Page 1
Installation, Use & Care Manual This manual is updated as new information and models are released. Visit our website for the latest manual. www.manitowocice.com This manual contains English and French text America’s #1 Selling Ice Machine Part Number 000006529 10/09...
Anchor flanged feet to floor as instructed on page 4 • Only use paddle provided to assist ice flow • Only use cart to transport ice and reinstall carefully in bin bay when not in use Part Number 000006529 10/09...
2. Reposition tie-down strap up until slot matches rivnut opening. 4. Install bin section on base section, taking care that locating pins in base engage holes in bin. 3. Reinstall screws in rivnuts and tighten. Part Number 000006529 10/09...
4. After sealant has set but before shutter door(s) have been reinstalled, clean inside of bin following instructions in this manual. 5. Reinstall shutter door(s). EXTERIOR INTERIOR SECTION BASE COMPLETELY SECTION SEAL GASKET Cross Section of Ice Transfer System Sections Joined Part Number 000006529 10/09...
5. On other side, insert screwdriver between door and hinge bracket and gently push against bracket to provide room for door stud to clear bracket. 6. Reinstall washers and screws in lift door and tighten. 7. Check door to ensure proper operation. Part Number 000006529 10/09...
PULLING CART OUT 1. PUSH cart all the way to back. 1. PUSH shutter handle closed. 2. PULL cart drain open. 2. PUSH cart drain closed. 3. Lock brake on caster DOWN. 3. Release brake on caster. Part Number 000006529 10/09...
This often happens if ice has been held in storage for a period of time without use. Use supplied paddle accessory to break up bridges. Part Number 000006529 10/09...
The ice storage bin is equipped with polyethylene liner areas. walls which must be cleaned and sanitized every six 7. Remove the following bin components for cleaning months with Manitowoc Ice Machine Cleaner and and sanitizing. Sanitizer. • Shutter Door 1.
REMOVE THUMBSCREWS AND BOTH UPPER DRAIN TRAYS REMOVE AND CLEAN/SANITIZE DRAIN LINES CLEAN AND SANITIZE SHUTTER RAILS BEFORE REINSTALLING SHUTTER REMOVE THUMBSCREWS AND BOTH SHUTTERS Part Number 000006529 10/09...
Ice spills when filling cart Ice guides incorrectly adjusted Refer to Section 2 and adjust ice guides Water in bottom of cart Drain closed Refer to Section 3, Operation Drain obstructed Clear drain Part Number 000006529 10/09...
Model Number and Serial Number price paid by purchaser for the Ice Storage Bin or Dispenser. Installation Date • All warranty service must be preformed by an approved Manitowoc EXCLUSIONS FROM COVERAGE contracted or authorized Service Representative. To schedule a service •...
Page 13
Site Web : www.manitowocice.com ........Part Number 000006529 10/09...
Page 14
• Utiliser uniquement la palette fournie pour faciliter le débit de glaçons • Utiliser le chariot uniquement pour transporter les glaçons et le remettre soigneusement en place dans le compartiment du bac lorsqu’il n’est pas utilisé Part Number 000006529 10/09...
2. Retirer tout l’emballage de protection de l’extérieur. 3. Remonter les vis dans les écrous à river et serrer. 3. Appliquer un cordon de 1/8" de Silastic fourni au centre de chaque bande de joint sur la base. Part Number 000006529 10/09...
NOTE: Le support adhésif est extrêmement solide et les étiquettes ne pourront pas facilement être enlevées une SECTION DE fois apposées. EXTÉRIEUR IINTÉRIEUR SCELLER SECTION DE COMPLÈTEMENT BASE LE JOINT Coupe transversale des sections jointes du système de transfert de glaçons Part Number 000006529 10/09...
6. Remonter les rondelles et les vis dans la porte relevable et serrer. 7. Vérifier la porte pour assurer un bon fonctionnement. Part Number 000006529 10/09...
2. FERMER l’évacuation du chariot. 3. Relâcher le frein sur la roulette. MISE DU CHARIOT DANS LE COMPARTIMENT 1. ENFONCER le chariot complètement au fond. 2. OUVRIR l’évacuation du chariot. 3. Verrouiller le frein sur la roulette vers le BAS. Part Number 000006529 10/09...
Ceci est courant si les glaçons ont été stockés pendant une période prolongée sans être utilisés. Utiliser l’accessoire palette fournie pour séparer les ponts. Part Number 000006529 10/09...
(le cas échéant) et bien rincer 000000084) et Désinfectant Manitowoc (94-0565-3) toutes les zones à l’eau claire. pour machines à glaçons approuvés par Manitowoc pour cette application. NE PAS utiliser de nettoyants Important à base de chlore qui peuvent provoquer une...
RETIRER LES VIS À OREILLES ET LES DEUX PLATEAUX SUPÉRIEURS D’ÉVACUATION RETIRER ET NETTOYER/DÉSINFECTER LES CONDUITES D’ÉVACUATION NETTOYER ET DÉSINFECTER LES GLISSIÈRES DU VOLET AVANT DE REMONTER LE VOLET RETIRER LES VIS À OREILLES ET LES DEUX VOLETS Part Number 000006529 10/09...
Guides de glaçons mal ajustés Consulter la section 2 et ajuster les guides de remplissage du chariot glaçons Présence d’eau dans le fond du Évacuation fermée Se reporter à la section 3, Fonctionnement chariot Évacuation obstruée Dégager l’évacuation Part Number 000006529 10/09...
• Tout service au titre de la garantie doit être effectué par un représentant mauvaise utilisation, d’un entretien ou d’un entreposage inadéquat, de du service technique sous contrat ou autorisé homologué de Manitowoc. négligence, d’altération, d’utilisation de fournitures incompatibles ou du Pour prendre rendez-vous pour tout service, contacter le représentant du...
Need help?
Do you have a question about the 000006529 and is the answer not in the manual?
Questions and answers
i have a table top ice maker, model # SL1MO1B SERIAL NUMBER 231001706 LOOKING FOR CARE & MAINT. INFO