Table of Contents
Advertisement
Quick Links
9210859, 9210860, 9210861 & 9210863
Place this manual in the Toaster section
of your Equipment Manual.
Manufactured exclusively for
McDONALD'S ®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
Owner Information .....................................................2
General ......................................................................2
Service/Technical Assistance ....................................2
Warranty Information .................................................2
Specifications .............................................................3
Electrical Specifications & Plug Configuration ..........3
Dimensions ................................................................3
Important Safety Information ....................................4
Installation ...................................................................5
Unpacking ..................................................................5
Location .....................................................................5
Operation .....................................................................6
Operating Instructions ...............................................6
User Mode .................................................................6
Manager Mode ..........................................................6
Safety Features .........................................................7
A.J. Antunes & Co. provides the following limited warranty to the original purchaser of all McDonald's Equipment.
All components are warranted against defects in the material and workmanship for a period of two (2) years. If any part becomes inoperable during the period of this
warranty, A.J. Antunes & Co. will pay labor costs to an Authorized Service Agent to replace the part plus travel expenses.
WARRANTY EXCLUSIONS
• The cost of installation.
• Equipment that has been damaged due to shipment. Purchaser should make
damage claim directly upon carrier.
• Alteration, misuse, abuse.
• Improper storage or handling.
• Improper maintenance.
• Failure to follow proper installation instructions, including electrical connec-
tion.
A.J. Antunes & Co. reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment because of
factors beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge.
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular pur-
pose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall A.J. Antunes & Co. or any of its Divisions be liable for
special consequential or incidental damages for the breach or delay in the performance of this warranty.
This manual is for the exclusive use of licensees and employees of McDonald's Systems, Inc..
P/N 1011377 Rev. G 07/17
McDonald's
BUN TOASTER
HEBT-3V
A.J. Antunes & Co.
HEBT-3V
Scan with mobile device or enter URL
for product and service information.
http://tiny.cc/ajaHEBT3V
TABLE OF CONTENTS
Maintenance ................................................................8
Daily Cleaning ...........................................................8
Quarterly ..................................................................11
(Annually) ................................................................13
Troubleshooting .......................................................14
Replacement Parts ...................................................17
Wiring Diagram .........................................................24
Notes..........................................................................25
LIMITED WARRANTY
• Improper or unauthorized repairs.
• Scheduled Maintenance procedures as outlined in your MRC Card.
• Consumables such as Grill Covers (Release Sheets), gaskets, Conveyor Belt
Wraps, O-rings, removal of links, and light bulbs.
• Freight, foreign, excise, municipal, or other sales or use taxes.
• Consequential damages such as loss of profit, loss of time, the cost of repair-
ing or replacing other property which is damaged, or any other incidental
damage of any kind.
© McDonald's Corporation All Rights Reserved
1
HEBT-3V BUN TOASTER
Advertisement
Table of Contents
Related Manuals for McDonald's Antunes HEBT-3V
Summary of Contents for McDonald's Antunes HEBT-3V
-
Page 1: Table Of Contents
BUN TOASTER HEBT-3V BUN TOASTER HEBT-3V 9210859, 9210860, 9210861 & 9210863 A.J. Antunes & Co. Place this manual in the Toaster section of your Equipment Manual. Manufactured exclusively for McDONALD’S ® ANTUNES 180 KEHOE BLVD. CAROL STREAM, ILLINOIS 60188, U.S.A. PHONE: +1-630-784-1000 TOLL FREE: +1-877-392-7854 FAX: +1-630-784-1650... -
Page 2: Owner Information
HEBT-3V BUN TOASTER OWNER INFORMATION General Fill in the information below and have it handy when calling Antunes Technical Service for assistance. The This manual provides the safety, installation, and serial number is on the specification plate located on operating procedures for this unit. Please read this the rear of the unit. -
Page 3: Specifications
HEBT-3V BUN TOASTER SPECIFICATIONS Electrical Specifications & Plug Configuration Model & Plug Plug Volt Watts Mfg. No Description Configuration HEBT-3V IEC-309 Pin & Sleeve, 9210859 (Korea) 220-240 3300 50/60 16 Amp., 230 Volt 9210861 (Europe) Marechal HEBT-3V Pin & Sleeve 9210860 220-240 3180-3750... -
Page 4: Important Safety Information
HEBT-3V BUN TOASTER IMPORTANT SAFETY INFORMATION In addition to the warnings and cautions in this manual, • Bread may burn. Therefore toasters must not be use the following guidelines for safe operation of the used near or below curtains or other combustible unit. -
Page 5: Installation
HEBT-3V BUN TOASTER INSTALLATION Unpacking Rear Bun Feeder Conveyor 1. Open the large box. It contains: Cover Control • HEBT-3V toaster Panel (Side of unit) • Accessories box 2. Remove the accessories box from the large box. 3. With the help of another person, carefully remove the HEBT-3V from the large box. -
Page 6: Operation
HEBT-3V BUN TOASTER OPERATION User Mode Operating Instructions User Mode allows an operator to view the toaster set- The HEBT-3V toasts Crowns, Heels, Clubs, and other tings but does not permit any adjustments. products. Follow these steps to start the HEBT-3V: 1. -
Page 7: Safety Features
HEBT-3V BUN TOASTER OPERATION (continued) Safety Features 4. Press the PROGRAM button to proceed to the Platen B (rear) Setpoint Temperature. HI-LIMIT CONTROL 5. To adjust the Platen B (rear) Setpoint A Hi-Limit Control turns off electrical power to the heat- Temperature, press the LIGHTER or DARKER ers and control circuits if the unit overheats. -
Page 8: Maintenance
HEBT-3V BUN TOASTER MAINTENANCE Daily Cleaning 8. Wash, rinse, and sanitize the bun feeder and bun stop in the three-compartment sink. Allow to air Clean the Toaster and Belt Wraps 1. Turn the toaster’s power switch to the off position. 9. - Page 9 HEBT-3V BUN TOASTER MAINTENANCE (continued) Figure 4. Examples of Damaged Belts P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 10 HEBT-3V BUN TOASTER MAINTENANCE (continued) BELT IS TORN AND FOLDED. REPLACE BELT. Figure 7. Example of Damaged Belt Figure 5. Example of Damaged Belt BELT IS MISSING SNAPS AND IS DAMAGED. REPLACE BELT. Figure 6. Example of Damaged Belt P/N 1011377 Rev. G 07/17 McDonald’s...
-
Page 11: Quarterly
HEBT-3V BUN TOASTER MAINTENANCE (continued) Quarterly Tense Tense Remove Belt Wraps and Clean Rollers 1. Turn the toaster’s power switch to the off position. The toaster enters a cool-down mode and will automatically shut down when complete. Loose 2. Unplug the power cord once the cool-down period Loose is complete. - Page 12 HEBT-3V BUN TOASTER MAINTENANCE (continued) Install Belt Wraps Tense Tense 1. If you are installing the existing belt wraps, inspect the belts. Replace belt wraps if worn or damaged. If the belt wraps are in good condition put them back on the toaster. Loose 2.
-
Page 13: Clean Cooling Fans And Electrical Housings (Annually)
HEBT-3V BUN TOASTER MAINTENANCE (continued) Clean Cooling Fans and Electrical Housings (Annually) 1. Turn the toaster’s power switch to the off position. The toaster enters a cool-down mode and will au- tomatically shut down when complete. Unplug the power cord. 2. -
Page 14: Troubleshooting
HEBT-3V BUN TOASTER TROUBLESHOOTING Problem Possible Cause Corrective Action Control Display flashes The A Platen temperature has not Allow the unit to warm up for 30 minutes and then Err 5 continuously. Buns reached the setpoint temperature recheck. If the Control Display still flashes Err 5, contact your maintenance person or Antunes not toasting properly. - Page 15 HEBT-3V BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Control Display flashes Mechanical bind in one or both con- Enter “user mode” to check the motor speed. Err 20. veyors. Check both conveyors for mechanical binds. Test the motor. Replace necessary parts. Contact your Worn or damaged Ball Bearings.
- Page 16 HEBT-3V BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause Corrective Action Conveyors not turning. Motor Drive Chain is detached from Reinstall the Drive Chain. sprockets. Drive Chain needs lubrication. Lubricate Drive Chain with Lubit-8 (P/N 2140152). Failed Drive Motor. Contact your maintenance person or Antunes Technical Service for service.
-
Page 17: Replacement Parts
HEBT-3V BUN TOASTER REPLACEMENT PARTS Item Part No. Description Qty. Item Part No. Description Qty. 0012603 Sprocket / Tensioner Bracket Assy 48 2140109 Loctite # 242 (Blue) 0012592 Sprocket /Bearing Assembly 49 2150316 Sprocket, 25B12 3/8” Bore 0506185 Bracket, Chain Tensioner 50 310P199* Scr, #10-32 X 3/8 LG Socket HD Cap 1 2140109 Loctite # 242 (Blue) - Page 18 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) Item Part No. Description Qty. Item Part No. Description Qty. 139 300P123* Ring, Retaining, External 96 0506167 Bracket, Bearing 97 0506278 Spacer, .312 X .187 X .105 140 304P105* Nut, Hex ‘Keps’ #4-40 141 306P130* Nut, Hex Keps #6-32 (Small Pattern) 98 7001431 Tensioner Bracket Kit 99 0506292...
- Page 19 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 20 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 21 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 22 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 23 HEBT-3V BUN TOASTER REPLACEMENT PARTS (continued) P/N 1011377 Rev. G 07/17 McDonald’s...
-
Page 24: Wiring Diagram
HEBT-3V BUN TOASTER WIRING DIAGRAM P/N 1011377 Rev. G 07/17 McDonald’s... -
Page 25: Notes
HEBT-3V BUN TOASTER NOTES P/N 1011377 Rev. G 07/17 McDonald’s... - Page 26 HEBT-3V BUN TOASTER NOTES P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 27 HEBT-3V BUN TOASTER NOTES P/N 1011377 Rev. G 07/17 McDonald’s...
- Page 28 +1 (630) 784-1000 +86-512-6841-3637 +1 (800) 253-2991 +86-512-6841-3907 +1 (630) 784-1650...
Need help?
Do you have a question about the Antunes HEBT-3V and is the answer not in the manual?
Questions and answers