BendPak TS-580V-601 Installation And Operation Manual
  1. Manuals
  2. Brands
  3. BendPak Manuals
  4. Air Compressor
  5. TS-580V-601
  6. Installation and operation manual

BendPak TS-580V-601 Installation And Operation Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
INSTALLATION AND OPERATION MANUAL
ELITE™ AIR COMPRESSOR - 80-GALLON VERTICAL TANK
MODEL:
TS-580V-601
SHIPPING DAMAGE CLAIMS
When this equipment is shipped, title passes
to the purchaser upon receipt from the carrier.
Consequently, claims for the material damaged in
shipment must be made by the purchaser against
the transportation company at the time shipment
is received.
PLEASE READ THE ENTIRE CONTENTS OF THIS MANUAL PRIOR TO
INSTALLATION AND OPERATION. BY PROCEEDING YOU AGREE THAT
YOU FULLY UNDERSTAND AND COMPREHEND THE FULL CONTENTS OF
THIS MANUAL. FORWARD THIS MANUAL TO ALL OPERATORS. FAILURE TO
OPERATE THIS EQUIPMENT AS DIRECTED MAY CAUSE INJURY OR DEATH.
BE SAFE
Your new BendPak air compressor was designed and
built with safety in mind. However, your overall
safety can be increased by proper training and
thoughtful operation on the part of the operator.
DO NOT operate or repair this equipment without
reading this manual and the important safety
instructions shown inside.
Keep this operation manual near the
machine at all times. Make sure that
ALL USERS read this manual.
1645 Lemonwood Dr.
Santa Paula, CA. 93060, USA
Toll Free 1-800-253-2363
Tel: 1-805-933-9970
Fax: 1-805-933-9160
www.bendpak.com
REV A 10-05-16
PN# 5900391

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the TS-580V-601 and is the answer not in the manual?

Questions and answers

Related Manuals for BendPak TS-580V-601

Summary of Contents for BendPak TS-580V-601

  • Page 1 SHIPPING DAMAGE CLAIMS BE SAFE When this equipment is shipped, title passes Your new BendPak air compressor was designed and to the purchaser upon receipt from the carrier. built with safety in mind. However, your overall Consequently, claims for the material damaged in...
  • Page 2 For additional copies or further information, contact: 2. Check the voltage, phase and proper amperage BendPak Inc. / Ranger Products requirements for the motor shown on the motor plate. Wiring 1645 Lemonwood Dr., should be performed by a certified electrician only.

  • Page 3: General Safety

    GENERAL SAFETY 12. Tanks rust from moisture build-up, which weakens the tank. Make sure to drain tank regularly and inspect Since the air compressor and other components periodically for unsafe conditions such as rust formation and (material pump, spray guns, filters, lubricators, hoses, etc.) corrosion.

  • Page 4: Spraying Precautions

    SPRAYING PRECAUTIONS NOTE: If compressor operates in a hot, moist environment, supply compressor pump with clean, dry outside air. Supply air should be piped in from external sources. 1. Fast moving air will stir up dust and debris which may be harmful.
  • Page 5 WIRING Connect piping system to tank using the same size fitting as the discharge port. Pipe thread lubricant must be used on all male pipe threads, and all joints are to be made up tight, since small leaks in the All wiring and electrical connections must be performed by piping system are the largest single cause of high operating a qualified electrician.
  • Page 6 V-MAX SERIES DESCRIPTION OF PARTS ON/OFF SWITCH SIDE VIEW On/Off Switch Incoming Power (See Page 7) Service Valve Safety Valve (See Page 7) Pressure Switch NOTE: THIS UNIT CONTAINS NO OIL WHEN SHIPPED. FILL WITH OIL BEFORE OPERATING COMPRESSOR. USE ONLY THIS RECOMMENDED OIL: ISO100, NON-DETERGENT, COMPRESSOR OIL.

  • Page 7: Direction Of Rotation

    Recommended wire sizes may be larger than the 1. Rewire motor per data plate on motor or instruction sheet. minimum set up by local ordinances. If so, the larger size wire should be used to prevent excessive line voltage 2. Check electric rating of magnetic starter and replace drop.
  • Page 8 LUBRICATION AIR TANK SAFETY VALVE If the pressure switch does not shut off the air compressor at its cut-out pressure setting, the safety valve will protect against high pressure by “popping off” at its factory set pressure (slightly higher than the pressure switch cut-out THIS UNIT CONTAINS NO OIL WHEN SHIPPED.

  • Page 9: Break-In Procedures

    BREAK-IN PROCEDURES OPERATING PROCEDURES Daily Start-Up Checklist This procedure is required before the air compressor is put into service, before the hose is installed, the check valve is 1. Check oil and add if necessary. Do not change oil while replaced, or a complete compressor pump is replaced.

  • Page 10: Maintenance

    TANK Drain liquid from tank daily or after each use. The tank should be carefully inspected at a minimum of once a DRAIN AIR TANK DAILY. Water will condense in the air year. Look for cracks forming near the welds. tank.

  • Page 11: Air Filter

    AIR FILTER Never run the compressor pump without an intake air filter or with a clogged intake air filter(s). Use compressed air to blow the filters clean. Do not wash or oil the element. If it cannot be blown clean, the filter(s) must be replaced. Operating compressor with a dirty filter can cause high oil consumption and increase oil contamination in the discharge air.

  • Page 13: Description Qty

    TS-580V-601 PARTS LIST DESCRIPTION QTY. DESCRIPTION QTY. PUMP FLARED JOINT MOTOR EXHAUST PIPE AIR RECEIVER AIR RECEIVER MAGNETIC SWITCH ELBOW BALL VALVE NIPPLE-M NIPPLE NIPPLE-F PRESSURE SWITCH BALL VALVE PRESSURE GAUGE TAPER-LOCK PULLEY UNLOADING ELBOW V-BELT BELT GUARD UNLOADING COPPER PIPE...

  • Page 14: Water Drainage

    WATER DRAINAGE...

  • Page 15: Changing Oil

    OUR UNITS ARE SHIPPED WITH NO OIL. FILL WITH OIL BEFORE STARTING. CHECK THE OIL LEVEL AND QUALITY BEFORE OPERATING THE COMPRESSOR. DO NOT ADD OR CHANGE OIL WHILE COMPRESSOR IS IN OPERATION. USE ONLY THE BELOW RECOMMENDED COMPRESSOR OIL: ISO100, NON-DETERGENT, COMPRESSOR OIL.

  • Page 16: Specifications

    SPECIFICATIONS TS-580V-601 MODEL:...
  • Page 18 MAINTENANCE / INSPECTION RECORDS ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________...
  • Page 19 NOTES ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________ ____________________________________________________________________...

Table of Contents