Table of Contents
Advertisement
Quick Links
Blue-Ray Disc Player
C
o
n
e t
n
s t
...................................................1-1 to 1-10
2 Laser Beam Safety Precautions......................................... 2-1
3 Important Safety Precautions .................................. 3-1 to 3-2
4 Safety Check After Servicing ............................................. 4-1
Requirements .................................................................... 5-1
7 Direction of Use ....................................................... 7-1 to 7-6
8 Cabinet Disassembly Instructions ........................... 8-1 to 8-2
9 Troubleshooting ....................................................... 9-1 to 9-2
10 Block Diagram .................................................................10-1
11 Wiring Diagram ...............................................................11-1
12 Headphone & MP3 Link and USB、LED Board
Circuit Diagram ....................................................12-1
Layout Diagram ...................................................12-1
13 AMP Board
Circuit Diagram ....................................................12-2
Layout Diagram ...................................................12-3
© Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands.
All rights reserved. No part of this publication may be reproduced, stored in a
retrieval system or transmitted, in any form or by any means, electronic,
mechanical, photocopying, or otherwise without the prior permission of Philips.
Published by Sophie-KM 1123 AVM
Version 1.0
All manuals and user guides at all-guides.com
P
a
g
e
Printed in the Netherlands
Contents
14 Display Board
Circuit Diagram ................................................12-4
Layout Diagram ...............................................12-5
15 Key Board
Circuit Diagram .................................................12-6
Layout Diagram.................................................12-7
16 Power Board
Circuit Diagram ........................................12-8 to 12-9
Layout Diagram ..............................................12-10
17 Decoder Board
Circuit Diagram .................................12-11 to 12-19
Layout Diagram ..............................................12-20
18 Exploded View....................................................................13-1
19 Revision List .......................................................................14-1
Features
RDS
Voltage Selector
ECO Standby
DTS
Subject to modi cation
MBD7020/12/93
Page
Feature
Different
/12 /93
EN
3141 785 36200
Advertisement
Table of Contents
Related Manuals for Philips MBD7020
Summary of Contents for Philips MBD7020
-
Page 1: Table Of Contents
Different /12 /93 Features © Copyright 2011 Philips Consumer Electronics B.V. Eindhoven, The Netherlands. All rights reserved. No part of this publication may be reproduced, stored in a Voltage Selector retrieval system or transmitted, in any form or by any means, electronic, ECO Standby mechanical, photocopying, or otherwise without the prior permission of Philips. -
Page 2: Technical Specification And Connection Facilities
Bl-Ray Loader Key Board USB Board Power Board Headphone/MP3 Link Board LED Board Display Board Version Variations Type /Versions: MBD7020 Service policy Board in used: LED Board Decoder Board Display Board AMP Board Headphone & MP3 Link Board Power Board... - Page 3 Technical Specification and Connection Facilities Technical Specification 2 General Specification Product family features 2.1.1 Styling and functions MBD7020 appearances are defined In MUS. MUS is the leading document where product appearance is applicable. MBD7020 Features Products [ALL Stroke Version] s l i Dimension [250x93.5 x286]mm...
- Page 4 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities MBD7020 Interface Type [All Stroke Version] USB Type A Receptacle [Color: Black] 2.1.3 Product Controls MBD7020 Remark Controls / Indicators [ALL Stroke Version] h t i Buttons Rotary Fade-on and Fade-off effect is required.
- Page 5 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities 3.2 Climatic Tests 3.2.1 Exposure Test (Non-Operating) 3.2.2 Functional Test (Operating) 4 Performance Specifications 4.1 Audio Performance 4.1.1 Reference levels Audio inputs Audio Outputs Audio Input Sensitivity (±3dB) rated output power at 1KHz Audio Output(*1) Tuner FM 67.5KHz,Modulation (Limit:-6dB)
- Page 6 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities 4.1.2 Amplifier Output Measurements are done with rated speaker impedance. Description Specification Rated Output Power @ 10%THD 50W± 0.5dB Channel Unbalance(1KHz) |2.0|dB Crosstalk (20Hz – 20KHz) |50|dB Frequency Response (30Hz –...
- Page 7 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities 4.1.5 Digital Audio Outputs Standard Reference IEC 60958 IEC 61937 4.1.5.1 Coaxial & Optical Output Required to support up to bitrate of up to 96KHz SPDIF input. Description Specification Test Condition Output signal amplitude...
- Page 8 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities 4.2.2 Component Video (Y/Pb/Pr) Description Test Signal Specification Interlace/Progressive NTSC u t i e t i ± ± e t i e t i ± ± PbPr peak to peak 75% Color bar 525mV ±...
- Page 9 -1.5dB 20MHz -1.5dB 25MHz -1.5dB 30MHz -5dB FNAC Requirement MBD7020 is to attain 4 starts fnac rating. 4.5 Sound Requirement Reference MBD7020 Sound Requirement Specification [8] 4.6 FM Tuner Test conditions: Power Supply: AC According to Ver Ref Output :6 1W, sound effect off FM MONO:22.5KHz Dev, 1KHz Modulation , 75...
- Page 10 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities TEST ITEMS UNIT NOM. LIMIT 87.5 Frequency Range 90MHz 24~30 19~35 TUNING SENS 98MHz 24~30 19~35 106MHz 24~30 19~35 -3dB LIMITING POINT 26dB QUENTING SENSITIVITY FM IF REJEDION 98MHZ S/N=26dB IMAGE REJECT 98MHZ S/N=26dB 300kHz SELECTIVITYS...
- Page 11 All manuals and user guides at all-guides.com Technical Specification and Connection Facilities 4.7 HDMI Standard Reference High-Definition Multimedia Interface Specification version 1.3a High-Definition Multimedia Interface Compliance Test Specification version 1.4 4.7.1 Standard Reference: USB specification Revision 2.0,dated 27 April 2000 USB-IF USB 2.0 Electrical Test Specification Version1.03, dated January 2005 USB-IF Embedded Host Compliance Plan , Revision 1.0, dated August 2006 USB 1A requirement...
-
Page 12: Laser Beam Safety Precautions
All manuals and user guides at all-guides.com Laser Beam Safety Precautions This Blu-Ray player uses a pickup that emits a laser beam. Do not look directly at the laser beam coming from the pickup or allow it to strike against your skin. -
Page 13: Important Safety Precautions
Remove discs from the disc compartment and the wall mount. Koninklijke Philips if you are not using the product for an Electronics N.V. bears no responsibility extended period of time. - Page 14 All manuals and user guides at all-guides.com Important Safety Precautions Disposal of your old product and batteries Your product is designed and manufactured with high quality materials and components, which can be recycled and reused. When this crossed-out wheeled bin symbol is attached to a product it means that the product is covered by the European Directive 2002/96/EC.
-
Page 15: Safety Check After Servicing
All manuals and user guides at all-guides.com Safety Check after Servicing Examine the area surrounding the repaired location for damage or deterioration. Observe that screws, parts, and wires have been returned to their original positions. Afterwards, do the following tests and confirm the specified values to verify compliance with safety standards. -
Page 16: Safety Information General Notes & Lead Free Requirements
All manuals and user guides at all-guides.com Safety Information, General Notes & Lead Free Requirements Safety Instructions Warnings General Safety General Safety regulations require that during a repair: All ICs and many other semiconductors are susceptible to Connect the unit to the mains via an isolation transformer. electrostatic discharges (ESD, ). -
Page 17: Standard Notes For Servicing,Lead Free Requirements & Handling Flat Pack Ic
1. The output pin of the 3 pin Regulator ICs is When soldering, be sure to use the Pb free solder. indicated as shown. Information about lead-free soldering Top View Philips CE is producing lead-free sets from 1.1.2005 Bottom View onwards. Input IDENTIFICATION Regardless of special logo (not always 2. - Page 18 2004), containing leaded solder-alloy and components, all needed spare-parts will be available till the end of the service-period. For repair of such sets nothing changes. On our website www.atyourservice.ce.Philips.com you find more Fig. S-1-1 information to: BGA-de-/soldering (+ baking instructions) 2.
- Page 19 All manuals and user guides at all-guides.com Standard Notes for Servicing, Lead Free Requirements & Handling Flat Pack IC 3. The flat pack-IC on the CBA is affixed with glue, so 4. Release the flat pack-IC from the CBA using be careful not to break or damage the foil of each tweezers.
- Page 20 All manuals and user guides at all-guides.com Standard Notes for Servicing, Lead Free Requirements & Handling Flat Pack IC Instructions for Handling Semi- 2. Installation conductors 1. Using desoldering braid, remove the solder from the foil of each pin of the flat pack-IC on the CBA Electrostatic breakdown of the semi-conductors may so you can install a replacement flat pack-IC more occur due to a potential difference caused by...
-
Page 21: Direction Of Use
The following excerpt of the DFU/QSG serves as an introduction to the set. The Complete Direction for Use can be download in different languages from the internet site of Philips Customer care Center : www.support.philips.com IR sensor Overview of the main unit Detect signals from the remote control. - Page 22 All manuals and user guides at all-guides.com Direction of Use Remote Control LOUDNESS Turn on or off automatic loudness adjustment. Turn on this product or switch to Eco Power standby mode. PROGRAM When EasyLink is enabled,press Program radio stations. and hold for at least three seconds OPEN/CLOSE to turn all connected HDMI CEC Open or close the disc...
- Page 23 All manuals and user guides at all-guides.com Direction of Use 3 Connect Connect speakers Note Make the following connections to use this product. Insert the stripped portion of each speaker wire into the socket completely. For optimal sound,use the supplied speakers only. Connect only speakers with impedance that is the Preparations same or higher than the supplied speakers.
- Page 24 All manuals and user guides at all-guides.com Direction of Use Insert fully the silver end of the speaker Connect a composite video cable to: cableinto the black(-) connector. the VIDEOjack on this product. the VIDEO input jack on the TV. Screwthe black(-) connectorto secure the cable.
- Page 25 All manuals and user guides at all-guides.com Direction of Use Connect to a digital AV ampli er/ receiver LINEOUT COAXIAL LINE OUT AU X IN DIGITAL OUT LINE OUT AU X IN COAXIAL AUX IN Connecta coaxial c able(not supplied) to: the COAXIAL jack on this product.
- Page 26 LINE OUT AU X IN Note DOCK Internet access to Philips website for software update may not be allowed,depending on the router you use or the Internet Service Provider’s policy. Contact your Internet Service Provider for more information. Connect a dock(not supplied) to the Connect power DOCK socket on this unit.
-
Page 27: Cabinet Disassembly Instructions
All manuals and user guides at all-guides.com Cabinet Disassembly Instructions Note: 1. Disassembly Flowchart (1) Identification (location) No. of parts in the figures This flowchart indicates the disassembly steps to gain (2) Name of the part access to item(s) to be serviced. When reassembling, (3) Figure Number for reference follow the steps in reverse order. - Page 28 All manuals and user guides at all-guides.com Cabinet Disassembly Instructions A010 Fig. D3 Fig. D6 Fig. D4 Fig. D7 A011 A012 Fig. D5 Fig. D8...
-
Page 29: Troubleshooting
All manuals and user guides at all-guides.com Troubleshooting FLOW CHART NO.1 NO Power(The power cannot be turned on) Check the Power Cable connect is ok or not Check and Change the connect cable TEST CON4 “ECO”pin whether TEST Power supply voltage output CON4 each has high level signal plate is normal or not(+12V\DC5V\MCU\5V\P25V) Check the fuse which location F1... - Page 30 All manuals and user guides at all-guides.com Troubleshooting FLOW CHART NO.3 VFD no display Check VFD display board CN301 whether connection to decoder board CN1 is normal Check VFD display board CN401 whether Test whether VFD board CN401 pin 12#~13# between connection to KEYS board CN301 is normal has AC5V provide voltage Check the KEYS board location...
-
Page 31: Block Diagram
All manuals and user guides at all-guides.com Block Diagram CONTROL BY MCU WIFI DONGLE MODULE 5V 0.5A BRAND: ALPHA USB0 REAR WIFI DONGLE CONTROL BY BD TRV414H05 (Atheros AR9271) Model Number: WUS-N11 Power Switch TPS2553DBVT Collimator II TPC1391G4 ??K 1% resistor BD TRAVERSE Ethernet RJ45 A DDRIII X 1... -
Page 32: Wiring Diagram
All manuals and user guides at all-guides.com Wiring Diagram LINE OUT M-BOY DIN9 1.0/4P IPOD DET SGND 2.5/4P 2.0/4P AGND 2.0/8P 2.0/7P ACC_DET 4705 2.5/2P CS5346 PS9831 TAS5342 R5F21258 DRV604 2.0/4P 1.0/10P 2.5/9P 2.5/2P OPTICAL CVBS COAXIAL USB WIFI ready HDMI 2.0/5P 1.0/8P... - Page 33 All manuals and user guides at all-guides.com...
-
Page 34: Circuit Diagram
ECO_POWER R195 NC/NC/NC/100R MSCL 1N4148 R198 1K MSDA A_MUTE R197 MUTE MUTE_9831 R207 NC/NC/NC/100R R202 CE23 1N4148 MODEL MCU_MUTE 1N4148 MBD7020 DAB_MUTE ITEM 3.3V_MCU R179-0R 1N4148 3.3V_MCU A_MUTE MUTE_HP/LINE 3.3V_MCU U10 CX1117 -3.3 I+5V/2.1A R180-0R MCU_5V OUT1 R152 LED_PWM_V OL... -
Page 35: Layout Diagram
All manuals and user guides at all-guides.com AMP Board -- Layout Diagram 12-3 12-3... - Page 36 All manuals and user guides at all-guides.com...
- Page 37 All manuals and user guides at all-guides.com...
- Page 38 All manuals and user guides at all-guides.com...
- Page 39 All manuals and user guides at all-guides.com...
-
Page 40: Circuit Diagram
All manuals and user guides at all-guides.com Power Board -- Circuit Diagram 1 COLD +12V 102P 400V 22R 1206 3.3uH 5x7mm 1nF,200V Q5 B772 22R 1206 47R 1206 9.1K 1% 0805 ER28 3.3K 0805 100P 0805 103P/630V 33uF/35V 103P/1KV SB3100 3.3K 0805 62K/1W 100uF 25V... - Page 41 All manuals and user guides at all-guides.com Power Board -- Circuit Diagram 2 JMP5 GBL406 NTC,MF72,5D-11 T5AH250V T18*10*7,0.45*45Ts,20MH T18*10*7,0.45*45Ts,20MH JUMP 5mm 47uF/400V JMP1 NC CON4 10D471K T6.3AH250V 10D561K 47uF/400V JUMP 5mm 22uF/400V 14D561K HGND COLD 1K 0805 PC817 MMBT2222 33V 5% R58 1K 0805 100R 1206 1K 0805...
-
Page 42: Layout Diagram
All manuals and user guides at all-guides.com Power Board -- Layout Diagram 12-10 12-10... - Page 43 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 1 VCC_P FB4 BLM21P 12V_P VCC_P 0.1uF/10V BEAD/SMD/0805 CE307 0.1uF/10V 10uF/10V/X5R NC0805/SMD C0805/SMD P1_GND 100uF R12 10 VCC_1.1V 10uF/10V/X5R L0805B 1.1V 10uF/16V/X5R 10uF/10V/X5R 0.1uF/10V/X5R C0805/SMD 2.2uH/LQH6PPN2R2N43 C0805/SMD C0805/SMD FB904 R3 2.4K 1.1V_EN...
- Page 44 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 2 U100A MT8550-DDR3-BGA492-090924 1.5V A_DQ0 A_RA0 1.5V A_DQ7 A_RA1 A_DQ1 A_RA2 C142 C118 A_DQ6 A_RA3 0.01uF/6.3V/X5R 0.1uF/6.3V/X5R CE100 A_DQ3 A_RA4 AB20 DVCC18_IO_1 220uF/16V A_DQ5 A_RA5 AB21 DVCC18_IO_1 A_DQ0 A_DQ2 A_RA6 AC10...
- Page 45 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 3 U100B MT8550-DDR3-BGA492-090924 U203 1.1V IC DDR3 x16 FBGA-96 B_DQ0 B_RA0 1.1V B_DQ6 B_RA1 C207 C206 B_DQ3 B_RA2 CE205 0.01uF/6.3V/X5R B_DQ5 B_RA3 0.1uF/6.3V/X5R DVCC10_K 470uF/10V B_DQ1 B_RA4 DVCC10_K B_DQ0 B_DQ4 B_RA5...
- Page 46 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 4 U100C 3.3V 1.2V R343 AVDD33_VDACY AUDIO I2S AVDD12_HDMI R350 C304 AOSDATA5 C303 AOSDATA5 AOSDATA4 C300 C313 AOSDATA4 0.1uF/6.3V 10uF/6.3V/X5R 0.1uF/6.3V AOSDATA3 C0603/SMD AOSDATA3 AOSDATA2 AVDD33_VDACR AOMCLK_R C0805/SMD AOSDATA2 AVDD33_VDAC_R AOMCLK...
- Page 47 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 5 HW TRAPPING NFWEN NFWEN U100E 3.3V NFREN NFREN 3.3V NFCEN NFCEN 3.3V NFCEN2 NFCEN2 DVCC33_IO_6 DVCC33_IO R449 0 VDD3.3_USB AMUTE DVCC33_IO AVDD33_USB_1P U400 AMUTE (5,7,9) NFCLE DVCC33_IO_2 AVDD33_USB_2P NFCLE C402...
- Page 48 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 6 OPWRSB OPWRSB U100D 3.3V_STBY 3.3V RESET# RESET# 3.3V_STBY R522 GPIO8 TP516 VCC3IO_STB HW TRAPPING LCDRD DVCC33_IO_STB ETCOL TP513 ETTXEN R509 0 TP515 DVCC33_IO_STB ETCRS ETMDC TP514 NFWEN NFWEN TP512 NFWEN...
- Page 49 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 7 R611 CVBS R0603/SMD C604 C605 R604 D601 47pF/6.3V 75_1% 47pF/6.3V/NC DIODE SMD BAV99 SOT23/SMD ASPDIF ASPDIF 0.1uF/6.3V AUDIO CNT R602 C606 COAXOUT DAC_RST# R601 C611 DAC_RST# PCM_DSD# FB912 FB601/0.5A PCM_DSD# 33pF/6.3V...
- Page 50 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 8 HA800 3.3V CON801 FOC2+ FCS2+ FOC2- URXD FCS2- UTXD U100F TRK+ FOC1+ C942 C941 AGND FCS1+ MT8550-DDR3-BGA492-090924 AGND TRK- MOTOR DRIVER FOC1- MT8550/BGA492/P0.8/B0.4/21X21 FCS1- 4x1 W/HOUSING A1.2V CO_A- DIP4/W/H/P2.0 GAINSW2...
- Page 51 All manuals and user guides at all-guides.com Decoder Board -- Circuit Diagram 9 MOTOR DRIVER GAINSW2 GAINSW2 (10) MUTE2 MUTE2 (10) MUTE1 MUTE1 (10) TRAYPWM TRAYPWM (10) DMSO DMSO (10) U900 FOSO FOSO (10) R2A30209SP-W02Z TRSO TRSO (10) SSOP42/SMD TLSO TLSO (10) DMSO...
- Page 52 All manuals and user guides at all-guides.com Decoder Board -- Layout Diagram 12-20 12-20...
-
Page 53: Exploded View
All manuals and user guides at all-guides.com Exploded View Screw Screw PCB6 PCB7 Back Plate FAN1 Screw PCB8 BRDVD Aluminium Plate 114 Screw PCB1 13-1 13-1... -
Page 54: Revision List
All manuals and user guides at all-guides.com Revision List Revision List Version 1.0 * Initial Release 14-1... - Page 55 All manuals and user guides at all-guides.com MBD7020 stroke version /93(China) repair policy MLR+CLR Level Pos. No. 12Nc Description Safety PCM Code Mechanical Partlist 996510043829 VOLUME KNOB 03-MBD7020-01A101 996510043814 BRDVD BL-RAY LOADER MECHANISM 31000296 PCB8 996510043822 POWER BOARD NEP3200B-12/93 RN...
- Page 56 All manuals and user guides at all-guides.com VFD401 996510042474 DISPLAY VFD VFD27-1201N 27WX118LX6.5 29000529 HEADPHONE/MP3 LINK BOARD Partlist PCB3 996510043826 HEADPHONE/MP3 LINK BOARD ASSY 07-MBD7020-05A101 J501 994000004967 AUX IN JACK CK3511 24000120 J502 994000004966 HEADPHONE JACK D3.5 24000177 USB BOARD Partlist...
- Page 57 2U901 996510043837 IC TI TPC1391G 1900089 2U1996510043824 IC AP1122(TO- 1900095 2U409 996510042461 IC TPS2553 SO 1900099 All manuals and user guides at all-guides.com 2U410 996510042461 IC TPS2553 SO 1900099 2U11 996510043832 IC CEM9435 PM 1900102 2U2996510043815 IC G5627 (SOP 1900101 2U4996510043815 IC G5627 (SOP 1900101...