SIMS GRASEBY MR10 Technical & Service Manual

SIMS GRASEBY MR10 Technical & Service Manual

Neonatal respiration monitor

Advertisement

Quick Links

G r a s e b y M R 1 0
N e o n a t a l
R e s p i r a t i o n
M o n i t o r
Te c h n i c a l S e r v i c e
M a n u a l
0473

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the MR10 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for SIMS GRASEBY MR10

  • Page 1 G r a s e b y M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Te c h n i c a l S e r v i c e M a n u a l 0473...
  • Page 2 WARNING: Mobile communication devices e.g. mobile phones, should not be used at a distance of less than one metre to the MR10 Monitor, as this could affect the safe operation of the Monitor. Even if these devices cause no obvious interference, possible interference can only be ruled out if this advice is strictly observed.
  • Page 3 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Cautions Cautions tell you about dangerous conditions that can occur and cause damage to the Monitor if you do not obey all of the instructions in this...
  • Page 4 S I M S G r a s e b y L t d . © SIMS Graseby Limited 2001 Trademarks and acknowledgements: M R 1 0 Te c h n i c a l S e r v i c e M a n u a l...
  • Page 5 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r SIMS Graseby Ltd. l i r Page ii I s s u e A ( A p r i l 2 0 0 1 )
  • Page 6: Table Of Contents

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Contents Chapter 1 Introduction ...................
  • Page 7 Replacing the front panel keypad membrane ........ 4 - 4 Chapter 5 Illustrated Parts List ................5 - 1 General assembly of the MR10 new case design (serial numbers from 80,000) ............. 5 - 2 General assembly of the MR10 old case design (for serial numbers below 80,000) ............
  • Page 8 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Abbreviations Abbrev.
  • Page 9 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r SIMS Graseby Ltd. Page vi I s s u e A ( A p r i l 2 0 0 1 )
  • Page 10: Introduction

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Chapter 1 Introduction ON 10 sec...
  • Page 11 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Figure 1-1 MR10 old case design (for serial numbers from 30,000 to 80,000) Figure 1-2 MR10 new case design (for serial numbers from 80,000) 1 —...
  • Page 12: Specification

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Specification Dimensions: below...
  • Page 13: Batteries

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Batteries: Low battery indicator External sensor:...
  • Page 14: Standards

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Standards Electrical Safety Design Standards...
  • Page 15 S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r 1 —...
  • Page 16: Introduction

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Chapter 2 Introduction DIGITAL SIGNAL PROCESSOR...
  • Page 17: Circuit Description

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Circuit Description Master Clock Transducer oscillator...
  • Page 18 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Figure 2.2 Circuit diagram M R 1 0 Te c h n i c a l S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 1 )
  • Page 19 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . 2 —...
  • Page 20: Acceptance And Routine Tests

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Chapter 3 Acceptance and Routine Tests ON 10 SEC...
  • Page 21 S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r 3 —...
  • Page 22: Cleaning And Maintenance

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Chapter 4 Cleaning and Maintenance Cleaning...
  • Page 23: Battery Replacement

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Battery replacement Old case design (models with serial number below 80,000) New case design (models with serial number above 80,000)
  • Page 24: Disassembly Of The Monitor

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Disassembly of the monitor Replacing the batteries Old case design (models with serial number below 80,000)
  • Page 25: Sensitivity Setting

    S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Sensitivity setting Replacing the front panel keypad membrane Disassembly of the monitor.
  • Page 26: Illustrated Parts List

    S I M S G r a s e b y L t d . Chapter 5 Illustrated Parts List When ordering spare parts for the MR10 please check that the parts you ordering are for the correct MR10 design assembly list. for Old case design serial numbers below 80,000 see page 5-4...
  • Page 27: General Assembly Of The Mr10 New Case Design (Serial Numbers From 80,000)

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r General assembly of the MR10 new case design (serial numbers from 80,000) Item No.
  • Page 28 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Figure 5-1A General assembly of the MR10 new case design (for serial numbers from 80,000)
  • Page 29: General Assembly Of The Mr10 Old Case Design (For Serial Numbers Below 80,000)

    M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r General assembly of the MR10 old case design (for serial numbers below 80,000) Item No.
  • Page 30 M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r S I M S G r a s e b y L t d . Figure 5-1B General assembly of the MR10 old case design (for serial below 80,000)
  • Page 31 S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r Item No.
  • Page 32 LED2 LED3 0 0 0 GM1182-A Figure 2 A MR10 PCB layout serial numbers below 80,000 Figure 2 B MR10 PCB layout New case design serial numbers from 80,000 M R 1 0 Te c h n i c a l S e r v i c e M a n u a l I s s u e A ( A p r i l 2 0 0 1 ) 5 —...
  • Page 33 S I M S G r a s e b y L t d . M R 1 0 N e o n a t a l R e s p i r a t i o n M o n i t o r M R 1 0 Te c h n i c a l S e r v i c e M a n u a l 5 —...
  • Page 34 SIMS Graseby Limited Colonial Way, Watford, Herts , UK, WD24 4LG Tel: (+44) (0)1923 246434 Fax: (+44) (0)1923 231595 www.graseby.co.uk Part No. 0514-0045 Issue A April 2001 © SIMS Graseby Ltd. 2001...

Table of Contents