2. Assembly 2.1 Earth works Congratulations on purchasing your the pool should preferably be positioned Gardipool swimming pool. Your pool is in a sunny place, away from any trees manufactured from quality North-Euro- whose leaves could fall into the pool. pean pressure impregnated pinewood.
Page 3
QUARTOO 300 x 500 AbOvE GROuNd INGROuNd Protective felt gravel Metal supports Metal supports ground Concrete C25/30 Concrete C25/30 Metal mesh anti-bacterial felt (150x150x6x6) ground sand drainage ± 20 cm ± 20 cm Plastic foil CONCRETE FLOOR Concrete C25/30 Metal supports IPE 120 IPE 120 IPE 120 IPE 120...
MaNual - quartoo 2.2 Wooden structure 2.2.1 General the wooden structure of the pool It is necessary to use the correct planks the ends of the planks are treated in consists of swallow’s tail planks, which in the correct order. such a way that they form a swallow’s may or may not have received additional tail joint with each other.
Page 8
MaNual - quartoo QUARTOO 300 x 500 4x25mm EXO 4x25mm EXO 4x25mm EXO TIP: rough-bore the hardwood coverplanks. 1.8x30mm 1.8x30mm 1.8x30mm REMARK: Do not yet place the supporting plank there, where the stainless steel internal steps will come (see further on: installation of the stainless steel steps). 5x50mm 4.5x50mm EXO 4.5x50mm EXO...
2.3 Interior finish In order to attach the lining, the hung-profile on bare feet and using a plastic squee- is screwed to the inside of the pool at 20cm gee, remove the folds in the liner and intervals. (stainless steel screws 4x30mm) press the liner well into the corners of Ensure walls are dust-free to avoid ir- the pool.
MaNual - quartoo 2.4 Technical installation 2.4.1 Parts the most important parts of the filter unit Follow the instructions in the enclosed are: filter, pump, 6-way valve, lid, power filter installation manual. supply cable and connecting system. the pump must never be placed higher the monobloc filter is the appliance that than 4m above the filter inlet and should takes care of the water treatment.
2.4.2 Monobloc Place the installation in the final position; Make sure that the plastic protection bear in mind that the 6-way valve must (funnel) is placed on top of the filter to remain accessible. prevent sand/gravel from falling into the _____ mouthpiece of the branch pipe.
MaNual - quartoo 2.4.3 Connections the pump and filter are interlinked by a semi-flexible tube. _____ Screw the connector pieces into the filter and the pump. Slide the fittings and the inserts over both ends of the hose. Connect the fittings to the connector pieces, and then tighten the fittings.
Page 13
Before you join the connectors, you must after installation, the filter needs to be screw the PVC elbow (7) onto the return backwashed automatically; in this pro- opening. Do this as follows. Screw the cess the filter sand is rinsed to prevent PVC elbow carefully onto the return piece impurities from entering the pool.
MaNual - quartoo 2.4.4 Functioning NEVEr altEr tHE PoSItIoN oF tHE ValVE WHIlE tHE Motor IS ruNNING FIrSt rEMoVE tHE PluG NEVEr DISMaNtlE tHE ValVE WHIlE tHE FIltEr IS StIll uNDEr PrESSurE. the 6-way valve controls the 6 functions of the filter: backwash, re-circulation, rinse, filtration, waste, closed.
2.5 Finishing touches Function 5: RECIRCuLATION With the recirculation position, the water is returned to the pool via the skimmer, pump and valve. Choose this position for instance when you dissolve chlorine tablets in the skimmer and do not want the chlorinated water to circulate through the filter sand.
Page 16
MaNual - quartoo Stainless steel steps the stainless steel interior steps are assembled according to the instructions and are attached on top of the border. Not suitable in salted water ! 3) Place the two holders and screw 5) Place the metal covering plates over 1) Define the place of the steps holders them with the screws which were also the holders and install the steps.
3. Accessories 3.4 Electrical box 3.3 Technical housing 3.1 Summer tarpaulin a summer tarpaulin can be placed across the pool. Sunrays can increase the water temperature. the tarpaulin is simply placed on the water; when using the pool the tarpaulin is removed and turned over to dry. It is best to roll the tarpaulin up to prevent tears.
MaNual - quartoo 3.7 Felt after fitting the liner, and when the pool is filled to just below this hole, push the connector piece through and trace the contours in order to cut the liner correctly. Fit the lamp according to the instructions provided, and guide the cable outside via the connector piece.
4. Safety instructions 4.1 General TAKE NOTE the borders are not intended to run on nor to dive from. the steps are only TECHNICAL INSTALLATION intended for use to step in and out of the Do not activate the appliance if the air pool.
MaNual - quartoo 5. Maintenance 5.3 Technical installation 5.1 Wooden structure Check the pump once a year to ensure In order to guarantee a long lifetime good performance. for your wood, it can be treated with Normally no maintenance is required for a special stain.
6. Guarantee 6.3. Filtre / pompe 6.6. In general 6.1. Wooden structure two years’ guarantee on the sealing of our guarantee is limited to the delivery • ten years’ guarantee against insect the filtration kit. of the replacement parts for defective infestations and bacterial attacks on the items. In no case whatsoever, it implies vertical wooden structure (autoclave are not covered by this guarantee : a demand of damages or indemnity for...