Table of Contents
Advertisement
Quick Links
GENERAL INSTALLATION INSTRUCTIONS
ASSEMBLY, INSTALLATION, AND OPERATION INSTRUCTIONS FOR
LD(30, 36, 48, 60, 72, 84, 96)-N for use with Natural Gas or
IMPORTANT
WARNING:
alteration, service or maintenance can cause
injury
or
property
instructions thoroughly before installation.
f i r e - p a r t s . c o m
For assistance or additional information, consult
your gas log dealer, qualified installer, service
agency or gas supplier.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
THIS GAS LOG SET MUST BE INSTALLED IN A FULLY VENTED
SOLID-FUEL BURNING FIREPLACE WITH A WORKING FLUE
The minimum permanent free opening of the fireplace chimney or chimney damper must be at least the minimum
Chimney Area shown below, based on a minimum chimney height of at least 8 feet. The area of the flue must not be less
than 1/10 the area of the fireplace opening. The flue must exhaust all products of combustion.
The chimney damper must be fixed in a manner to maintain permanent free opening as outlined above at all times. To
accomplish this, install the damper clamp (provided) on the edge of the damper blade to prevent its closing, drill a hole or
holes in the damper, or remove damper completely.
The minimum size of the fireplace in which the log set is to be installed must be as follows:
LOG SET SIZE
HEIGHT
30 INCH
36 INCH
42 INCH
48 INCH
54 INCH
60 INCH
66 INCH
72 INCH
84 INCH
96 INCH
"LD" Multi-Burner
Vented Gas Log Burner MODELS:
LD(30, 36, 48, 60)-P for use with Propane (LP) Gas
READ THESE INSTRUCTIONS CAREFULLY BEFORE
STARTING INSTALLATION OF LOG SET.
Improper
installation,
damage.
Read
IMPORTANT INFORMATION
CONSTRUCTED OF NON-COMBUSTIBLE MATERIAL.
MINIMUM FIREPLACE SIZE IN INCHES
DEPTH
REAR WIDTH
26
20
30
22
30
22
34
22
34
22
34
22
34
22
34
22
34
22
34
22
12028 E. Philadelphia St. Whittier , CA 90601 U.S.A.
gaslogs@rasmussen.biz
FOR YOUR SAFETY
WHAT TO DO IF YOU SMELL GAS
these
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
any phone in your building.
•
Immediately call your gas supplier from a
neighbors phone. Follow the gas suppliers
instructions.
•
If you cannot reach your gas supplier, call the
fire department.
FRONT WIDTH
30
38
36
44
42
50
.
48
58
54
64
60
70
66
76
72
82
84
94
96
106
(562) 696-8718
FAX (562) 698-3510
www.rasmussen.biz
GAS PIPING
½" i.d.
½" i.d.
½" i.d.
3/4" i.d.
3/4" i.d.
1" i.d.
1" i.d.
1" i.d.
1" i.d.
1" i.d.
LD-705
CHIMNEY AREA
12 INCH DIAMETER
14 INCH DIAMETER
14 INCH DIAMETER
16 INCH DIAMETER
16 INCH DIAMETER
18 INCH DIAMETER
18 INCH DIAMETER
.
20 INCH DIAMETER
.
20 INCH DIAMETER
.
20 INCH DIAMETER
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Rasmussen LD Series
Summary of Contents for Rasmussen LD Series
-
Page 1: For Your Safety
LD-705 "LD" Multi-Burner 12028 E. Philadelphia St. Whittier , CA 90601 U.S.A. (562) 696-8718 FAX (562) 698-3510 gaslogs@rasmussen.biz www.rasmussen.biz GENERAL INSTALLATION INSTRUCTIONS ASSEMBLY, INSTALLATION, AND OPERATION INSTRUCTIONS FOR Vented Gas Log Burner MODELS: LD(30, 36, 48, 60, 72, 84, 96)-N for use with Natural Gas or... - Page 2 LD-705 Glass doors must be wide open when burner is lighted to allow air for safe combustion, venting and cooling of valves. THIS BURNER IS FOR USE IN FULLY FUNCTIONING WOOD BURNING FIREPLACE WITH THE DAMPER WIDE OPEN. THE FLUE MUST VENT ALL PRODUCTS OF COMBUSTION. IMPORTANT INFORMATION (continued) A fireplace screen must be in place when the log set is in The gas log set and its individual shutoff valve must be...
- Page 3 LD-705 WARNING: not installed, operated and maintained in accordance with these instructions, this product could expose you to substances in fuel or from fuel combustion which are known to the State of California to cause cancer, birth defects or other reproductive harm. WARNING! CHECK FOR PROPER VENTING A properly sized, unobstructed chimney will normally vent all fumes and products of combustion.
- Page 4 LD-705 LD 48 and larger LD30 and LD36 Inlets (2) Gas Inlet Front Burner Front Burner Front Burner Adjust. Valve Adjust. Valve Adjust. Valve WARNING: A SAFETY PILOT MUST BE INSTALLED ON ALL UNITS DESIGNED OR CONVERTED TO BURN PROPANE/LP GAS Accessory Safety Pilot Lighting Kits: •...
- Page 5 LD-705 LD48 and larger STEP THREE: Filling Pans with Medium (NOTE: White Sand is used with Natural Gas, Black Volcanic Ash is used with Propane/LP Gas) 1. Completely cover BURNER TUBES and EMBER BOOSTER with the appropriate PAN MEDIUM. The WHITE SAND is for use with Natural Gas, the BLACK VOLCANIC ASH is for use with Propane/LP Gas.
- Page 6 LD-705 PH60/LD60 PH66/LD60 PH72/LD72 PH84/LD84 (photo not available) PH96/LD96 f i r e - p a r t s . c o m STEP FIVE: Lighting Instructions and Operation. IMPORTANT: CHIMNEY DAMPER MUST BE WIDE OPEN MANUAL MATCH LIGHTING. (For use only with Natural Gas Burner Models LD (30X, 36, 48, 60, 72, 4, 96)-N) 1.
- Page 7 LD-705 LIGHTING WITH ACCESSORY SAFETY PILOT LIGHTING KITS: • RPK3-F, RPK3-F10-F or EIS-N200 (For use with Natural Gas Burner Models) • RPK3-FA, RPK3-F10-FA or EIS-P200 (For use with Propane Gas Burner Models) 1. Light in accordance with specific instruction sheets provided with SAFETY PILOT LIGHTING KIT. CUSTOMER RESPONSIBILITY: THIS BURNER IS FOR USE FOR USE IN A FULLY FUNCTIONING WOOD BURNING FIREPLACE WITH THE DAMPER WIDE OPEN.
- Page 8 FROM STATE TO STATE. RASMUSSEN RASMUSSEN shall be held harmless from any and all claims by 12028 E. PHILADELPHIA STREET the buyer as a result of injury or damage to an ultimate user or WHITTIER CALIFORNIA 90601...
Need help?
Do you have a question about the LD Series and is the answer not in the manual?
Questions and answers