6990021904 Pressure Switch With Tank Reliable P/N 6872000028 Without Tank... -
Page 11: Section 9 - Maintenance Instructions
3. Air flow to fan blocked 3. Clean air flow to fan or relocate unit 1. Damaged bearings 2. Worn piston cup Excessive noise in Contact Reliable for technical support 3. Broken valves operation 4. Loose fan 5. Damaged fan guard 1. -
Page 12: Section 11 - Warranty Policy
Replacement parts provided under the terms of the warranty are warranted which may vary from those in neighboring areas. While Reliable Automatic for the remainder of the Warranty Period of the product upon which Sprinkler Co., Inc.
Need help?
Do you have a question about the RRM Series and is the answer not in the manual?
Questions and answers