Bleeding Air From The Injectors; Electrical System Maintenance; Electrical System Safety; Servicing The Battery - Toro Reelmaster 6700-D Operator's Manual

Bleeding Air from the
Injectors
Note:
Perform this procedure only when the fuel
system has been purged of air through normal priming
procedures and the engine does not start; refer to
Bleeding the Fuel System (page
1. Loosen the pipe connection to the No. 1 nozzle
and holder assembly.
Figure 56
1. Fuel injectors (4)
2. Move the throttle to the F
3. Turn the key to the R
fuel to flow around the connector. Turn the key
to the O position when you see a steady flow
FF
of fuel.
4. Tighten the pipe connector securely.
5. Repeat steps 1 through
nozzles.
Note:
You can remove the fan shroud from the
machine to simplify cleaning.
6. Install the rear screen and secure the latches.
Important:
Do not use water to clean the
engine, as damage may occur.
25).
position.
AST
position and watch for
UN
4 on the remaining
Electrical System
Maintenance

Electrical System Safety

•
Disconnect the battery before repairing the
machine. Disconnect the negative terminal first
and the positive last. Connect the positive terminal
first and the negative last.
•
Charge the battery in an open, well-ventilated
area, away from sparks and flames. Unplug the
charger before connecting or disconnecting the
battery. Wear protective clothing and use insulated
tools.

Servicing the Battery

Service Interval: Every 25 hours—Check the
g019474
The battery electrolyte level must be properly
maintained and the top of the battery kept clean. If the
machine is stored in a location where temperatures
are extremely high, the battery will run down more
rapidly than if the machine is stored in a location
where temperatures are cool.
DANGER
Battery electrolyte contains sulfuric acid
which is a deadly poison and causes severe
burns.
• Do not drink electrolyte and avoid contact
with skin, eyes or clothing. Wear safety
glasses to shield your eyes and rubber
gloves to protect your hands.
• Fill the battery where clean water is always
available for flushing the skin.
• Charge the battery in a well-ventilated
place so that the gasses produced while
charging can dissipate.
• Since the gases are explosive, keep open
flames and electrical sparks away from the
battery; do not smoke.
• Nausea may result if the gases are inhaled.
• Unplug the charger from the electrical
outlet before connecting to or
disconnecting the charger leads
from the battery posts.
Maintain the cell level with distilled or demineralized
water. Do not fill the cells above the bottom of the split
39
electrolyte level (if the machine is in
storage, check it every 30 days).