Repair Parts List; Electrical Parts List - Sony DEV-30 Service Manual

(ENGLISH)
NOTE:
• -XX, -X mean standardized parts, so they may have some dif-
ferences from the original one.
• Items marked "*" are not stocked since they are seldom required
for routine service. Some delay should be anticipated when
ordering these items.
• The mechanical parts with no reference number in the exploded
views are not supplied.
• Due to standardization, replacements in the parts list may be
different from the parts specified in the diagrams or the com-
ponents used on the set.
• CAPACITORS:
uF: μF
• COILS
uH: μH
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
• SEMICONDUCTORS
In each case, u: μ, for example:
uA...: μA... , uPA... , μPA... ,
uPB... , μPB... , μPC... , μPC... ,
uPD..., μPD...
When indicating parts by reference
number,please include the board name.
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
0 sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
Caution
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Dispose of used batteries according to the instructions.
Note 1: Be sure to read "Precautions for Replacement of Imager"
on page 6-1 when changing the Imager.
Note 2: Replace the battery holder (BH8001) together when
replacing the lithium storage battery (BT8001) on the MS-
1012 board.
(The battery holder removed once cannot be usedagain.)
When mounting these parts, mount new battery holder
first and attach new lithium storage battery next.
DEV-30/50/50V_L3

2. REPAIR PARTS LIST

KY-1005 JY-1001 ZM-1001 CM-123
(JAPANESE)
【使用上の注意】
• ここに記載されている部品は, 補修用部品であるため, 回路図
及びセットに付いている部品と異なる場合があります。
• -XX, -Xは標準化部品のため, セットに付いている部品と異な
る場合があります。
• *印の部品は常備在庫しておりません。
• コンデンサの単位でuFはμFを示します。
• 抵抗の単位Ωは省略してあります。
金 被：金属被膜抵抗。
サンキン：酸化金属被膜抵抗。
• インダクタの単位でuHはμHを示します。
• 半導体の名称でuA..., uPA..., uPB..., uPC..., uPD...等はそれぞれ
μA..., μPA..., μPB..., μPC..., μPD...を示します。
お願い
図面番号で部品を指定するときは基板名
又はブロックを併せて指定してください。
0印の部品，または0印付の点線で囲ま
れた部品は，安全性を維持するために，
重要な部品です。
従って交換時は，必ず指定の部品を使用
してください。
注意
電池の交換は、正しく行わないと破裂する恐れがあります。
電池を交換する場合には必ず同じ型名の電池又は同等品と交換し
てください。
使用済み電池は、取扱指示に従って処分してください。
Note 1: イメージャの交換時は，6-1ページの"イメージャ交換時の
注意"を必ずお読みください。
Note 2: MS-1012基板のリチウム蓄電池 (BT8001) を交換する
場合はバッテリホルダ (BH8001) も同時に新品に交換し
てください。
(一度使用したバッテリホルダは再使用できません。 )
部品取り付けの際は、先にバッテリホルダを取り付けて
からリチウム蓄電池を装着してください。
FP-2134 FP-2135 FP-2137 FP-2138

2-2. ELECTRICAL PARTS LIST

Ref. No. Part No. Description
A-1945-867-A CABINET (TOP) BLOCK ASSY
(Not supplied) KY-1005 BOARD, COMPLETE
(Not supplied) JY-1001 BOARD, COMPLETE
(Not supplied) ZM-1001 BOARD, COMPLETE
***********************
(All mounted parts, KY-1005 COMPLETE BOARD, JY-1001 COMPLETE BOARD and
ZM-1001 COMPLETE BOARD are not supplied, but they are included in CABINET
(TOP) BLOCK ASSY.)
A-1851-196-A CM-123 BOARD, COMPLETE (MAIN)
A-1851-196-A CM-123 BOARD, COMPLETE (SUB)
****************************
(All mount parts are not supplied, but they are included in CM-123 COMPLETE BOARD
(MAIN/SUB).)
1-887-911-11 FP-2134 FLEXIBLE BOARD
*********************
1-887-912-11 FP-2135 FLEXIBLE BOARD
*********************
1-887-914-11 FP-2137 FLEXIBLE BOARD (MAIN)
1-887-914-11 FP-2137 FLEXIBLE BOARD (SUB)
*********************
1-887-915-11 FP-2138 FLEXIBLE BOARD
*********************
1-887-918-11 FP-2141 FLEXIBLE BOARD
*********************
1-887-982-11 FP-2147 FLEXIBLE BOARD
*********************
A-1938-584-A GP405 ASSY
(Not supplied) GP-1009 BOARD, COMPLETE
***********************
(All mounted parts and GP-1009 COMPLETE BOARD are not supplied, but they are
included in GP405 ASSY.)
A-1949-930-A JKR BLOCK ASSY
(Not supplied) JK-1005 BOARD, COMPLETE
***********************
(All mounted parts and JK-1005 COMPLETE BOARD are not supplied, but they are
included in JKR BLOCK ASSY.)
2-1
FP-2141 FP-2147 GP-1009 JK-1005
Ref. No. Part No.
A-1945-742-A
(IC7701 and SE7701 are not supplied, but they are included in LD-1009 COMPLETE
BOARD.)
C7701 1-118-417-11
C7702 1-114-411-21
C7703 1-118-417-11
C7704 1-116-713-11
* C7705 1-118-407-11
C7706 1-118-388-11
C7707 1-118-388-11
C7708 1-118-417-11
C7709 1-118-417-11
CN5001 1-842-897-11
* CN5002 1-821-503-11
CN5003 1-816-654-61
IC7701 (Not supplied)
* R7701 1-250-523-11
R7702 1-218-979-11
R7703 1-218-965-11
R7704 1-218-969-11
R7705 1-218-969-11
SE7701 (Not supplied)
A-1945-753-A
CN5101 1-842-897-11
* CN5102 1-821-503-11
CN5104 1-778-506-21
A-1945-991-A
(BT8001 is not included in MS-1012 COMPLETE BOARD (SERVICE).)
BT8001 1-756-134-15
BH8001 1-251-928-21
C7501 1-118-417-11
C7502 1-118-417-11
C7503 1-118-417-11
LD-1009 LD-1010 MS-1012
Description
LD-1009 BOARD, COMPLETE
***********************
< CAPACITOR >
CERAMIC CHIP 0.1uF 10% 16V
CERAMIC CHIP 0.33uF 10% 6.3V
CERAMIC CHIP 0.1uF 10% 16V
CERAMIC CHIP 22uF 20% 10V
CERAMIC CHIP 470PF 10% 50V
CERAMIC CHIP 0.047uF 10% 25V
CERAMIC CHIP 0.047uF 10% 25V
CERAMIC CHIP 0.1uF 10% 16V
CERAMIC CHIP 0.1uF 10% 16V
< CONNECTOR >
CONNECTOR, FPC (ZIF) 45P
CONNECTOR, FPC (ZIF) 39P
FFC/FPC CONNECTOR (LIF) 6P
< IC >
IC NJM3232MG2 (TE2)
< RESISTOR >
METAL CHIP 15K 1% 1/16W
METAL CHIP 150K 5% 1/16W
METAL CHIP 10K 5% 1/16W
METAL CHIP 22K 5% 1/16W
METAL CHIP 22K 5% 1/16W
< SENSOR >
SENSOR, ANGULAR VELOCITY
LD-1010 BOARD, COMPLETE
***********************
< CONNECTOR >
CONNECTOR, FPC (ZIF) 45P
CONNECTOR, FPC (ZIF) 39P
PIN, CONNECTOR (PC BOARD) 2P
MS-1012 BOARD, COMPLETE (SERVICE)
********************************
< BATTERY>
BATTERY, LITHIUM (SECONDARY)
< BATTERY HOLDER >
SOCKET, BATTERY
< CAPACITOR >
CERAMIC CHIP 0.1uF 10% 16V
CERAMIC CHIP 0.1uF 10% 16V
CERAMIC CHIP 0.1uF 10% 16V