PermaGreen Supreme Triumph Operator's Manual
  1. Manuals
  2. Brands
  3. PermaGreen Supreme Manuals
  4. Paint Sprayer
  5. Triumph
  6. Operator's manual

PermaGreen Supreme Triumph Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

PermaGreen™ Triumph Spreader Sprayer
800.346.2001, SUPPORT@PERMAGREEN.COM OR AT WWW.PERMAGREEN.COM
Triumph E1E Serial #:
Engine Serial #: GCBTT
Transaxle Serial #: _______________-___________________________________
To Avoid serious injury or death:
This Triumph MUST pass a New Machine Pre-Operation Inspection prior to use.
DO NOT start the machine until instructed to do so during the Pre-Operation Inspection.
Read this Manual before using.
ALL operators and mechanics MUST be trained.
This product can expose you to chemicals including Ethyl Benzene, Naphthalene, N-Hexane, and Benzene
which are known to the State of California to cause cancer and birth defects or other reproductive harm. For
more information go to www.P65Warnings.ca.gov
Copyright © 2018, Perma-Green Supreme, Inc. All rights reserved. No part of this book covered by the copyright hereon may be reproduced
or copied in any form or by any means, except as permitted by the proprietary data statement for use with Perma -Green Supreme. Inc.
equipment, without the written permission of Perma-Green Supreme, Inc. Triumph is protected by US Patent 6.336,600 and 7,954,573 and
Patents Pending.
Operator's Manual
Model E1E with Serial Number 170001 and Above
IF YOU HAVE ANY QUESTIONS OR CONCERNS OR ARE
MISSING PARTS OR NEED WARRANTY SERVICE,
DO NOT RETURN YOUR TRIUMPH TO THE STORE!
PLEASE CONTACT OUR SUPPORT HOTLINE AT
________________________________
_______________________________
Periodically check permagreen.com for available Triumph updates
Perma-Green Supreme, Inc. November 2, 2018 Triumph (v19) North American Version
WARNING

Advertisement

Table of Contents
loading

Related Manuals for PermaGreen Supreme Triumph

Summary of Contents for PermaGreen Supreme Triumph

  • Page 1 Perma -Green Supreme. Inc. equipment, without the written permission of Perma-Green Supreme, Inc. Triumph is protected by US Patent 6.336,600 and 7,954,573 and Patents Pending.
  • Page 2 RECORD OF REVISIONS Keep this record in the front of the manual. When a manual revision is provided, insert the revised pages in the manual. Record the revision number, the date the revision was inserted in the manual, and provide your initials or signature in the BY column.

  • Page 3: Table Of Contents

    TABLE OF CONTENTS Section Page 1. Introduction to using Your Manual....................1 New Machine Pre-operation Inspection ................. 2-3 3. Safety Manual ........................5-13 a) Machine Safety Labels ......................5 b) Warnings ..........................8 4. Driver’s Training and Operation ....................14-19 a.
  • Page 4 Page left intentionally blank...

  • Page 5: Introduction To Using Your Manual

    Congratulations on the purchase of your new Triumph E1E Sprayer Spreader, and welcome to the PermaGreen family! Before attempting to start or operate your Triumph, please read the Operator Manual and safety labels on the machine. Follow all the instructions carefully.
  • Page 6 Safety manual before inspecting, operating or repairing the  Tire Inspection Triumph. If you are not entirely familiar with the Safety Manual,  With the Valve Stem in the 12 O’CLOCK position, make read it now before proceeding with the Pre-Operation Inspection.

  • Page 7: New Machine Pre-Operation Inspection

    Dealer shall provide the purchaser:  With the collection bucket in place, spray through each A) Verbal instructions of their obligation to read the Triumph nozzle individually to purge the lines of RV antifreeze/water Operator’s Manual and the Safety Instructions contained solution.
  • Page 8 Page left intentionally blank...
  • Page 9 EPA and/or CARB authorized service centers. Contact PermaGreen or your PermaGreen dealer with emission controls and component questions. The engine used on your Triumph has been certified with the United States Environmental Protection Agency (EPA) and California Air Resources Board (CARB) for use in the United States and Canada in off-road mobile equipment.

  • Page 10: Safety Manual

    SAFETY MANUAL FIGURE 3, Panel Labels R) WARNING FIGURE 2, Rear Labels Improper operation and improper maintenance of this machine may cause death or serious injury. DO NOT operate the Machine WARNING Labels machine if: (Refer to FIGURE 2) • Engine speed exceeds 3,450 RPM. •...
  • Page 11 Road Valparaiso, IN 46383 800.346.2001. handling and applying. Permagreen.com . MODEL: TRIUMPH E1 W) WARNING SERIAL NUMBER: XXXXX The engine emits toxic, poisonous carbon monoxide gas; DO U.S. PATENTS 6,366,600; 7,954,573 and patents NOT run in an enclosed area.

  • Page 12: A) Machine Safety Labels

     Belt and pulley covers on engine and hood.  As the trainee progresses to more advanced phases of training  Neutral Safety Switch System which prevents the Triumph from the degree of difficulty may be increased, but at each phase the initial training must begin on terrain that has a low degree of starting in gear.
  • Page 13 DO NOT attempt to drive the  Use extra care when operating this machinery on inclines or Triumph in that area. slopes. Be sure to refer to the Operator’s Manual for specific  If hills are present, refer to additional Warnings in Hillside instructions regarding operating the machinery on slopes and/or Operation in this section.
  • Page 14 Stop on level ground. Avoiding slipping or tripping injury  Turn off the engine. Use caution when riding on, and getting on and off the Triumph.  Lock both Brake Levers.  Keep a firm grip on the handles with both hands.
  • Page 15  DO NOT attempt to climb over curbs and parking blocks  Zigzag or slalom slowly and gradually downhill traveling while operating the Triumph at a high speed as this may cause across the grade using both brakes to slow your speed. The a forward tip-over.
  • Page 16 Driving up and down ramps is hazardous. The risks include tip- over, rollover, loss-of-control, and back-over. Use extreme caution when driving the Triumph onto and off of a Transport, (such as a vehicle, carrying rack, or trailer).  When loading and unloading, park the Transport on level...
  • Page 17 Pre-Operation Inspection Tire Safety Pesticide Safety The improper use, handling, application, and disposal of pesticide Tires are filled with pressurized diluted RV antifreeze to provide ballast for a lower center of gravity. Explosive separation of rim and products applied by this machine may cause death or serious injury.
  • Page 18 A. Engine Kill Switch (SD) turns the engine off and permits it to be started. It is part of the Neutral Safety Switch System to prevent the Triumph from starting in Gear. B. Front Brake Lever (SD) controls the front service brake on the Transaxle.

  • Page 19: Driver's Training And Operation

     Turn Kill Switch on. and when the Triumph is operated as a walk-behind unit. HIGH GEAR provides a forward speed of 5.0 MPH.  Choke engine if necessary.
  • Page 20 FIGURE 9. Balance Zone Principles On slopes over 15 DEGREES; stop, release, and lower the handlebar. Walk behind the machine. Never ride the Triumph on inclines or slopes greater the 15 DEGREES. FIGURE 8. Driving Techniques, Triumph Spreader Sprayer...
  • Page 21 Repeat Phase I training using HIGH GEAR. Repeat Phase I Low Gear training procedures as set forth on page 15. However, you Read Safety Manual WARNING 13, Reverse operation now will perform these procedures with the Triumph in high gear rather than low gear. To back up: ...

  • Page 22: Testing Safety Devices

     Pull and release the Front Brake Lever several times. required to perform on the Triumph such as, changing Engine and Ensure that the lever operates smoothly and snaps back Clutch oil, greasing, etc. Refer to Service Manual for scheduled completely when released.
  • Page 23 Components: Front tires (2) and Rear Tires (2).  Read Safety Manual WARNING 18, Tire Safety before starting or operating the Triumph.  Examine all tires for wear and damage. Confirm that tires are free from visible damage and tread depth exceeds 1/4 INCH.
  • Page 24 Page left intentionally blank...

  • Page 25: Spreader Operation

    Spreader Operation Operation of Spreader Controls Spreader Opening and closing. Pesticide Safety  Start spreader operation by pushing the Hopper Lever (C) forward to the OPEN position. The improper use, handling, application, and disposal of pesticide  To stop spreader operation, pull the Hopper Lever rearward to products applied by this machine may cause death or serious the CLOSED position.
  • Page 26 Spreader Operation can be collected and recycled or will not damage desirable the right side of the machine, move the Third-hole Lever turf. forward to increase the opening of the Third-hole Adjuster Plate.  Move the Fertilizer lever forward to open the hopper and clear the clog.
  • Page 27 Gage setting must be verified from time to time.  The Memory-Lock setting is adequate for reference in the If you did not purchase a calibration kit with your Triumph, obtain field, but it must be adjusted to the Calibration Gage during the following materials: the Daily machine Servicing.
  • Page 28  Create a test course based on the effective Spread Width from the table above. EXAMPLE:  Triumph comes set from the factory to an effective spread and spray width of 7 FEET, which can be accomplished by making 7 FOOT center-to-center parallel passes overlapping approximately 50 PERCENT of the last pass.
  • Page 29 12 U.S. GALLONS (45.4 liters). NOTE: The Triumph is not capable of selectively drawing from only one Tank. If your calibrated effective spreader width is 7 feet, the factory settings will enable the sprayer and spreader to be operated at the...
  • Page 30 NOTE: Unless the optional One Half Gallon Spray Kit is used, Valve or 14 FEET using the 30 PSI Unloader Valve. Triumph is intended to spray using only one Nozzle at a time. Increase the pattern width by raising the nozzle level.

  • Page 31: Calibration

    Output from the Nozzles must be plus or minus 15%. the proper ratio with water in a Supply Tank, and dispensed equally If the output from a nozzle is significantly outside the limits, as needed into the Triumph Tanks. refer to SECTION 4, Troubleshooting.  Remove both Tank Lids.

  • Page 32: Spot Sprayer

     To stop spraying, stop squeezing and right the bottle. Filling the Spot Sprayer. The spray bottle can be filled directly from the Triumph spray system using the Fill Valve.  Park Triumph on level ground, shift into NEUTRAL, lock both...

  • Page 33: Troubleshooting Manual

    Troubleshooting Manual If you are experiencing a problem that is not on the list Check or are having difficulty, contact PermaGreen Tech Support at 800-346-2001 or support@permagreen.com. Engine will not Idle Adjustment too low idle Honda Throttle Spring Broken Check Dirty or stale gas Gas Cap plugged Engine...
  • Page 34 Troubleshooting Manual If you are experiencing a problem that is not on the list Transaxle Locked Front Brake locked or are having difficulty, contact PermaGreen Tech Steering Brakes too tight, dirty, or damaged Support at 800-346-2001 or support@permagreen.com. Axle Bearing low on grease Internal Transaxle damage- Check (Do not attempt to repair)
  • Page 35 Troubleshooting Manual If you are experiencing a problem that is not on the list Check or are having difficulty, contact PermaGreen Tech Support at 800-346-2001 or support@permagreen.com. Spray output low Unloader Valve diaphragm dirty or damaged Engine RPM low Check Clogs - Spreader Nozzle Strainer...
  • Page 36 Page left intentionally blank...

  • Page 37: Service Manual

    For more information go to www.P65Warnings.ca.gov □ Check wheel lug nut tightness □ Check tightness of Articulating Joint Bolts IMPORTANT: Keeping the Triumph E1E Spreader Sprayer □ Test Safety Devices operating reliably requires attention to maintenance. Proper maintenance prevents damage to your machine and preventable □...
  • Page 38 Replace any lost fluid. Read Safety Manual WARNING 18, Tire Safety before starting, operating or performing repairs or maintenance on the Triumph. Tires are filled with pressurized diluted RV antifreeze to provide ballast for a lower center of gravity. EXPLOSIVE SEPARATION OF RIM AND TIRES MAY CAUSE SERIOUS INJURY.
  • Page 39 Read Safety Manual WARNING 14, Parking before starting or operating the Triumph. Read Safety Manual WARNING 5, Safety Devices now. Read Safety Manual WARNING 21 Handling and Disposal...
  • Page 40 On a level open area free from obstructions and bystanders, lock Read Safety Manual WARNING 5, Safety Devices before both Brakes, shift into NEUTRAL, and start engine. starting or operating the Triumph. There are 2 methods to adjust the top engine speed. Return Spring (FIGURE 22), Multifunction Display (Tachometer),...
  • Page 41 (page 18) in the “Driver’s Training and Operation” section of this Manual. Read Safety Manual WARNING 5, Safety Devices before starting or operating the Triumph. Adjusting Steering Brakes (Refer to Figure 25.1) To increase Steering Brake assistance:  Hold the adjustment bolt A and loosen lock nut B to the desired amount.

  • Page 42: Plumbing And Electrical Schematics

    Plumbing and Electric Schematics FIGURE 25, Plumbing Diagram FIGURE 26, Wiring Diagram Starting module Neutral switch Ground to engine Kill switch Engine Magneto...

  • Page 43: Specifications

    Premium unleaded (preferred) Regular unleaded (minimum) NOTICE: NEVER use E85 or other high ethanol fuel Oil Specifications on your new Triumph: - Engine 10w30 (0.63 us quart - Clutch 10w30 (0.53 quart) - Transmission 90 synthetic gear lube Belt sizes: 1.

  • Page 44: Warranty

    Warranty WARRANTY Except as noted below, Perma-Green Supreme, Inc. hereby warrants to the original purchaser of the 2014 Triumph E1E manufactured by PermaGreen Supreme, Inc. that: For 60 Days, PermaGreen will Buy-Back the machine for the full purchase price including freight and tax (Limit one Buy-Back per customer);...

This manual is also suitable for:

E1e

Table of Contents