Simplicity Landlord DLX Series Dealer Setup & Adjustment Instructions Manual page 24

Landlord / 1700 / 2700 Series
Expansion Chamber
Access Plug
Figure 43. Seat Deck Access Plug
Change Transmission Oil, Internal
Filter, & Hydraulic System Filter
Service Interval: After 50 Hrs, Then Every 250 Hrs
The oil should also be changed whenever it has become
discolored from overheating or contamination.
Do not allow dirt, water, or other debris to
enter the expansion chamber or
transmission. Even a small amount of dirt
can damage the transmission
1. Place a drain pan under the transmission and remove
the two 14mm drain plugs (A, Figure 45).
2. Remove the differential fill cap (B, Figure 44).
3. Remove the plastic plug (A, Figure 46).
4. Remove and replace the hydraulic system filter (A,
Figure 44). Thread the new filter onto the filter base
and tighten 1/2-3/4 turns past finger tight.
5. Remove and replace the internal transmission filter
(B, Figure 46).
6. Reinstall the plastic plug (A, Figure 46) and the two
14mm drain plugs (A, Figure 45).
7. Using a long funnel, add 2 quarts of oil to the differen-
tial fill (the differential fill cap B, Figure 44 should have
been removed earlier).
8. Reinstall the differential fill cap (B, Figure 44).
9. Remove the expansion chamber access plug (Figure
43) and expansion chamber cover. Add 2 quarts of
oil to the expansion chamber (D, Figure 44) a few
ounces at a time.
10. Reinstall the expansion chamber cover (D, Figure 44).
11. Test run the tractor for 10 minutes. Drive forward and
backward; raise and lower the attachment lift several
times.
12. Recheck the transmission oil level with the cylinder
extended. There should be 1" of oil visible in the
clear plastic tube (C, Figure 44).
TP 300-2226-02-LL-SMA
A
B
Figure 44. Hydraulic System Oil Filter
A. Hydraulic System Filter C. Clear Tube
B. Differential Fill Cap
A
Figure 45. Transmission Drain Plugs
A. 14mm Drain Plugs
Figure 46. Internal Transmission Filter Service
A. Plastic Plug
22
D
D. Expansion Chamber
B
A
B. Internal Filter
1/2001
C