Philips PET100 Service Manual
Hide thumbs
Also See for PET100:
- Service manual (32 pages) ,
- User manual (12 pages) ,
- Specifications (2 pages)
Advertisement
Quick Links
DVD Portable Player
Service Manual
TABLE OF CONTENTS
Technical Specification & Service Tips......................... 1
Safety Instructions..................................................... 2
Instruction for Use...................................................... 3
Mechanical Instructions.............................................. 4
Troubleshooting .........................................................5
Overall Block Diagram................................................. 6
Electrical Diagram...................................................... 8
Component Layout.................................................... 9
Service Part List......................................................... 10
Revision List............................................................. 11
©Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may by reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronics,
mechanical, photocopying, or otherwise without the prior permission of Philips
Version 1.3
PET100/PET101
All version
Chapter
3141 785 33103
Advertisement
Related Manuals for Philips PET100
Summary of Contents for Philips PET100
-
Page 1: Table Of Contents
All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 33103 Version 1.3... - Page 2 Headphone out (headphone output load 2x16 ohm) Check www.philips.com/support for latest software upgrades available. >10mW Maximum output power: Frequency response: 20Hz – 20kHz Download the latest software from the Philips SNR (A-wght): 80dB typical support site THD ( <1% 0.2-20kHz)
- Page 3 2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
- Page 4 2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
- Page 5 SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
-
Page 6: Instruction For Use
3.0 INSTRUCTIONS FOR USE MAIN UNIT CONTROL - VOL + Up / down cursor. Volume control. POWER Skip to the previous/next Switch the power on/off. chapter, track or title. POWER/IR/CHR Power /remote sensor /charging Start or interrupt playback. indicator. OPEN MENU Open the disc door to insert Enter or exit the disc contents... - Page 7 REMOTE CONTROL MENU SUBTITLE Display MENU page. Subtitle language selector. , , , RETURN Up / down / left / right For VCD menu page. navigation key. A - B To repeat or loop a sequence Confirm seletion. in a title. VOL +/- SETUP Volume control.
- Page 8 4.0 MECHNICAL INSTRUCTIONS PET101 1. Back View as Fig.1 Divided the top into the door and function Remove screws and broken connections to button discreteness and the middle cabinet discreteness, remove screws to remove remove the top. the function PCB from the door and function button discreteness as Fig.4.
-
Page 9: Troubleshooting
5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: NO POWER, NO GREEN LED start Check if the power cable replace cable/ No defect, return set OK? adapter set to customer AC adapter Check if the replace connector power and play and switch unit button OK? replace MAIN go to other... - Page 10 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE INITIAL SCREEN IS NOT DISPLAYED ON THE LCD Refer to the symptom NO start POWER, NO GREEN LED Replace broken Check if the Repair connector harness LED on the front lights up? Remove the LCD Open the top and Is the cover and plate of...
- Page 11 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE DVD DRIVE DOES NOT WORK Press the DISC cover switch at the center of the DVD player and turn on the power. Then check whether or not the optical pick- up lens of the DVD drive lights. CAUTION: start Visible laser radiation when open and interlock defeated.
- Page 12 5.0 TROUBLESHOOTING & SERVICE TIPS SYMPTOM: THE DVD DRIVE DOES NOT OPERATE WITH BATTERY start Install a good battery does the LED lights up orange while the AC adapter is connected and does the DVD drive operate OK? NOTE: - For this check, use a battery which is not fully Replace battery charged (because the LED does not light when the battery is fully charged.)
-
Page 13: Overall Block Diagram
6.0 OVERALL BLOCK DIAGRAM 8M FlashROM 64M SDRAM TC4W53 EN25B16 HY57V641620ETP-7-C RF AMP & SERVO & DVD PROCESSOR KHM252G MPEG-2 DECODER & VIDEO ENCODER PU mechanism MT1389DE/L-L VIDEO OUT +3.3V +1.8V DRIVER DRIVER +5.5V (SA5954) 110~240V 50/60Hz Adapter AUDIO AMP UTC4558 AUDIO OUT +/-5V... -
Page 14: Electrical Diagram
8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (AUDIO) CONNECT JS4 2SD601 2SD601 A_MUTE VD28 VD28 R515 R515 CVBS-OUT VIDEO OUT C516 C516 100PF 100PF 100U/16V 100U/16V R521 R521 R522 R522 4558 4558 R524 R524 U501B U501B 47U/4V 47U/4V 5.1K 5.1K C520 C520 47U/4V... - Page 15 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (MT1389L/K) 89L_3V3 AADVDD VDD33_F L101 L101 APLLVDD3 R200 R200 100k 100k TestPoint & Resistor thrice resonance must reserve. crystal need add C208 C208 Y200 Y200 DACVDD3 DACVDD3 L204 L204 TP212 TP212 R287 R287 10uF/10v 10uF/10v 0.1uF...
- Page 16 8.0 ELECTRICAL DIAGRAM MAIN BOARD CIRCUIT DIAGRAM (POWER) 1715B 1715B FMC3 FMC3 10nF 10nF 3.9nF 3.9nF AP1534 AP1534 MP1412 MP1412 P5504EVG P5504EVG VD25 VD25 HEC4801-010010 HEC4801-010010 0430003WR 0430003WR LV-R0484 LV-R0484 COMP VD10 VD10 100N 100N BAV99 BAV99 B240A B240A 100U/16V 100U/16V 100UH 100UH...
-
Page 17: Component Layout
9.0 COMPONENT LAYOUT PET101M MAIN BOARD DIAGRAM... - Page 18 9.0 COMPONENT LAYOUT PET711K FUNCTION BOARD DIAGRAM...
-
Page 19: Service Part List
10.0 SERVICE PART LIST Electrical Part List: Service Service Description Photo Pos. 12NC PET101/12 996510018823 PET101M MAIN PCBA /12 PET100/12 996510021557 PET100M MAIN PCBA/12 PET101/12 PET711K FUNCTION 996510010518 PET100/12 PCBA Mechanical Part List: Service Service Description Photo Pos. 12NC PET101/12... - Page 20 10.0 SERVICE PART LIST Mechanical Part List: Service Service Description Photo Pos. 12NC BASE COVER PET101/12 996510018824 DISCRETENESS BASE COVER PET100/12 996510010523 DISCRETENESS PET101/12 996510010526 MAIN PCB SHIELD COVER PET100/12 PET101/12 996510010524 DOOR SPRING A PET100/12 PET101/12 996510010525 DOOR SPRING B...
- Page 21 10.0 SERVICE PART LIST Accessories Part List: Service Service Description Photo Pos. No. 12NC ADPV60A AC/DC PET101/12 996510010987 ACAPT ADAPTER /12 ADPV60A AC/DC PET100/12 996510021559 ADAPTER /12 PET101/12 994000001912 AV CABLE AVCABLE PET101/12 996510010527 RC-AY5513 REMOTE PET100/12 SCART LINKER / PET101/12...
-
Page 22: Revision List
Initial release PET101/12 Version 1.1 (3141 785 33101) • Update partlist – to add on/off power button Version 1.2 (3141 785 33102) • Update chapter 10 – change FFC 12NC from 996510014378 to 996510020229 Version 1.3 (3141 785 33103) • Add PET100/12...