Page 1 MASTER 100 X 75 INSTALLATION MANUAL (EUROPE) VERSION 1.8 DATED 04/09/2020...
Page 3 CAUTIONS AND WARNINGS OVERVIEW FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH.
Page 4: Table Of Contents
DRAGO P1 PLUS INSTALLATION MANUAL FIRST FIRING TURNING OFF THE BURNER MAINTENANCE DRAGO D1/M INSTALLATION MANUAL FIRST FIRING TURNING OFF THE BURNER MAINTENANCE WARRANTY www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 5: Cautions And Warnings
CAUTIONS AND WARNINGS This section details the correct operation and install of a Gozney Oven.
Page 6: Oven Overview
Always use the Oven Door in accordance with the User Manual. The Door must never be in the Closed position whilst a fire is lit in the oven. Cutting off the oxygen can cause the fire to erupt suddenly when the door is removed. www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset.
Page 7 It is recommended to install a CO2 alarm and a CO alarm within the same room as the appliance. It is recommended to use appropriate pizza oven tools to operate the oven safely and efficiently. Contact Gozney Ltd in the event that your oven requires maintenance or servicing.
Page 8 Air Act 1993 including designation and supervision of smoke control areas and you can contact them for details of Clean Air Act requirements. The Gozney 1012 oven is an exempt appliance suitable for burning wood logs and gozney manufactured wood logs in accordance with the manufacturer instructions.
Page 11: Pre-Install
PRE-INSTALL This section details how to correctly install a Gozney oven.
Page 12: Extraction
Extraction option 1 - Flue OPTION 2 - CANOPY When operating a Gozney Oven exclusively on gas, it may be possible to utilise an existing or new kitchen extract system via the use of an extraction canopy. ALWAYS CHECK WITH YOUR EXTRACTION PROVIDER PRIOR TO USING YOUR OVEN.
Page 13: Excessive Ventilation From Over Head Canopies
WARNING: ALWAYS ENSURE canopy. THAT A CARBON MONOXIDE Gozney Ovens suggest that an extraction canopy is positioned at MONITOR IS FITTED WITHIN A a distance of 350mm from the top of the oven dome. Emissions SAFE DISTANCE OF THE OVEN.
Page 14: Venting
PRE-INSTALL VENTING INTRODUCTION TO VENTING DAMAGE CAUSED BY NOT When installing a Gozney commercial gas fired oven there ADHERING TO VENTING are some basic guidelines to follow to ensure that the INSTRUCTIONS WILL NOT BE gas burner is vented well and can operate correctly. Not COVERED BY WARRANTY.
Page 15: Acceptable Venting
ACCEPTABLE VENTING It is important that the gas burner has sufficient ventilation to operate correctly. GENERAL DOS • Maintain a clear air flow to the gas burner from the same area as the oven mouth. • The gas burner must be accessible at all times. •...
Page 16: Unacceptable Venting
PRE-INSTALL VENTING UNACCEPTABLE VENTING Additional Venting or Poorly Sealed enclosure Blocked Air Vent Enclosure Open to False Ceiling Void No Rear/ceiling/side around Enclosure www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 17: Factors Affecting Flue System Performance
FACTORS AFFECTING FLUE SYSTEM Flue Extraction PERFORMANCE DOWNDRAFT CONDITIONS Downdraft is caused when air is forced back down the flue system and into the oven cavity and room where the oven is situated. This can be caused by environmental conditions acting on an incorrectly positioned flue terminal.
Page 18: Gas Closure Ventilation
Support stand enclosure must be made entirely from non- combustible materials. Incorrect gas enclosure www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999...
Page 19: Clearances
PRE-INSTALL CLEARANCES CEILING CLEARANCE A minimum clearance of 350mm from any combustible material is required from the top of the oven. These clearances apply over and above the oven core and insulation materials, from the outer most extremity of the oven’s final finished surface.
Page 21: Build Manual
Parts List Liste der Einzelteile Lista de partes Elenco delle parti Liste des pieces...
Page 22 G0889 G0882 Scale: 1:1 ZR001 ZS002 140x www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 23 Scale: 1:1 ZB008 ZB005 ZB006 ZB007 ZW002 ZN002...
Page 24 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 27 Stand Stand Estar Stare in piedi Supporter...
Page 28 ZB008 ZB005 ZW002 ZN002 ZW002 ZN002 ZB007 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 29 ZW002 ZN002 ZB007 ZB006...
Page 30 ZN006 ZW002 ZN002 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 31 1.7.1 Right Hand Burner Rechter Brenner Quemador de mano derecha Bruciatore a mano destra Bruleur Droite 1.7.2 Left Hand Burner Linker Handbrenner Quemador de mano izquierda Bruciatore a mano sinstra Bruleur Gauche...
Page 32 ZB007 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 33 1.10 1.11.1 1.11.2 1.11.3...
Page 34 1.11.1 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 35 1.11.2 Left Hand Burner Linker Handbrenner Quemador de mano izquierda Bruciatore a mano sinstra Bruleur Gauche...
Page 36 1.11.3 Right Hand Burner Rechter Brenner Quemador de mano derecha Bruciatore a mano destra Bruleur Droite www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 39: Arch And Floor
Arch and Floor Bogen und Boden Arco y piso Arco e pavimento Voûte et plancher...
Page 40 ZW002 ZN002 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 41 crop to circle Break circle where pucks and arch intersect...
Page 42 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 44 2.7.1 2.7.2 2.7.3 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 45 2.7.1...
Page 46 2.7.2 ZS002 Right Hand Burner Rechter Brenner Quemador de mano derecha Bruciatore a mano destra Bruleur Droite www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 47 2.7.3 ZS002 Left Hand Burner Linker Handbrenner Quemador de mano izquierda Bruciatore a mano sinstra Bruleur Gauche...
Page 48 ZM006 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 49 2.13 50 mm 2” 15 mm 5/8” 2.10 50 mm 2” 15 mm 5/8”...
Page 50 2.11 50 mm 2” 15 mm 5/8” 2.12 50 mm 2” 15 mm 5/8” www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 51 2.13 2.14 ZS002...
Page 53: Dome And Flue
Dome and Flue Kuppel und Kamin Cúpula y chimenea Cupola e canna fumaria Dôme et conduit...
Page 54 Electronic Burner 24kW Manual Burner 24kW 10mm 4/10” www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 55 3.15 10mm 3/8”...
Page 56 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 58 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 60 3.10 10mm 3/8” www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 61 3.11 ZW002 ZN002 ZS002 3.12...
Page 62 Electronic Burner 24kW Manual Burner 24kW 3.14 3.14 3.13 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 63 3.14...
Page 64 3.15 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 65 3.16 3.17...
Page 67: Insulation And Mesh
Insulation and Mesh Isolierung und Mesh Aislamiento y malla Isolamento e maglia Isolation et Mesh...
Page 68 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 69 Layer 1 Schicht 1 Capa 1 Strato 1 Couche 1 Layer 2 Schicht 2 Capa 2 Strato 2 Couche 2...
Page 70 Layer 3 Schicht 3 Capa 3 Strato 3 Couche 3 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 71 ZR001...
Page 72 ZR001 ZR001 ZS002 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 73 4.10 ZR001 ZS002 4.11 ZR001 ZS002...
Page 74 4.12 ZR001 ZS002 4.13 ZR001 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 75 4.14 ZS002 4.15...
Page 76 4.16 4.17 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 77 4.18 ZR001...
Page 78 4.19 ZR001 4.20 ZR001 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 79 4.21 ZR001 4.22 ZR001...
Page 80 4.23 ZR001 4.24 ZR001 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 81 4.25 ZR001 4.26...
Page 82 4.27 ZR001 4.28 ZR001 www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 83 4.29 ZS002 4.30 ZS002...
Page 85: Rendering
Rendering Rendering Representación Rendering Le rendu...
Page 86 4mm Fiber Glass 4mm Fiber Glass Render Mesh* Render Mesh ≈5m ≈5m² www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 87 Pre-Mixed Lime Based Pre-Mixed Lime Based Render Render 5 x 25kg bags* 5 x 25kg bags Render Mesh Layer Finished Render ≈20mm ≈3/4”...
Page 88 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 90 24Hr - 48Hr @ 20°C / 68°F www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 93: Wood Fired
WOOD FIRED This section details safety and how to get the most from your oven when firing on wood.
Page 94: First Firing
Fire has been left to die Ok to use door in closed or ajar died down. vegetables. Baking breads. down after the oven has positions. been saturated. www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 95: Maintenance
“self-cleaning”. To do this raise the to be stored in commercial kitchen locations. Please contact temperature of the oven on to above 360ᵒC (680ᵒF) for a Gozney Ovens for more information on HACCP certified fuels. period of time. FLUE SYSTEM MAINTENANCE It is essential that regular cleaning of the flue and extraction system is undertaken.
Page 96 Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 98 Natural Odour Free Firelighter www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 99 1-2” 1-2” 25-50mm 25-50mm...
Page 100 Natural Odour Free Firelighter www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 103: Gas Burners
GAS BURNERS This section details safety and how to get the most from your oven when using a gas burner...
Page 104 GAS BURNERS OVERVIEW INTRODUCTION This manual explains how to install your burner and perform an initial firing to cure your Gozney oven. For information on how to operate your burner, please refer to the Avanzini user manual provided. GAS BURNERS...
Page 105 FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE WARNING: IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLATION OR SERVICING THE EQUIPMENT...
Page 107: Drago P1 Plus
Drago P1 Plus Installation Manual Installationsanleitung Manual de instalación Manuale di installazione Installation Manuel...
Page 108 ZW004 ZN006 ZB011 Left Hand Burner Linker Handbrenner Quemador de mano izquierda Bruciatore a mano sinstra Bruleur Gauche www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 109 ZW004 ZN006 ZB011...
Page 110 ZW004 ZN006 ZB011 Right Hand Burner Rechter Brenner Quemador de mano derecha Bruciatore a mano destra Bruleur Droite www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 111 ZW004 ZN006 ZB011...
Page 112: First Firing
To turn the oven off turn the dial so it is positioned on the black dot. When the flame and the pilot flame has gone out it is then safe to put the door on the oven. www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset.
Page 113: Maintenance
DRAGO P1 PLUS MAINTENANCE OVERVIEW For general cleaning and maintenance, Always ensure that the following steps are adhered to. If your burner is blocked, it is often possible to resolve the issue without removal of the burner. CLEANING THE BURNER WHILST CONNECTED TO THE OVEN Switch the main gas tap off (close).
Page 115: Drago
Drago D1/M Installation Manual Installationsanleitung Manual de instalación Manuale di installazione Installation Manuel...
Page 116 ZW004 ZN006 ZB011 Left Hand Burner Linker Handbrenner Quemador de mano izquierda Bruciatore a mano sinstra Bruleur Gauche www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 117 ZW004 ZN006 ZB011...
Page 118 ZW004 ZN006 ZB011 Right Hand Burner Rechter Brenner Quemador de mano derecha Bruciatore a mano destra Bruleur Droite www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset. +44 (0)1425 204 999 BH23 4FL.
Page 119 ZW004 ZN006 ZB011...
Page 120: First Firing
Now press the main red switch on the left side to turner the controller off. When the flame has gone out it is then safe to put the door on the oven. www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com Christchurch, Dorset.
Page 121: Maintenance
DRAGO D1/M MAINTENANCE OVERVIEW For general cleaning and maintenance, Always ensure that the following steps are adhered to. If your burner is blocked, it is often possible to resolve the issue without removal of the burner. CLEANING THE BURNER WHILST CONNECTED TO THE OVEN Switch off the power supply to the gas burner and control panel.
Page 123: Warranty
WARRANTY This section explains the warranty associated to the oven.
Page 124 20% or less or our briquettes; www.gozney.com Unit 18 & 19, The Runway, enquiries@gozney.com...
Page 125 This warranty, and our liability to you, is governed by our standard terms and conditions of sale. Please refer to our standard terms and conditions at www.gozney.com/terms-conditions In the event of any inconsistency, our standard terms and conditions will prevail.

This manual is also suitable for:

Master 75 x 75 Core 100 x 75

Gozney MASTER 100 X 75 Installation Manual

Quick Links

Need help?

Questions and answers

Related Manuals for Gozney MASTER 100 X 75

Summary of Contents for Gozney MASTER 100 X 75

This manual is also suitable for:

Table of Contents