All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by CS 0771 BU CD Customer Service...
1.2.1 I/O interface Allowed signal mode specified Tuner: Latin PAL M/N, NTSC-M TV tuning systems Compair Rx/Tx communicate For 19PFL4322/45 AV1 audio IN : AV1 and S-Video shared audio R/L(RCA jack) AV1 IN : Composite video input (AV1) PC timing table CVI IN : Component input with YPbPr format with audio R/L.
Page 3
TPS 1.0L LA 1. Technical Specifications, Connections and Chassis Overview T.M.D.S. Data2- RF Signal: Aerial input / 10mV(typical: 80dBuV; range: 30-100dBuV) T.M.D.S. Data2+ Video signal : CVBS input ( RCA jack) / 1Vpp (300mV-sync, T.M.D.S. Data2/4 Shield 700mV-video.) No connect No connect S video input / 1VppY-signal, +/-300mV C-signal DDC Clock...
Page 4
TPS 1.0L LA 1. Technical Specifications,Connections,and Chassis Overview 1.3 Chassis Overview Type: 19PFL4322/45 Key Board Scaler Board Power Board Side AV Board IR Board...
Be careful during measurements in the high voltage by the workshop during a repair: section. • Use only lead-free soldering tin Philips SAC305 with order • Never replace modules or other components while the unit code 0622 149 00106. If lead-free solder paste is required, is switched “on”.
You can download this information from the following websites: 2.3.5 Alternative BOM identification http://www.philips.com/support http://www.p4c.philips.com The third digit in the serial number (example: AG2B0335000001) indicates the number of the alternative B.O.M.
Page 7
TPS 1.0E LA 3. Directions for Use 3. Directions for Use Refer to page 6.
TPS 1.0L LA 4. Mechanical Instructions 4. Mechanical Instructions Step 1. Remove the Base. a. Remove the 2 screws as Fig.3~4. Index of this chapter: b. Remove the 4 screws as Fig.5. 4.1 Assy/Panel Removal 4.2 Set Re-assembly 4.1 Assy/Panel Removal Note:Please put your mechine on a soft material to avoid to scrape panel when you disassemble it.
Page 9
TPS 1.0L LA 4. Mechanical Instructions Step 2. Remove the Back cover. a. Remove the 6 screws as Fig.6 b. Remove the 2 screws , then r emove the back cover as Fig.7. Fig.7 Fig.6 Step 3. Remove the Scaler, Power, IR ,Side AV and Key board as Fig.8 . a.
Page 10
TPS 1.0L LA 4. Mechanical Instructions Step 4. Remove the Front bezel as Fig.9. a. Remove the 19 screws to remove the Front bezel as Fig.9. Fig.9 Step 5. Remove the Frame assy as Fig.10~11. Remove the 4 screws as Fig.10. b.
Page 11
TPS 1.0L LA 4. Mechanical Instructions Fig.11 Fig.12 Insulation material 4.2 Set Re-assembly To re-assemble the whole set, execute all processes in reverse order. Notes: a. While re-assembling, make sure that all cables are placed and connected in their original position. b.
It can display CSM windows message when press 1-2 3-6 5-4 on the button (RC) remote control in normal operation mode. The following information is displayed on screen: Set type: Model type would be displayed on this item. 19PFL4322/45 Production code: S/N would be displayed on this item.
Page 13
TPS 1.0L LA 5. Service Modes, Error Codes and Fault Finding 5.2 Factory Mode Press "Menu062596 " on remote control then Press "Up " or "Down " button to move cursor to bottom item and then press "OK " button to enter factory mode. Factory indicate For white balance alignment For auto color alignment...
Page 14
TPS 1.0L LA 5. Service Modes, Error Codes and Fault Finding 5.3 Repair flow chart 1.No work/LED is off Check if power switch is Replace Power switch normal Check IR board CN001 pin1=0V,pin2=3.7V, Check IR board pin3=3V,pin4=2.85V ,pin5=5V,pin6 =3.3V Check scaler board U102 pin1=14V,pin4=1.22V, pin7=16V,pin8=5V, 2.No raster/picture too...
Page 15
TPS 1.0L LA 5. Service Modes, Error Codes and Fault Finding 3.No picture/LED is green Check scaler board U102 Check power pin1=14V,pin4=1.22V, pin7=16V,pin8 Check circuit around Check if each regulator and working voltage eliminate short and U152,pin2=3.3V open situation pin3=5V Check if clock Replace X350 source X350...
Page 16
TPS 1.0L LA 5. Service Modes, Error Codes and Fault Finding 4.No TV sound Check if tuner TU201 pin11 Replace TU201 output IF signal Check U301 5.No earthphone sound Check Eliminate short and open U760 pin15=3.3V situation Check U760 pin20=HPOUTL Replace U760 pin6=HPOUTR Replace Side AV Board...
Page 17
TPS 1.0L LA 5. Service Modes, Error Codes and Fault Finding 6.No remote function Tty another Replace one good remote control remote control Check IR receiver 7.LED and function key poor Check circuit around control board and cable between control board and scaler board 8.No HDMI picture Invalid Change U701 writen...
TPS 1.0L LA 8. Alignments 8. Alignments Index of this chapter: 8.1 Electrical Instructions 8.2 ISP Instructions 8.3 Serial Number Definition Notes: You could adjust the LCD/TV following this chapter when the LCD/TV has the below defect. 1. Change panel. 2. Change or repair main board. 3.
Page 62
8.2 Software Upgrading 8.2.1 ComPair Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 1. ComPair features TV software upgrade possibilities. 2. ComPair helps you to quickly get an understanding on how to repair the chassis in a short and effective way (this feature is not supported in this chassis).
Page 63
TPS 1.0L LA 8. Alignments 8.3 Serial Number Definition BOM Code: PANEL SUPPLIER CODE LPL(LG) B Z 5 A 0 7 0 1 0 0 0 0 0 1 Sequence number (6 digits) Production year/week code Service version change code BOM (bill of Material) code Site code (Production center) BZ CODE ( AR---CZECH REPUBLIC,...
9.1 Circuit Descriptions 9.1.1 General Descriptions M-star MST96885ALD is a high performance and fully 19PFL4322/45 is the 3rd generation of Fighter series (F3 integrated IC for multi-function LCD TV/Monitor with Latam) Flat Panel Display TV with lead free policy. It designs resolutions up to SXGA/WXGA.
Page 65
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets The MST96885ALD enables consumer electronics HDMI supports HDMI/ Digital signal with HDCP function, manufactures to build high quality, feature-rich ATV. PC supports 15pin D-sub input The tuner supports NTSC RF signal by region, For TV signal, All the input source video signals will directly deliver to MST96885ALD embeds analog video demodulator, decodes MST96885ALD for video part further processing.
Page 66
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets - Reduced swing for LVDS for low EMI NTSC/PAL/SECAM Video Decoder - Supports flexible spread spectrum frequency with Supports NTSC M, NTSC-J, NTSC-4.43, PAL (B,D,G,H,M,N, 360Hz~11.8MHz and up to 25% modulation I,Nc), and SECAM - Automatic TV standard detection CVBS In...
Page 67
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets 9.2 Abbreviations List Customer Service Mode ATSC Advanced Television Systems Committee, the digital TV standard in the USA Digital Versatile Disc EEPROM Electrically Erasable and Programmable Read Only Memory 3DNR Temporal (3D) Noise Reduction Automatic Gain Control: algorithm that controls the video input of the feature box...
Page 68
Scan mode where two fields are used to form one frame. Each field contains half the number of Interlaced the total amount of lines. The fields are written in "pairs", causing line flicker. Infra Red Interrupt Request LATAM Latin America Liquid Crystal Display Light Emitting Diode LG.Philips LCD (supplier) MUTE MUTE Line...
Page 69
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets Thin Film Transistor SRAM Static RAM STBY STandBY Sync On Green SVGA 800x600 (4:3) SVHS Super Video Home System Software SWAN Spatial temporal Weighted Averaging Noise reduction SXGA 1280x1024 TMDS Transmission Minimized Differential Signalling...
Page 70
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets 9.3 IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs). 9.3.1 IC Data Sheet-MST96885L (U4101) PIN Assignments...
Page 71
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets 9.3.2 IC Data Sheet-TPA3005D2PHPR (U6201) Block diagram...
Page 72
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets PIN Assignments...
Page 73
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets 9.3.3 IC Data Sheet-HY57V641620ETP(U4203) Function block diagram...
Page 74
TPS 1.0L LA 9. Circuit Descriptions, Abbreviations List and IC Data Sheets Pin assignments...
Page 75
TPS 1.0L LA 10.Recommended/Spare Parts List 10.1 Recommended Parts List Type:19PFL4322/45(CMO) (see next pages)
Page 76
CER2 1206 Y5V 10V 10U P8020 R 065G1206106A7Z 1056 C4144 996500042262 CAP CHIP 0603 100N 50V Y5V 065G060310437Z 1057 996510006778 SIDE AV PCB ASSY - 19PFL4322/45 PTPF7PB2 C4146 996500042233 CER2 1206 Y5V 10V 10U P8020 R 065G1206106A7Z C4147 996500042262 CAP CHIP 0603 100N 50V Y5V 065G060310437Z...
Page 79
EC 120uF 450V KM 22x41mm 067G305T12115C Q6201 996500042649 TRA SIG SM BC847C (KEC0) R 057G477900T C907 996510002802 EC 105 120uF 450V 067K215S12115K Q7101 996500042211 TRA PDTC114EK SC-59 PHILIPS 057G7602PH C908 996500043821 0.47UF 275VAC 063G107474HS Q7101 996500037397 TRA SIG SM MUN2211J(ONSE)R 057G7601PH C908 996500037794...