Related Manuals for Titus THH Series
Summary of Contents for Titus THH Series
- Page 1 I N STA L LAT I O N M ANUA L TH H H I G H PE R F ORMA NC E HOR IZONTAL FA N CO IL UNITS Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 2 Table of Contents INTRODUCTION Introduction ........................2 Safety Symbols ......................3 Titus fan coils represent a prudent investment which can, with proper Safety Precautions ...................... 3 installation, operation, and regular maintenance, give trouble free Section 1 – Receipt & Initial Installation operation and long service. Your equipment is initially protected under Code Compliance ....................
- Page 3 HOT PARTS HAZARDS Electric Resistance heating elements must be disconnected prior to servicing. Electric Heaters may start automatically, danger disconnect all power and control circuits prior to servicing to avoid burns. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 4 Return Authorization Number will be issued. Unauthorized return shipments of equipment and shipments not marked with an authorization number will be refused. In addition, the manufacturer will not accept any claims for unauthorized expenses. Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 5 LEVEL plane. All units are supplied with hanging holes for use with all thread rods. Redefine your comfort zone. ™ | www.titus-hvac.com Engineering Guide-THB...
- Page 6 For proper moisture carry-off, the drain piping should be sloped away from the unit at least 1/8” per foot. A drain trap may be required by local codes and it is strongly recommended for odor containment. Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 7 However should the need arise, the plenum box is easily removable by removing the screws attaching the plenum box to the sides, top and rear of the coil casing. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 8 The manufacturer assumes no responsibility for undesirable system operation due to improper design, equipment or component selection, and/ or installation of duct work, grilles, and other field supplied components. Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 9 The manufacturer assumes no responsibility for any damages and/or injuries resulting from improperly field installed or wired components. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 10 A clean filter of the proper size and type must also be installed. Failure to do so could result in damage to the equipment or building and furnishings, and/or void all manufacturers’ warranties. Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 11 1. Motor electrical data is nameplate data. Actual data will vary with application. 2. 230 volt motor is name plated for 208/230/1/60. Use 230 volt motor data for 208 volt applications Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 12 Airflow under dry coil connections. All models tested at 0.05" external static pressure. 2. Airflow rate CFM on sizes 14 through 20 exceed maximum ratings in AHRI 440 and are therefore not certified Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 13 Motors are permanently lubricated, PSC or ECM type and do not require field lubrication. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 14 Vacuuming should again follow this. Units provided with the proper type of air filters, replaced regularly, may require periodic coil cleaning. Electric Heater Removal Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 15 85 [39] 8 Row - Wet 55 [26] 63 [29] 71 [32] 79 [36] 87 [40] 95 [43] 103 [47] 111 [50] Notes: Unit weight data is in pounds [kilograms] Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 16 All repair work should be done in such a manner as to maintain the equipment in compliance with governing codes and ordinances or testing agency listings. Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 17 1. Shaded areas indicate kW and voltage options not avialable 2. Available voltages are single phase, 60 hertz. 3. Heaters over 48 AMPs are subdivided and fused per NEC Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 18 (2) 16 x25 [406 x635] 5.14 [0.48] 12.0 [1.11] 17.0 [1.58] Notes: 1. Face and free areas are in square feet [square meters] 2. Filter sizes are in inches [millimeters] Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 19 12 months unless the component is furnished as warranty replacement. Parts furnished as warranty replacements are warranted for the remaining term of the original unit warranties. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 20 10 x 16 x 6 250 x406 x 152 4. Auxiliary drain outlet is 5/8” ODM copper or 3/8” MPT galvanized 16 x 16 x 6 406 x 406 x 152 steel respectively Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 21 63 [1600] 8 1/2 [210] package condensate 47 [1194] 53 [1346] 56 1/8 [1426] 67 [1702] 8 1/2 [210] 4. Coil hand is field reversible (left hand unit shown) Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 22 250 x 406 x 152 4. Auxiliary drain outlet is 5/8” ODM copper or 3/8” MPT galvanized 16 x 16 x 6 406 x 406 x 152 steel respectively Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 23 3. Optional auxiliary drip pan available for piping package condensate 47 [1194] 53 [1346] 56 1/8 [1426] 67 [1702] 49 7/8 [1267] 4. Coil hand is field reversible (left hand unit shown) Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 24 10 x 16 x 6 250 x 406 x 152 46 1/2 [1181] 64 1/4 [1632] 53 [1346] 49 1/2 [1257] 16 x 16 x 6 406 x 406 x 152 Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 25 79 1/8 x 36 1/8 5. Filter and grill sizes are the same for each unit size in the [2057] [2002] [1271] [1268] [2009 x 918] THH product line. Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 26 Enclosed Cabinet 1 1/8 1 1/8 Fan Coil Unit Notes: 1. All dimensions are Inches [mm] AND are ± 1/8” 2. Coil handing is field reversible (left hand units shown) Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 27 Reinstall All Covers & Access Panels Proper Supply & Return Grille Type & Size Used ʋ Control Outside Air for Freeze Protection ʋ Insulate All Duct work as Required Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 28 THH HIGH PERFORMANCE HORIZONTAL FAN COIL UNITS Notes Installation Manual – THH Redefine your comfort zone. ™ | www.titus-hvac.com...
- Page 29 Notes Redefine your comfort zone. ™ | www.titus-hvac.com Installation Manual – THH...
- Page 30 605 Shiloh Rd Plano TX 75074 ofc: 972.212.4800 fax: 972.212.4884 Redefine your comfort zone. ™ | www.titus-hvac.com...
Need help?
Do you have a question about the THH Series and is the answer not in the manual?
Questions and answers