Maruyama MP2532E2 Owner's/Operator's Manual
  1. Manuals
  2. Brands
  3. Maruyama Manuals
  4. Water Pump
  5. MP2532E2
  6. Owner's/operator's manual
Maruyama MP2532E2 Owner's/Operator's Manual

Maruyama MP2532E2 Owner's/Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the MP2532E2 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Maruyama MP2532E2

Summary of Contents for Maruyama MP2532E2

  • Page 2: Table Of Contents

    Water Pump. It is essential that any operator of this Maruyama product reads and understands the. con­ tents of this manual before using the Water pump.

  • Page 3: Product Description

    PRODUCT DESCRIPTION SPARK PLUG THROTTLE LEVER ENGINE CAP FOR PRIMING AIR FILTER OUTLET PORT STOP SWITCH INLET PORT FUEL TANK DRAIN PLUG STANDARD ACCESSORIES -------- Part Name Remarks Q'ty (�1mill (! Suction Hose ([(U ((� ( (� ® 1 in. Packing 1 in.

  • Page 4: Safety Instructions

    SAFETY INSTRUCTIONS Operator safety Read and understand this Owner's/Operator's Manual before using this product. Be thor­ oughly familiar with the proper use of this product. Never operate this water pump when you are tired, ill or under the influence of alcohol, drugs or medication.
  • Page 5 Move the water pump at least 10 feet (3 m) away from the fueling location before starting engine. 10 feet (3m) 7. Do nofrem6ve the water pump fuel tank cap while the engine is running or right after stopping the engine. 8.

  • Page 6: Assembly Instructions

    ASSEMBLY INSTRUCTIONS Install a rubber packing onto one of the 1 inch hose fittings. Slide a hose fitting nut over the fit­ ting. Slide two hose clamps over the suction hose. Attach the hose coupler assembly and strainer to either end and tighten the hose clamps. Due to different operator requirements, the outlet hose is not provided.

  • Page 10: Starting And Stopping Procedure

    ° ° exceeds 70 F (20 C), turn the choke lever to the Open position, and perform Steps #1) and #3). MARUYAMA (If a engine fails to start after following the above procedures, contact an authorized MARUYAMA dealer.) To Stop The Engine: Move throttle lever to the idle po s itio n .

  • Page 11: Carburetor Adjustment

    CARBURETOR ADJUSTMENT This water pump is equipped with non-adjustable fuel mixture carburetor. The engine idle speed is the only adjustment accessible to the Operator. CAUTION: The water pump impeller is spinning during idle speed adjustment. Never start the engine without water in the pump housing. Running the engine without water in the pump housing will cause serious damage.
  • Page 12 FUEL FILTER Maintenance Interval: The fuel filter should be replaced after every 100 hours of operation. Maintenance: The fuel filter is attached to the end of the fuel FUEL TANK pick-up hose inside the fuel tank. To replace the fuel filter, first make sure the fuel tank is empty.

  • Page 13: S T O R Age

    SPARK ARRESTER Maintenance Interval: The spark arrester should be inspected and c leaned after every 25 hours of use. Replace the screen if it cannot be thoroughly cleaned or if it is damage. Maintenance: The spark arrester is installed inside the exhaust outlet of the muffler.

Table of Contents