Table of Contents
Advertisement
EcoDry Firefighter Turnout
Gear Drying Cabinet
Installation/Operator Manual
WARNING: For your safety the information
in this manual must be followed to
minimize the risk of fire or explosion and
to prevent property damage, personal
injury or death.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch any electrical switch;
do not use any phone in your
building.
Clear the room, building or area of
all occupants.
Immediately call your gas supplier
from a neighbor's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas
supplier, call the fire department.
— Installation and service must be
performed by a qualified installer,
service agency or the gas supplier.
AVERTISSEMENT: Assurez-vous de bien
suivre les instructions données dans cette
notice pour réduire au minimum le risque
d'incendie ou d'explosion ou pour éviter
tout dommage matériel, toute blessure ou
la mort.
—Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides
inflammables à proximité de cet
appareil ou de tout autre appareil.
—QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareils.
Ne touchez à aucun interrupteur. Ne
pas vous servir des téléphones se
trouvant dans le bâtiment.
Évacuez la pièce, le bâtiment ou la
zone.
Appelez immédiatement votre
fournisseur de gaz depuis un voisin.
Suivez les instructions du fournisseur.
Si vous ne pouvez rejoindre le
fournisseur de gaz, appelez le service
des incendies.
—L'installation et l'entretien doivent être
assurés par un installateur ou un
service d'entretien qualifié ou par le
fournisseur de gaz.
American Dryer Corporation
88 Currant Road
Fall River MA 02720-4781 USA
Telephone: +1 (508) 678-9000 / Fax: +1 (508) 678-9447
e-mail: techsupport@amdry.com
www.adclaundry.com
ADC Part No. 113015 - 5
Advertisement
Table of Contents
Summary of Contents for ADC EcoDry ADFG
- Page 1 American Dryer Corporation 88 Currant Road Fall River MA 02720-4781 USA Telephone: +1 (508) 678-9000 / Fax: +1 (508) 678-9447 e-mail: techsupport@amdry.com www.adclaundry.com ADC Part No. 113015 - 5...
- Page 2 Replacement parts can be obtained from your reseller or the ADC factory. When ordering replacement parts from the factory, you can FAX your order to ADC at +1 (508) 678-9447 or telephone your order directly to the ADC Parts Department at +1 (508) 678-9000. Please specify the cabinet model number and serial number in addition to the description and part number, so that your order is processed accurately and promptly.
-
Page 3: Table Of Contents
WARNING In the State of Massachusetts, the following installation instructions apply: Proposition 65 Installations and repairs must be performed by a qualified or licensed contractor, plumber, or Use of this product could expose you to substances gasfitter qualified or licensed by the State of from fuel combustion that contain chemicals Massachusetts. -
Page 4: Safety Precautions
Safety Precautions ____________________ WARNING The collection of lint in the burner area and exhaust WARNING ductwork can create a potential fire hazard. For your safety, the information in this manual must be Unless otherwise specified on the label, fiberglass fabric followed to minimize the risk of fire or explosion and to should not be dried in the gear cabinet. - Page 5 WARNING IMPORTANT: An external means of power removal (disconnect device) must be provided by the installer. This appliance may cause spillage of products of combustion from an open-flue appliance fitted in the CE ONLY same room, and that such an appliance shall be tested for clearance of products with the appliance in IMPORTANT: This appliance must only be installed and operation and all windows and doors closed.
-
Page 6: Specifications
Specifications _____________________________________________________________________ ADFG (5 Suit Hanger) 232 kg NET WEIGHT (Approximate) 513 lb DOMESTIC SHIPPING WEIGHT 548 lb 248 kg 15.24 cm AIR OUTLET DIAMETER 6” 0.75 mbar MAXIMUM STATIC BACK PRESSURE 0.3 W.C .I. MAXIMUM AIRFLOW 300 c.f.m. 510 m HEATING ELEMENTS 12 kW Shaded areas are stated in metric equivalents... - Page 7 Specifications _____________________________________________________________________ ADFG (5 Hanger Cabinet) ADFGX6 (6 Hanger Cabinet) 113015 - 5 www.adclaundry.com...
-
Page 8: Installation Procedures
Installation Procedures ______________ Unpacking / Setting Up _______________ Installation should be performed by competent professional Remove protective shipping material (i.e., plastic wrap and in accordance with local, state, and country codes. In the optional shipping box) from the gear cabinet. absence of these codes, the installation must conform to applicable American National Standards: ANSI Z223.1- IMPORTANT: Gear cabinet must be transported and handled... -
Page 9: Exhaust Requirements
Exhaust Requirements _______________ The ductwork for this appliance must be suitable for the appliance category in accordance with national installation Exhaust ductwork should be designed and installed by a regulations of the country of destination. qualified professional. Improperly sized ductwork will create Outside Ductwork Protection excessive back pressure, which results in slow drying, increased use of energy, and shutdown of the burner by the... -
Page 10: Electrical Information
Electrical Information _________________ ELECTRICAL SERVICE SPECIFICATIONS Electrical Requirements IMPORTANT: 208 VAC AND 230/240 VAC ARE NOT THE SAME. When ordering, specify exact voltage. All electrical connections must be made by a properly NOTES: When fuses are used they must be dual element, time delay, current licensed and competent electrician. -
Page 11: Preparation For Operation / Start-Up
Caution Single-Phase (1ø) Wiring Connections / Hookup The dryer must be grounded. A ground lug has been provided for this purpose. The electrical input connections are made into the rear service box. The ground connection is made to the copper Input connection wiring must be sized properly to handle lug, also provided in this box. -
Page 12: Preoperational Instructions
Electrical Cabinets Gas Models – Discontinue the gas supply. Shut off external gas supply shutoff valve. Check to ensure that electric oven/contactor assembly is activating. Shut off internal gas supply shutoff valve located in the gas valve burner area. Safety Related Circuits Steam Models –... -
Page 13: Returning Warranty Parts
90 Days Shipping charges are not the responsibility of ADC. All returns should be “prepaid” to the factory. Any “C.O.D.” or Remove lint from burner area with a dusting brush or “COLLECT” returns will not be accepted. -
Page 14: Adjustments
____________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ ____________________________________________________________ When contacting ADC, the information on the data label is ____________________________________________________________ required to ensure proper service/parts assistance. The data label is located at the upper left rear of the dryer behind ____________________________________________________________ the back guard. - Page 15 NOTES __________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ _________________________________________________________________________________________________________________________________ 113015 - 5 www.adclaundry.com...
- Page 16 ADC Part No. 113015 5 - 02/27/14...