All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 31674 Version 1.4...
Page 2
1.0 TECHNICAL SPECIFICATION General Playback disc type: DVD, Picture-CD, SVCD, Video CD, MP3- CD, CD-R/CD-RW, WMA-CD, DVD-R, DVD- Dimensions (W x H x D): 210 x 178 x 39mm RW, DVD+R, DVD+RW Weight: 1.9kg Power supply: Input: 100-240V AC, 50/60Hz Video Playback Format: DVD / VCD / JPEG 0.3A...
Page 3
For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. A) By CD-ROM Download the “PHILIPS.BIN” file from the Philips support site Unzip the file and then burn it into a CD-ROM to make a disc for upgrade CD-ROM disc name must be “PHILIPS”...
Page 4
2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 5
2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
Page 6
SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
4.0 MECHANICAL INSTRUCTION Disassembly Procedure Remove 7pcs of screws on the bottom cabinet and remove 1pc of screw in middle cabinet (we can find it after open CD door) Open the bottom cabinet carefully and unplug the wire connector of key board from the main board.
Page 9
4.0 MECHANICAL INSTRUCTION Remove all the screws on the battery board and then take out the battery with battery board. Remove 11pcs screws from key board. Remove 6pcs of screws on the display frame. Carefully open the display frame with the catches by screwdriver. (There are six catches as shown in the picture) To remove the TFT, de-soldering the wire...
Page 10
4.0 MECHANICAL INSTRUCTION To remove the hinge, remove the screws on the hinge.
5.0 TROUBLESHOOTING SYMPTOM: BATTERY NO POWER BATTERY CAN'T Power ON Start Check charging Check adaptor Check Battery capacity? SET OK? function OK? power-ON OK? Check the Power-ON No Defect, return button and cable OK? set to Customer Replace Button or Replace Main Board Cable...
Page 12
5.0 TROUBLESHOOTING SYMPTOM: NO IMAGE / NO SOUND SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE) Start Check DVD Drive work? Replace DVD Drive Check the external AV NOTE: AV Cable TYPE from outside to note Cable TYPE Exchange AV cable Inside L-Audio, R-Audio, Video, Ground connection is OK?
Page 13
5.0 TROUBLESHOOTING SYMPTOM: THE DVD DRIVE DOES NOT WORK SYMPTOM: THE DVD DRIVE DOESN'T WORK Start Check DVD-Loader Cable Reinsertion connection OK? Check the DVD-Loader Replace DVD- Loader Replace main board...
Page 14
5.0 TROUBLESHOOTING SYMPTOM: ADAPTOR CANNOT POWER ON Adaptor can not Power ON Start Check Adaptor OK? Change adaptor SET OK? Check the Power-ON Return set to Replace Main Board button and cable OK? Customer Replace Button or Cable...
Page 15
5.0 TROUBLESHOOTING SYMPTOM: REMOTE CONTROL CANNOT WORK SYMPTOM: THE REMOTE CONTROL CAN NOT WORK Start Check CABLE form bottom board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace IR receiver Replace top board Replace main board Return to custormer...
Page 16
5.0 TROUBLESHOOTING SYMPTOM: NO SOUND FROM HEADPHONE...
Page 17
5.0 TROUBLESHOOTING SYMPTOM: LED DISPLAY FAILURE SYMPTOM: LED Display Fail Start Check CABLE form Main board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace LED Replace top board Replace main board Return to custormer...
Page 18
5.0 TROUBLESHOOTING SYMPTOM: KEY & BOTTON FAILURE SYMPTOM: Key & Botton Fail Start Check CABLE form board to Cable Reinsertion board connection OK? Check KEY board OK? Replace KEY board Replace main board Return to custormer...
Page 19
DC IN DC-DC 27MHz AUDIO L SPEAKER L-CH TDA2822 AUDIO R SPEAKER R-CH AUDIO L 4*16M BOARD Earphone1&2 AUDIO R FLASH EEPROM SDRAM IR (RC6) BOARD Title PET714 block diagram Size Document Number <Doc> Date: Friday, January 05, 2007 Sheet...
Page 25
7.0 ELECTRICAL DIAGRAM 7.2 KEY PCBA ASSY key1 LEFT key2 ENTER SETUP STOP key3 MENU PREV PLAY/PAUSE key4 DOWN NEXT key5 RIGHT Title <Title> Size Document Number <Doc> Date: Tuesday, March 20, 2007 Sheet...
Page 32
8.0 SERVICE PART LIST Mechanical Part List: Service Service Description Photo Pos. 12NC 996510002383 OK BUTTON 996510002389 MENU BUTTON 996510002390 F.F / REW BUTTON 996510002391 PLAY / STOP BUTTON 996510002392 DOOR EJECT BUTTON 996510002393 DOOR SLIDE 996510002394 DOOR BUTTON BRACKET 996510002380 BUTTON BRACKET (BLACK) 996510002381...
Page 33
8.0 SERVICE PART LIST Accessories Part List: Service Service Description Photo Pos. No. 12NC AC/DC ADAPTER EU (for PET714/55, 996510002353 PET714/00, PET714/12 & PET714/94, ACADAPTOR PET718/12) 996510002403 AC/DC ADAPTER US (for PET714/37) ACADAPTOR 996510005473 AC/DC ADAPTER AUS (for ET714/75) ACADAPTOR...
Update chapter 8.0 to add service part 996510003847 for PET714/94 Version 1.2 (3141 785 31672) • Update chapter 8.0 to add service part 996510005473 & 996510005474 for PET714/75 Version 1.3 (3141 785 31673) • Update chapter 8.0 to add service part for PET714/12 & PET714/05 Version 1.4 (3141 785 31674)