Related Manuals for Trox Technik TAP-L
Summary of Contents for Trox Technik TAP-L
- Page 1 Operating instructions GB/en TROX AIR PURIFIERS TAP-L TAP-M Read the instructions prior to performing any task!
- Page 2 TROX GmbH Heinrich-Trox-Platz 47504 Neukirchen-Vluyn, Germany Germany Phone: +49 (0) 2845 2020 Fax: +49 2845 202-265 E-mail: trox-de@troxgroup.com Internet: http://www.troxtechnik.com A00000083746, 3, GB/en 10/2020 © 2020 TROX AIR PURIFIERS TAP-L TAP-M...
- Page 3 This applies in particular to: Publishing content Copying content Translating content Microcopying content Saving content to electronic systems and editing it TROX AIR PURIFIERS TAP-L TAP-M...
- Page 4 Specific safety notes The following symbols are used in safety notes to alert you to specific hazards: Warning signs Type of danger Warning – hand injuries. Warning – high-voltage. Warning – danger zone. TROX AIR PURIFIERS TAP-L TAP-M...
-
Page 5: Table Of Contents
7.1 Check and change filter ......19 7.2 Cleaning and disinfection ......Technical data ..........21 8.1 Circuit diagram ........Disposal ............23 Declaration of conformity ......24 Commissioning report/Maintenance report ................25 Index..............26 TROX AIR PURIFIERS TAP-L TAP-M... -
Page 6: Safety
Use of non-genuine replacement parts or acces- – During installation, observe the minimum dis- sories, whose quality and function are not equiv- tances from walls and objects and the operating alent to those of the original parts conditions. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 7: Qualified Staff
Dust mask FFP2 Dust masks protect users from inhaling contaminated material such as aerosols and harmful dusts. Safety shoes Safety shoes protect the feet against crushing, falling parts, and from slipping on slippery ground. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 8: Residual Risks
This sticker indicates that the operating manual must be read and understood before any work is performed on the air purifier. It is located inside the unit, behind the door and above the filters. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 9: Behaviour In An Emergency
Remove the mains plug from the mains socket. ð Do not reconnect a defective unit to the mains supply. Have the unit repaired by the manufac- turer or a qualified specialist company. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 10: Information About The Unit
The air purifier is supplied in two construction variants (L and M), which differ in size (unit depth), weight, air- flow, sound power and filter size, Ä 8 ‘Technical data’ on page 21 . TROX AIR PURIFIERS TAP-L TAP-M... - Page 11 By the filtering and high air change rates, the air purifier considerably reduces the amount of germs, viruses and bacteria (depending on the room size) and thus also cuts the risk of infection. TROX AIR PURIFIERS TAP-L TAP-M...
-
Page 12: Transport, Storage And Packaging
Fig. 7: Transport by trolley – Use only lifting and transport gear designed for the required load. – When setting the unit upright, secure it against shifting and tipping over until installation is com- plete. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 13: Bearing
3.4 Packaging Packaging materials: Wood Cardboard Foil packaging Expanded polystyrene ENVIRONMENT! Handling packaging materials Properly dispose of packaging material! TROX AIR PURIFIERS TAP-L TAP-M... -
Page 14: Installation
Dimensions and space required Installation 4.1 Dimensions and space required Dimensions Fig. 8: Unit dimensions TAP-L and TAP-M ① Door opening dimension (hinge left) ② Fixing brackets (wall distance) Space required Fig. 9: Setup: against a wall or in a corner Distance from ceiling (d) at least 100 –... -
Page 15: Mounting
Fig. 10: Securing of the fixing bracket on the wall necessary that the mains socket is close to the unit and easily accessible. Secure the bracket to the wall with suitable fixing mate- rial (screws and wallplugs) (slotted holes 7 mm). TROX AIR PURIFIERS TAP-L TAP-M... -
Page 16: Software Use
5.4 Switching the unit off Use the mains isolator to switch off the unit ( Fig. 12 /1). ð If necessary, pull out the mains plug, e.g. during maintenance work or longer interrup- tions in operation. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 17: Operation On A Timer
Use the [▼] or [▲] key to set the desired value Ä Chapter 8 ‘Technical data’ on page 21 . The set- [m³/h], setting range TAP-L: 400...1600 m³/h, TAP- tings of the unit are retained even when the supply M: 200...1200 m³/h. -
Page 18: Troubleshooting
Fan or bearing defec- Switch off unit and notify customer service tive If you are unable to rectify the fault yourself: Contact the TROX customer service (see page 3) or a qualified electrician. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 19: Maintenance And Cleaning
Check the filter chambers for contamination 5.2 ‘Starting’ on page 16 . and clean them with a damp cloth if neces- sary. ð Replace the prefilter if required, or according to the specified change intervals. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 20: Cleaning And Disinfection
Ä Chapter 5.4 ‘Switching the Switch the unit off, unit off’ on page 16 Disconnect the mains plug! Remove the mains plug from the socket. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 21: Technical Data
LwA dB(A) dB(A) 1000 1200 1400 1600 Sound pressure LpA with room attenuation 8 dB Construction M Air flow rate [m³/h] LwA dB(A) dB(A) 1000 1200 Sound pressure LpA with room attenuation 8 dB TROX AIR PURIFIERS TAP-L TAP-M... -
Page 22: Circuit Diagram
Technical data Circuit diagram 8.1 Circuit diagram Fig. 14: Circuit diagram TROX AIR PURIFIERS TAP-L TAP-M... -
Page 23: Disposal
As electrical and electronic components may also contain recyclables (e. g. precious metals), they must be provided for recycling or disposal by a specialist disposal company. TROX AIR PURIFIERS TAP-L TAP-M... -
Page 24: Declaration Of Conformity
Declaration of conformity Declaration of conformity TROX AIR PURIFIERS TAP-L TAP-M... -
Page 25: Commissioning Report/Maintenance Report
Changing HEPA filter ☐ ☐ Checking the function of the air purifier (fan): Comment: Next maintenance See note on maintenance intervals, scheduled for: Ä ‘Maintenance measures’ on page 19 . Signature: (Technician) Company: (Stamp) TROX AIR PURIFIERS TAP-L TAP-M... -
Page 26: Index
Switching on............16 switch off.............. 16 Incorrect use............... Unit description............Installation location............ 14 Volume flow rate Labelling..............7 Setting..............17 Limitation of liability............. 3 Warranty claims............3 Mains connection............15 Wiring................ 22 Maintenance.............. 19 TROX AIR PURIFIERS TAP-L TAP-M... - Page 27 TROX AIR PURIFIERS TAP-L TAP-M...
- Page 28 Germany TROX GmbH Phone: +49 (0) 2845 2020 Heinrich-Trox-Platz +49 2845 202-265 47504 Neukirchen-Vluyn, Ger- E-mail: trox-de@troxgroup.com © 2020 many http://www.troxtechnik.com...
Need help?
Do you have a question about the TAP-L and is the answer not in the manual?
Questions and answers