Troubleshooting - Weber 43028 Owner's Manual

18
PROBLEM
Burner burns with a dark orange
fl ame, in conjunction with heavy soot-
ing.
Burner does not light. -or - Burner has
a small fl ickering fl ame in the HIGH
position.
Burner does not light, or fl ame is low
in HIGH position.
Flame seems to lose heat when
burning in cold weather temperatures
50° F or colder. (The liquid propane in
the cylinder turns to vapor too slowly
to supply the burners with gas. This is
due to the air temperature cooling the
LP cylinder which slows the
vaporization process.)
Burner fl ame pattern is erratic. Flame
is low when burner is on HIGH. Flames
do not ignite all burner holes.
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area
using the contact information on our web site. Log onto www.weber.com

TROUBLESHOOTING

CHECK
Inspect Spider / Insect Screen for pos-
sible obstructions. (Blockage of holes.)
The excess fl ow safety device, which is
part of the fi replace to cylinder connec-
tion, may have activated.
Is LP fuel low or empty?
Is fuel hose bent or kinked?
Is igniter functioning properly?
Is the igniter box blocked?
Is there frost/ice on the outside of
the LP cylinder?
Are burner holes blocked?
Clean Spider / Insect Screen. (See Section
"Annual Maintenance")
To reset the excess fl ow safety device turn all
burner control knobs and the cylinder valve
OFF. Disconnect the regulator from the cylin-
der. Turn burner control knobs to HIGH. Wait
at least 1 minute. Turn burner control knobs
OFF. Reconnect the regulator to the cylinder.
Turn cylinder valve on slowly. Refer to "Light-
ing Instructions".
Refi ll LP cylinder.
Straighten fuel hose.
Replace igniter (see contact info. below).
Remove obstructions from igniter box (see
pg. 10, Step 11 of "Assembly" Section).
Turn off burner control knobs and
the LP cylinder. Replace with a
spare LP cylinder and resume
burning.
WARNING: The spare or
disconnected LP cylinder must
be stored outdoors in a well
ventilated area out of the reach
of children.
Clean burner holes. (See Maintenance Sec-
tion.)
® .
CURE