Related Manuals for BTCPower L3R-50-208-01-003
Summary of Contents for BTCPower L3R-50-208-01-003
- Page 1 50 kW DC Fast Charger INSTALLATION AND USER’S MANUAL BTCPOWER, INC. 1719 S. GRAND AVE. SANTA ANA, CA 92705 WWW.BTCPOWER.COM...
- Page 2 This document contains useful general information about the product and its installation. BTCPower, Inc. reserves the right to make changes to this product without further notice. No part of this document may be reproduced in any form or by any means, electronic or mechanical, including photocopying, without written permission of BTCPower, Inc.
-
Page 3: Table Of Contents
5.3. Time Outs ..........................22 Maintenance ........................... 23 Warranty ........................... 24 This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release... -
Page 4: Safety Guidelines
In situations where it is not possible to perform an installation following the procedures specified in this document, contact BTCPower, Inc. BTCPower, Inc. will not be responsible for any damages that may occur resulting from custom installations that are not specified in this document. -
Page 5: Symbols And Definitions
Indicates important information to consider, otherwise, improper installation and/or damage to components may NOTE occur. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release... -
Page 6: System Overview
6. Charging Coupler (for dual port) - CHAdeMO, SAE Combo - CHAdeMO, SAE Combo This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 7: Equipment Specification
Safety Compliance UL 50E, NEC Article 625, CSA Std C22.2 No. 107.1, FCC Part 15 Class A This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 8: Pre-Installation
Conformance to all governing standards for location and placement of the charger • Communications Connectivity o Refer to BTCPower guidelines in “Determining Suitability of Site for Cellular Connectivity” o Ensure that installation location meets the Cellular Signal Strength Criteria below Parameter... -
Page 9: Ada Consideration
The document, Guidance on the 2010 ADA Standards for Accessible Design, can be downloaded from: http://www.ada.gov This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. - Page 10 ADA requirements. That includes being under 48” of distance to the ground. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission.
-
Page 11: Installation
This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 12: Mounting Procedures
Refer to the installation drawings as illustrated below. Charger Installation Drawing This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 13: Charger Mounting
91578A116 or equivalent) concrete expansion studs or as determined appropriate by the structural engineer in-charge. Make sure to check local codes for compliance. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. - Page 14 The illustration below shows the drilling layout for the Charger. Only four (4) points are needed to fix the unit on the concrete pad. The conduit entry to the unit is also shown. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission.
-
Page 15: Electrical And Communication Service Connection
50kW DC Fast Charger is provisioned to receive an electrical power connection from the bottom. Refer to all applicable codes. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 16: Electrical Connection
Once the enclosure has been situated at its installation location. *Line 1, Line 2, Line 3, and Ground wires are required, neutral is not required. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. - Page 17 2/0 – 6 310 A 250 A 8 – 14 This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release...
-
Page 18: Operation
SCREEN 3 – RFID Card Option Hold RFID Card Close to the Reader to Proceed This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. - Page 19 Press “STOP” Press STOP to to Discontinue Charging stop charging This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release...
- Page 20 SCREEN 9 End of Charging Unplug Connector and Return to Holder This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release...
-
Page 21: Stop Procedure
Option 3 – Press EMERGENCY STOP Button This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release... -
Page 22: Time Outs
In situations like this, user will need to unplug the connector and re-plug before retrying. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 23: Maintenance
Please keep in mind that the replacement interval of each part can vary depending on, for example, the usage environment of the device. This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. -
Page 24: Warranty
Warranty Period, either repair or replace, at BTCPower’s election, the Product if it proves to be defective; provided, that BTCPower will only be responsible for the cost of any parts associated with the repair or replacement of any defective Product for a period of one (1) year after the date of the initial installation of the Product. - Page 25 Force Majeure – any occurrence or extraordinary event or circumstance beyond the control of BTCPower that is an act of God or whether that occurrence is caused by war, riot, storm, (such as hurricane, flooding, earthquake, volcanic eruption, etc.), or other natural forces, or acts of nature or other causes.
- Page 26 Revision Date Description Originator 29-May-19 Initial Release Dante Sanchez This document is the Property of BTCPower Inc. and shall not be copied, reproduced, or used as the basis for sale or manufacture of apparatus without written permission. Initial Release 29-May-19...
Need help?
Do you have a question about the L3R-50-208-01-003 and is the answer not in the manual?
Questions and answers