Related Manuals for CARVIN 973224 Series
Summary of Contents for CARVIN 973224 Series
- Page 1 OVAL GOLD SERIES User Manual for Above-Ground Pool CARVIN POOL EQUIPMENT | 4000 boul. Casavant Ouest, Saint-Hyacinthe, Québec, Canada, J2S 9E3 ® M22905003 EN| © 2021 Le Groupe VIF Inc. All rights reserved.
-
Page 2: Table Of Contents
This manual contains information on how to do that; please read it carefully Safety recommendations before operating the chlorine generator. If a problem should arise, or if you have any Pool safety label questions about your product, consult an authorized CARVIN retailer or distributor. ® Pool liner size... -
Page 3: Warning
NO DIVING - NO JUMPING Le Groupe VIF Inc . SHALLOW WATER CARVIN POOL EQUIPMENT ÉQUIPEMENT DE PISCINE CARVIN 4000 boul. Casavant Ouest NE PAS PLONGER OU SAUTER APSP-4 • Restrict access to the pool by making sure the ladder is removed, locked or Saint-Hyacinthe, Québec, Canada, J2S 9E... -
Page 4: Installation
Be aware that STEP 1 Through STEP 3 will be more time If a part is missing or defective, please contact your CARVIN retailer were your consuming and labor intensive than the rest of the steps, ®... -
Page 5: Ground Leveling
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL GROUND LEVELING 3′10″ 12x15 (117) 2′2″ 2′5″ (74) After the site is properly marked, remove the sod in the installation surface area. (67) 10′ (25) Equal trench width You will need to remove any tree stumps growing in the installation area. -
Page 6: Unpacking The Pool Parts
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL 15x21 18x39 6′10″ 15′11″ 3′11″ (120) (209) 2′2″ (67) (485) 2′5″ (74) 2′2″ (67) Equal 10′ (25) 2′7″ (78) Equal 2′7″ (78) 10′ (25) Equal trench width Equal trench width 6′6″ (198) 5′0″... -
Page 7: Laying The Buttrests Inside The Trenches
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL ASSEMBLING PRESSURE PLATES STEP 2 Insert the sleeve (46025010) into the footbeam channel and then insert a ½ bolt Assemble Pressure Plates (46025003) to the assembled footbeams with 4x screw (14455035) with washer (91922A308) and then put a washer on the other side and... -
Page 8: Squaring Out The Straight Section
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL SQUARING OUT THE STRAIGHT SECTION 18’ POOL 915.46 36.042 This step is one very important. See Squaring Diagram Measurement. The Buttrests TYPICAL on each side must be aligned in respect to one to another. The posts assembly must be sitting in the middle of the patio block. -
Page 9: Assemble The Round Section Rails
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL ADD DRILL STEP 2 STEP 5 When assembled, screw in all foots in foot beam hole with screw. Add dust stone inside the pool before unrolling the wall. Refer to page 2 sand required. -
Page 10: Basin Assembly
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL STEP 5 STEP 3 We suggest you install the top rails gradually as the wall is unrolled to give more When the assembly holes of the wall are aligned, you will be able to join them stability to the metal sheet. -
Page 11: The Sand Bed
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL STEP 5 STEP 2 Once the wall is assembled, make additional checks to make sure the pool round Once the plastic sheet in place, from the sand/stone dust previously placed inside sections are perfectly round. -
Page 12: Installing The Geotextile Liner
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL INSTALLING THE GEOTEXTILE LINER LINER INSTALLATION There are already cut to pool size geotextiles liners sold at your pool stores. Those The liner dimensions are usually a bit smaller than the pool frame. It is recom- are thick and durable. -
Page 13: Fastening The Liner On To The Pool Wall
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL FASTENING THE LINER ON TO THE POOL WALL FOR ASSEMBLY WITH A U/J TYPE POOL LINER STEP 1 STEP 3 As you install and hang the overlap liner, assemble the top rails to solidify the pool. -
Page 14: Installing The Top Plates - Straight Sections
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL INSTALLING THE TOP PLATES - STRAIGHT SECTIONS STEP 2 Insert the top plate screwing detail inside the buttress post make sure that the rail is inside the rear plate channel. Before screwing make sure that the plate is sitting flat Line up the post cover top holes with the top plate inward holes set (For gold series on the post. -
Page 15: Top Ledge Cover Installation
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL STEP 3 STEP 2 Before screwing top ledges, pull them towards the exterior of the pool so that the Insert the rear part of the top ledge covers (hook) under top ledge and turn the top corners on the interior of the pool are pressed and flush against top plates. -
Page 16: Locking The Foots In Round Section
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL STEP 5 STEP 2 Install the top ledge cover cap by inserting one snap into cavity and push the other Close skimmer opening on the outside of the pool wall with cardboard and duct tape into place until it clicks. -
Page 17: Inspection
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL STEP 5 When water reaches 4” (10 cm) deep, turn off the vacuum and remove the vacuum hose. Skimmer Skimmer Water return outlet Water return outlet Remove the hose 2’’ 4’’... -
Page 18: Water Chemistry
The hole under the skimmer must stay opened ppm = part-per-million, ppb = part per billion Keep the skimmer on the pool. Do not let water accumulate in it. Make sure the This pool series is compatible with Carvin Ollo™ Salt Chlorine Generator; consult the owner’s ®... -
Page 19: Use Of A Winter Cover
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL USE OF A WINTER COVER STEP 1 For the use of a winter cover, we recommend you ask your local dealer for information. Since many types of winter covers are available, your dealer can advise you on the best installation for your pool. -
Page 20: Remplacement Parts
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL REMPLACEMENT PARTS Use the original CARVIN replacement parts only. ® Part number Description 46025008 - Oval pool foot beams sheet metal Oval pool foot beam sheet metal 16025009 - Oval pool buttress post sheet metal - gauge 14... - Page 21 CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL REMPLACEMENT PARTS Use the original CARVIN replacement parts only. ®...
- Page 22 CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL REMPLACEMENT PARTS Use the original CARVIN replacement parts only. ® STRAIGHT SECTION GOLD SERIES PLASTIC PART ASSEMBLY DETAIL DETAIL J DETAIL I DETAIL G...
-
Page 23: Parts Table
CARVIN ® GOLD SERIES OVAL POOL | USER MANUAL REMPLACEMENT PARTS Use the original CARVIN replacement parts only. ® PART CODE DESCRIPTION 12x15 12x18 12x21 12x24 15x21 15x24 15x30 18x33 18x39 52’’ PGU52 UPRIGHT GOLD SERIES TOP SEAT GOLD SERIES... -
Page 24: Consumer Information
After following the troubleshooting section of this manual and after contacting your or workmanship, for the Warranty period set below, under normal use and main- dealer or distributor, if you have any problems with your Product, contact CARVIN ® tenance. If any defects should be found in a Product within the period set below Technical Support.
Need help?
Do you have a question about the 973224 Series and is the answer not in the manual?
Questions and answers