CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacturer. Discord used batteries according to the manufacturer's instructions. MVH-280FD/XNEW5...
10.10 TUNER AMP UNIT (EXTERNAL I/F PART) ..................32 10.11 TUNER AMP UNIT (POWER AMP IC PART)..................33 10.12 KEYBOARD UNIT ..........................34 11. PCB CONNECTION DIAGRAM ........................35 11.1 TUNER AMP UNIT ..........................35 11.2 KEYBOARD UNIT ..........................37 12. ELECTRICAL PARTS LIST ...........................39 MVH-280FD/XNEW5...
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. MVH-280FD/XNEW5...
See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted MVH-280FD/XNEW5...
1450.0 mA Current 215.0 mA (min 300 mA) B.REM / A.ANT Hiside-SW (min 500 mA) LED model IlM REG K/B Illumi (LED) Voltage 9.4 V 9.6 V Current 150 mA (max) Amp supply Power Amp TAS5414CTPHDRQ1 Voltage 19 V MVH-280FD/XNEW5...
In case of the above signal, the communication Source keys with Grille microcomputer may fail. operative If the time interval is not 300 msec, the oscillator may be defective. Source ON SYSPW <- H Pin 2 Completes power-on operation. (After that, proceed to each source operation) MVH-280FD/XNEW5...
– Connect the USB device directly to this There are no songs in the current list. unit using a USB cable. – Select a list that contains songs. NOT FOUND No related songs. – Transfer songs to the iPod. MVH-280FD/XNEW5...
Page 10
Then reconnect the device. CHECK DEVICE Device error message displayed in the Pandora application. – Check the connected device. PLEASE CREATE A STATION ON THE PHONE No station found. – Create a station in the Pandora application on your connected device. MVH-280FD/XNEW5...
If you find the symptoms above, check if the fuse is not blown. If you replace to a new fuse and the fuse is blown again (you cannot turn on the power of external product), check the power connection (Ground) of external product. MVH-280FD/XNEW5...
All light off SOURCE States 2 (No light) No light Button feeling Button 3 States 3 Light on (and ILM light) LCD States Status 1: All light up States 2: All light off Status 3: Refer to below draw. MVH-280FD/XNEW5...
On (lighting condition setting value of default of normal times) menu) Display update is stopped The screen gets still when entering this item. On (an initial value or On (state when setting value of default entering test mode) menu) MVH-280FD/XNEW5...
The display is continued until the power supply is turned OFF. If the power supply is turned ON again, the display is not changed. Since USB Updating is disabled, it is necessary to replace Tuner Amp Unit. Notes: Flash ROM in which software is written is NSP. MVH-280FD/XNEW5...
Slide the Tuner Amp Assy in the direction of the arrow and then remove the Tuner Amp Assy. Tuner Amp Assy Chassis Fig.2 - Removing the Tuner Amp Unit (Fig.3) Tuner Amp Unit Remove the three screws and then remove the Tuner Amp Unit. Fig.3 MVH-280FD/XNEW5...
Page 17
1. Attach the button from the front side of the panel. Fig.6 2. Attach the spring to the arm as shown in the figure. The bended tip of the spring is set to this side. Hitch the spring to the groove. Fig.7 MVH-280FD/XNEW5...
Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) MVH-280FD/XNEW5...
9.1 PACKING MVH-280FD/XNEW5 MVH-X285FD/XNES (1) PACKING SECTION PARTS LIST Mark No. Description Part No. Mark No. Description Part No. Warranty Card See Contrast table (2) Case Assy QXA3129 Owner’s Manual See Contrast table (2) Contain Box See Contrast table (2)
Page 20
See Contrast table (2) Screw See Contrast table (2) MBL CMPX CONN-CORD See Contrast table (2) Card Remote Control Unit QXE1047 (2) CONTRAST TABLE MVH-280FD/XNEW5 and MVH-X285FD/XNES are constructed the same except for the following: Mark Description MVH-280FD/XNEW5 MVH-X285FD/XNES Contain Box QHL3821 QHL3822...
10. SCHEMATIC DIAGRAM Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". MODEL A MVH-280FD/XNEW5 1/11 TUNER AMP UNIT (VEHICLE I/F PART) B MVH-X285FD/XNES BUP14.4V BUP_IN B.UP3 L101 CTH1620-A...
MODEL 3/11 TUNER AMP UNIT (SUPPLY FOR POWER PART) A MVH-280FD/XNEW5 B MVH-X285FD/XNES Power Amp VDD3.3V BUP Voltage Sense 5/11 VOLTSNS R352 D352 R353 4.7k DZ2J075M0 1/4W 3225 DAN217UM D351 DGND For study noise R309 R310 R311 D301 2.7k 1608...
MODEL 10/11 TUNER AMP UNIT (EXTERNAL I/F PART) A MVH-280FD/XNEW5 B MVH-X285FD/XNES VDD3.3V C1223 R1226 PLch CCG1192 Set back chart MUTE 2125 TP1206 10u/10 W.REM C1325 interference P1201 (CEK1286-) P1202 Steering W,REM B only *JA1202 FSMD075- CKB1109-A P1203 C1222 CCG1192...
MODEL 11/11 TUNER AMP UNIT (POWER AMP IC PART) A MVH-280FD/XNEW5 B MVH-X285FD/XNES Add for Audio C/M SDA_AMP C1309-1312 change to CCG1268(D/C) Add for supply C/M SCL_AMP OFFSET R1301 CTH1460-A 5/11 NM because no need 3216 MUTE_PW_IC AMP_CLIP R1302 R1309...
11. PCB CONNECTION DIAGRAM SIDE A W.REM FM/AM ANTENNA TUNER AMP UNIT JA1201 JA101 PREOUT POWER SUPPLY JA1202 JA851 L101 NOTE FOR PCB DIAGRAMS C102 C104 D101 1.The parts mounted on this PCB include all necessary parts for D102 C1327 C1325 Q1202 several destination.
The expression of the unit in this manual is shown by u instead of . Please do not make a mistake. Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. Q 451 (A,111,106) Transistor LTC143EUB A:MVH-280FD/XNEW5 Q 701 (A,85,39) Bipolar TR LSAR523UB B:MVH-X285FD/XNES Q 1201 (A,48,124) Transistor(B) EMD53...
Page 40
R 230 (B,139,38) RS1/16SS0R0J R 614 (A,115,58) RS1/16SS473J R 231 (B,139,36) RS1/16SS820J R 616 (A,105,38) RS1/16SS473J R 232 (B,136,40) RS1/16SS0R0J R 617 (A,121,64) RS1/16SS103J R 233 (B,135,37) RS1/16SS682J R 619 (A,119,63) RS1/16SS473J R 235 (B,144,54) RS1/16SS3903D R 622 (A,114,65) RS1/16SS473J MVH-280FD/XNEW5...
Page 41
R 856 (A,39,103) RS1/16SS472J R 1318 (A,67,98) RS1/16SS471J R 857 (A,37,104) RS1/16SS101J R 1319 (A,93,91) RS1/16SS103J R 1321 (B,66,99) RS1/16SS221J R 858 (A,37,103) RS1/16SS101J R 1325 (A,80,90) RS1/16SS103J R 860 (A,26,94) (A) RS1/16SS391J R 1327 (A,52,115) RS1/10SR0R0J (A,26,94) (B) RS1/16SS101J MVH-280FD/XNEW5...
Page 42
CKSSYB102K50 C 353 (B,121,61) 1 uF DCH1246 C 771 (B,88,78) 1 uF DCH1246 C 401 (A,145,25) CKSSYB104K16 C 772 (B,106,84) CKSSYB104K10 C 402 (A,146,21) CCG1393 C 775 (B,107,79) CKSSYB102K50 C 403 (B,130,19) CCSRCH101J50 C 777 (B,102,80) 1 uF DCH1246 MVH-280FD/XNEW5...
Page 43
(A,57,3) RED LED FC-1608SXK630D08 D 1975 (A,111,4) RED LED FC-1608SXK630D08 C 1306 (B,71,118) CCSRCH471J50 C 1307 (B,69,118) CCSRCH471J50 D 1976 (A,93,4) RED LED FC-1608SXK630D08 C 1308 (B,65,115) CCSRCH471J50 D 1977 (A,89,4) RED LED FC-1608SXK630D08 C 1309 (A,110,128) 0.47 uF CCG1268 MVH-280FD/XNEW5...
Page 44
R 1982 (B,86,10) RS1/10SR152J R 1984 (B,63,14) RS1/10SR102J R 1986 (B,137,18) RS1/10SR102J R 1988 (B,49,23) RS1/10SR102J R 1996 (B,59,7) RS1/10SR0R0J CAPACITORS C 1806 (B,66,22) CKSRYB104K16 C 1807 (B,64,22) CKSRYB105K10 C 1912 (B,143,21) CKSRYB102K50 C 1941 (B,135,26) 10 uF CCG1192 MVH-280FD/XNEW5...