Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for AOBOET Uhome-LFP 5.8kWh/LV
Summary of Contents for AOBOET Uhome-LFP 5.8kWh/LV
- Page 1 AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au User Manual V 1.2...
-
Page 2: About This Manual
E-mail: info@aoboet.com.au About this manual This manual is intended for the AOBOET Uhome-LFP 5.8kWh/LV Energy Storage battery, but the hybrid inverter and any other equipment is not included. The AOBOET hot line and http://ess.AOBOET.com.au are both available if you want to... -
Page 3: Statement
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Statement Compliant to Best Practice Guide for Battery Storage Equipment—Electrical Safety Requirements- version 1- Pre-assembled integrated battery energy storage system equipment –... -
Page 4: Table Of Contents
Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Contents About this manual · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · I Statement ·... - Page 5 Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Storage · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · · - 12 - Battery Installation ·...
-
Page 6: Safety Introduction
A warning describes a hazard to equipment or personnel. It calls attention to a procedure or practice, which, if not correctly performed or adhered to, could result in damage to or destruction of part or all of the AOBOET equipment and/or other equipment connected to the AOBOET equipment or personal injury. -
Page 7: Response To Emergency Situations
If the battery catches fire, it will produce poisonous gases. Do not approach. 1.4.3 Wet battery If the battery is wet or submerged in water, do not try to access it. Contact AOBOET hot line or your distributor for technical assistance. -
Page 8: App Download
Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au AOBOET Energy Storage battery is suggested installing by skilled worker or electrician. A skilled worker is defined as a people who had been trained and qualified electrician or had all of the following skills and experience: - Knowledge of the functional principles and operation of on-grid Energy Storage systems. -
Page 9: Product Introduction
Cell UL 1973 Safety Pack TUV(IEC 62619, IEC 62040-1) Hazardous Material Classification Transportation UN 38.3 Testing conditions based on temperature 25℃ at the beginning of life. *Total Energy/Usable Energy measured under specific conditions from AOBOET 0.2C CC-CV - 4 -... -
Page 10: Exploded Views Of Battery
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 2.2 Exploded views of battery - 5 -... -
Page 11: Indicator And Ports
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 2.3 Indicator and ports 2.3.1 Indicator There are four LED indicators on the front of the battery to show its operating status. -
Page 12: Communication Interface Plat（Dvc-A
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Building up illustration of waterproof terminal 2.4 Communication interface plat（DVC-A voltage）... -
Page 13: Feature
Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 2.6 Feature The AOBOET Uhome Energy Storage battery has following features: - Energy storage unit: This battery is suit for photovoltaic system compatibility. - Battery management system (BMS): The battery built-in BMS monitors its operation and prevents the battery from operating outside design limitations. See Troubleshooting on Chapter 8. -
Page 14: Guidance For Disconnection Of Batteries During Shipment
3.3 The DC circuit of AOBOET Uhome-LFP 5.8kWh/LV battery has been disconnected before outgoing. The DC breaker recommended to be re-connected by skilled installer before use. -
Page 15: Installation Prerequisites
- Minimal dust and dirt in the area. - No corrosive gases present, including ammonia and acid vapor. The AOBOET Uhome battery is rated at IP65, so the battery could be installed outdoors as well as indoors. But if installed outdoors, do not allow the battery to be exposed to direct sunlight or moisture. -
Page 16: Installation Process
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 4.3 Installation process The battery should be installed according to the following flow chart. The detail installation process described in chapter 4 Install process. -
Page 17: Tools
Make sure that the cross-sectional area of charging cables is 25 to 35 mm NOTICE A bipolar breaker between AOBOET battery and inverter was required to install, and the breaker’s min. current should be over 150A or following with local regulations. - Page 18 Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au - The temperature of battery stored recommended in the range of -20° C to 45° C. - Do not expose to water The battery box should be upright as shown in the following figure and not stacked upside down when storing the battery box.
-
Page 19: Battery Installation
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 5. Battery Installation 5.1 Unpacking WARNING The battery is 64kg and it is too heavy for one to carry. Make sure that two or more persons are available. -
Page 20: Package Items
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 3. Take out the battery with hand hole in cardboard. - Page 21 Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Check item 1: Check the main breaker safety and stability; Check item 2: Check the battery voltage.
-
Page 22: Installation The Battery
ON position. If the breaker moves to any other positions by itself, do not use the battery. Contact AOBOET hot line or your distributor. 5. Press and hold the panel button for about 4... - Page 23 AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Note The symbol located on the back cover plate, and the earth wire between battery and inverter is not compulsive but recommended.
-
Page 24: Cable Connections
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 5. Fasten the mounting beam to battery. 6. Fixing the battery to bracket with screws. -
Page 25: Parallel Connection
Caution Uhome-LFP 5.8kWh/LV energy storage battery only could be used by parallel mode if two or more batteries installed. Note: Before two or more batteries installed in parallel, please check the voltage of each battery and make sure the voltage different less than 1.0V. -
Page 26: Configuration
If parallel connecting multiple batteries, please set the DIP switches as following: 6.1 Configure device WIFI The AOBOET Uhome battery has a built-in WIFI module for use with the AOBOET APP. 1. Remove the cover by pulling it up to expose the SD card board. The WIFI setting of battery should be as following 2. -
Page 27: Register Your Account
If the WIFI cannot be set or there is no WLAN accessible, the battery can still operate normally. 6.2 Register your account Note The AOBOET Uhome battery could be registered only one time. 1. Open the APP monitor of battery, select ‘Register’ option box. - 22 -... -
Page 28: Setting For Communication Interface
The AOBOET Uhome battery running is not associated with registration or not. 6.3 Setting for communication interface For Uhome-LFP 5.8kWh/LV Energy Storage battery, the limit of parallel number is 4. For each connecting mode, the DIP switch SW7 dial mode like following tables 6-1. -
Page 29: Settings For Can /485 Bus Pins
AOBO ENVIRONMENTAL NEW ENERGY (WUXI) CO., LTD. Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Table 6-1 The DIP switch SW7 selected for 1 battery connected with inverter... - Page 30 Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au Note The battery default protocol is CAN bus, if a inverter communication mode is RS485 or other protocol, please contact AOBOET hot line before installed the battery. - 25 -...
-
Page 31: Commissioning
4. Make sure that the Standby light is on. If it stays off, do not use the battery and contact AOBOET or your distributor. 5. Turn the inverter on, and wait for the start-up sequence to complete fully. -
Page 32: Troubleshooting
2. If the battery fault light on, pls check the Troubleshooting number in Homepage in your AOBOET APP, if the code is 0x1***, this problem would be recovered by itself. But if the code is 0x2*** or 0x3***, please contact the AOBOET after service hot line or your distributor for help. -
Page 33: Firmware Update
Add: Industrial Concentration zone, Sumiao village, Qianqiao street Huishan District, Wuxi city, Jiangsu province, China Tel: +86-510-83209451 Fax: +86-510-83203470 Web: http://www.aoboet.com.au E-mail: info@aoboet.com.au 9. Firmware Update It is possible to update the BMS firmware version manually via using a SD Memory card or via the WIFI monitor system App.
Need help?
Do you have a question about the Uhome-LFP 5.8kWh/LV and is the answer not in the manual?
Questions and answers