The user must ultimately make the decision regarding suitability of the product for any given task and assume the responsibility of safety for all in the work area. Contact a Durapac representative if you are unsure of your spreader’s suitability for a particular application.
Page 3
Hydraulic equipment must only be serviced by a qualified hydraulic technician. For repair service, contact the Durapac authorised service centre in your area. To protect your warranty, use only high quality hydraulic oil CAUTION: ...
4.1 Familiarise yourself with the specifications and illustrations in this owner’s manual. Know your spreader, its limitations and how it operates before attempting to use. Refer to the specification chart below or if in doubt, contact a Durapac representative. Model...
Inspect before each use. Do not use if bent, broken, leaking or damaged components are noted The DHS-15 Spreaders have a spring return cylinder and the speed of retraction is affected by the length of the hose and other restrictions in the line. Most 700 bar hand or power pumps for use with single acting tools are compatible with the DHS-15 spreaders.
Durapac authorised service centre Damage to hydraulic hoses may not be detected during visual inspections. For this reason, Durapac recommends that hydraulic hoses be replaced on a regular basis Tighten connections as needed. Use non-hardening pipe thread compound when servicing connections Dirt, sand, etc.
Tighten couplers slower than normal Blocked hydraulic lines Clean and flush lines Weak or broken retraction Send to a Durapac authorised service springs centre for repair Internally damaged Send to a Durapac authorised service cylinder centre for repair ...
Items marked with a * are contained within a 11 Bolt ZAL1705 standard seal kit. 12 Bolt ZAL1706 13 Coupling ZAL1472 ~The 8mm jaw is no longer available – contact your Durapac representative for replacement instructions. Seal kit ZAL1746 DHS-15 Spreader - V1.4 www.durapac.com Page 8 of 8...
Need help?
Do you have a question about the DHS-15 and is the answer not in the manual?
Questions and answers