Table of Contents
Advertisement
Quick Links
Advertisement
Chapters
Table of Contents
Related Manuals for Airstream Basecamp 2020
Summary of Contents for Airstream Basecamp 2020
- Page 1 2020 Basecamp Owner ’s Manual...
- Page 2 If and when new materials and production techniques are developed that can improve the quality of its product, or material substitutions are necessary due to availability, Airstream reserves the right to make such changes.
-
Page 3: Table Of Contents
TABLE OF CONTENTS INTRODUCTION ... . 1-1 TOWING ....7-1 SAFETY ....2-1 Tow Vehicle . - Page 4 NOTES 2020 Basecamp...
-
Page 5: Introduction
However, should you ever feel equipment. that you may be in need of assistance, please consult your Airstream dealer for advice on service that may be NOTE required. A note is used to address practices not related A brief explanation of the operation of the appliances to personal injury. - Page 6 Introduction NOTES 2020 Basecamp...
-
Page 7: Safety
Section 2 SAFETY SAFETY � � � � � � � � � � � � � � � � � 2-1 Do Not Smoke � � � � � � � � � � � � 2-3 SAFETY PRECAUTIONS � � � � � � � � � 2-2 Medical Advice �... -
Page 8: Safety Precautions
Safety Safety Precautions Appliances and Equipment The appliances and equipment (stove, hot water Many things can be construed as safety related, but heater, furnace, etc�) typically can be operated on the most important is your common sense� If you are LP gas. -
Page 9: Alarms And Detectors
WARNING Airstream strongly suggests you take measures to properly ventilate your trailer on a regular basis� If you Smoke alarms have a limited life. The unit should have any questions with respect to proper ventilation... -
Page 10: Carbon Monoxide Detector
The alarm will only Carbon Monoxide Detector user’s manual, please indicate the presence of CO gas at the sensor. contact the manufacturer, your dealer, or Airstream Important Safety Precautions Customer Service� • Carbon Monoxide is produced by the incomplete... -
Page 11: Symptoms Of Carbon Monoxide Poisoning
Safety The following conditions can result in potentially Liquid Propane Gas (LPG) Detector dangerous CO situations 1� Excessive spillage or reverse-venting of fuel- burning appliances caused by outdoor conditions, such as: • Wind direction and/or velocity, including high gusts of wind� •... -
Page 12: Detector Test
Safety Detector Test Fire Extinguisher The Test/Reset button is used to verify proper alarm function� Executing the test function sounds the alarm and lights up the red LED� The test will sound the alarm twice, with four beeps in 1 second, followed by 5 seconds of silence�... -
Page 13: General Information
Under This Limited Warranty � � � � 3-4 Tips To Controlling Condensation � � 3-9 Airstream Limited Warranty Excludes � � � 3-4 Molds � � � � � � � � � � � � � � � � 3-9 Normal Wear �... -
Page 14: Limited Warranty Policy
General Information Limited Warranty Policy of the Basecamp excluded from coverage� There is no warranty of any nature made by Airstream beyond This Limited Warranty Covers that contained in this limited warranty� No person has authority to enlarge, amend or modify this limited (i) The first retail owner and any subsequent owners (ii) warranty�... -
Page 15: What Is Not Covered
Unless prohibited by state law, repairs will not extend by Airstream, or any defects or damage caused by the time when you must commence a breach of such items;... -
Page 16: Obtaining Warranty Service
Jackson Center, Ohio 45334-0629 Lack of customer care and/or improper maintenance Attention: Owner Relations Department will result in early failure for which Airstream cannot be held responsible� Airstream may direct you to an authorized Airstream dealer, or may request that you bring your Basecamp to the Airstream factory in Jackson Center, Ohio for repairs�... -
Page 17: Service
At that time, a specified list of performance checks Conditions of this nature, although they may be normal on your trailer equipment will be conducted, and for the area, are beyond Airstream’s control and any deficiencies you have experienced since taking become the responsibility of the owner�... -
Page 18: Camping
2� Turn off gas at LP tanks� Safety Administration (NHTSA), in addition to notifying 3� Retract stabilizing jacks� Airstream, Inc� 4� Check hitch for proper attachment� If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists 5�... -
Page 19: Motoring Essentials
10� Wear easy wash, drip-dry traveling clothes� All you need to do to enjoy the self-contained luxury 11� Do not make your vacation trips a mileage of your Airstream is to turn on the LPG and light any marathon� Stop and relax frequently� appliance pilot lights�... -
Page 20: Extended Stay
General Information Extended Stay WARNING Making a long trip in your Airstream is not very different from making a weekend excursion� Since everything Whenever the trailer must be lifted with a jack, as you need is right at hand, you are at home wherever when changing a tire, always place the lifting jack you go�... -
Page 21: Tips To Controlling Condensation
General Information Tips To Controlling Condensation Molds Allow excess moisture to escape to the outside when: Molds are microscopic organisms that naturally occur in virtually every environment, indoors and • Bathing, washing dishes, hair drying, etc out� Outdoors, mold growth is important in the •... -
Page 22: Waste Water System
General Information Waste Water System Winter Traveling The main parts of the waste water system are the Traveling in sub-freezing temperatures will require toilet, combination Black/Gray tank, and tank dump certain precautions to protect the plumbing system valve (See Section 8 - Maintenance for dump valve and your personal belongings from being damaged by information). -
Page 23: Safety
General Information Safety As always, safety should be a top priority� Ensure that you, and everyone traveling with you, can operate the main and rear door rapidly, without light� Contemplate other means of escape in case the designated exit is blocked�... - Page 24 General Information NOTES 3-12 2020 Basecamp...
-
Page 25: Floor Plans And Specifications
Section 4 FLOOR PLANS AND SPECIFICATIONS FLOOR PLANS AND SPECIFICATIONS � � � � � � � � � � � � � � � � � � � � � � � � � � � � � 4-1 FLOOR PLANS �... -
Page 26: Floor Plans
Floor Plans And Specifications Floor Plans Basecamp Specifications Specification Chart NOTE All weights listed in the Specification Chart are checked and updated throughout the model year. Your production trailer may vary from weights listed. Model Basecamp Basecamp Length - Exterior 16’... - Page 27 Floor Plans And Specifications Measuring Hitch Ball Height The UBW and NCC weights listed in the Specification Chart are for the base unit with LP and batteries The proper height will vary according to the weight you included. carry and the tires you use. However, checking the Gross Vehicular Weight Rating (GVWR) is the height on your trailer is relatively easy: maximum permissible weight of this trailer when fully...
- Page 28 Floor Plans And Specifications NOTES 2020 Basecamp...
-
Page 29: Interior
Section 5 INTERIOR INTERIOR � � � � � � � � � � � � � � � � 5-1 Toilet � � � � � � � � � � � � � � � � 5-6 GENERAL INFORMATION AND CLEANING � 5-3 Deodorizers �... - Page 30 Interior Section 5 Interior APPLIANCES � � � � � � � � � � � � �5-11 Microwave Ovens � � � � � � � � � � �5-14 Maintenance � � � � � � � � � � � � �5-11 Range �...
-
Page 31: General Information And Cleaning
General Information and Cleaning Interior Woodwork The finish on the interior woodwork is a high quality The interior of all Airstream trailers has been designed furniture finish and should be treated as any fine for comfort, convenience, durability, and appearance�... -
Page 32: Dinette Tables
Interior Dinette Tables Lounge The dinette seats and tables have been designed to convert into a bed� The dinette tables will need to be lowered into position by installing a set of smaller legs which are located on the underside of the curbside dinette seat hatch�... -
Page 33: Plumbing
Interior Plumbing Faucets Galley Faucet Water System (Self-Contained) Fill the water tank by opening the exterior access door and removing the screw cap� A potable water hose can now be inserted� It is a good idea to let the water run through the hose for a short time to flush it out. -
Page 34: Faucet Cleaning And Care
Toilet All that is needed to clean your faucet is a soft, damp The RV toilet in your Airstream is a design that has cloth� Airstream does not recommend the use of scour been used for many years� One pedal is used to open pads, cleansers, or chemicals�... -
Page 35: Electrical
Battery Disconnect Switch Battery/12-Volt System Information The major portion of electrical power in your Airstream is 12-volt� The 12-volt current powers all gas appliances for controls and/or ignition as well as lighting� An exception would be the range which has its own ignition source�... -
Page 36: Converter
Interior Converter 12-Volt Power Circuits The current in the converter system is 12 volts direct current (12 VDC) negative grounded� Power sources that supply 12 VDC current to the system are as follows: • Main charge line from tow vehicle •... -
Page 37: 120-Volt Ac Panel Board
Amp rating as panel� The circuit breaker panel for the 120-volt system originally supplied by Airstream� Replacing it with either is located in the converter� In the event of a failure of a... -
Page 38: Converter
Interior Ground Fault Circuit Interrupter (GFCI) The 120-volt electrical system provides power to operate the air conditioner, converter, and 120-volt Most states require trailers with exterior 120-volt receptacles for portable appliances� The power is receptacles and receptacles close to a water sources, carded through the 120-volt city power flexible cord to such as a faucet, to have a ground fault-circuit the 120-volt distribution panel, and then is distributed to... -
Page 39: Appliances
Appliances at the LPG tanks before refueling the tow vehicle or entering a refueling station. All appliances are delivered to Airstream Inc� with in- depth owner’s manuals� Those manuals are included in WARNING the delivery case supplied by your dealer� The manuals... -
Page 40: Air Conditioner
Interior Air Conditioner Exhaust Fans The roof A/C used on Airstream’s Basecamp has the lowest profile of any A/C on the market today. Coupled with an industry exclusive fiberglass basepan this lower profile and lighter weight means less drag and improved fuel efficiency. -
Page 41: Cleaning Instructions
• The furnace can be operated even if the tank hasn’t NOTE been filled If warranty service is required, use only a • Water, gas and warm air duct connections at the side service location recommended by the furnace make servicing easier manufacturer or your Airstream dealer. 5-13 2020 Basecamp... -
Page 42: Microwave Ovens
Interior Truma Combi CP Plus Control Panel Refrigerator Your Basecamp is equipped with Nova Kool 2-Way (12V, 120V) refrigerator� Review all refrigerator literature supplied in your owner’s packet or stored in the refrigerator prior to operating� Operation The refrigerator operates on 12-volt current from the battery or on 120V shore power�... -
Page 43: Solar System
LEDs will be dimly be shown� If the same button is pressed twice, the lit� Manuals on their use are included with the Airstream display will hold on that tank and continue to show owner’s packet�... -
Page 44: To Read The Battery Voltage
Interior To Program the LED Brightness 3� To continuously display a reading, press and release the desired button, and then press the 1� The display needs to enter the brightness same button a second time� When the button is programming mode� To do this, press and hold released, the display will be on hold mode, which the BATT button;... -
Page 45: Exterior
Section 6 EXTERIOR EXTERIOR � � � � � � � � � � � � � � � � 6-1 Receptacle Outlets � � � � � � � � � � 6-5 CLEANING � � � � � � � � � � � � � � 6-2 Exterior Shower �... -
Page 46: Cleaning
If a substance is found on the coating that cannot be removed by normal washing procedures, Airstream recommends using DX 330 Acryli-Clean, made by PPG Industries� Follow all directions and warnings on the product container�... -
Page 47: General Information And Operation
Exterior General Information and Operation Front End Protection The front end of the trailer exterior shell is equipped Step with a 3-M film protective covering the lower corner To operate the step, lift up on the front of the step and wraps. -
Page 48: Rear And Curbside Tents
The keder cord should fit completely into Your Airstream Basecamp can be equipped with rear the rail, with little or no excess hanging out of either and curbside tents with a versatile design that allows end�... -
Page 49: Receptacle Outlets
NOTE the air is expelled from the trailer system� If the water Use only power cords recommended by Airstream. heater is empty, it will take some time before all the air is expelled and a steady flow of water occurs at the Many campgrounds provide less than 30 amp service, faucet. -
Page 50: Liquid Petroleum Gas (Lpg)
Exterior Liquid Petroleum Gas (LPG) Hitch/Coupler Fill Valve The LPG tanks are equipped with fill valve connections RV Type I Acme� The large, green, nylon swivel nut is a right-hand thread and is designed for hand operation only� The valve features an internal spring-loaded module that will not allow gas to flow from the cylinder until a positive seal has been made at the connection�... -
Page 51: Automatic Gas Regulator
Exterior Automatic Gas Regulator Bypass flow is extremely important in the proper operation of this connection. The flow-limiting device may activate if the cylinder valve is opened quickly� When all appliances are off, the bypass flow allows the pressure downstream from the flow-limiting device to equalize. -
Page 52: Lpg Tanks
Exterior LPG Tanks WARNING The following procedure outlines the proper method of removing and installing LPG bottles: The LPG tanks are securely mounted on the front A- frame of your trailer. If these tanks must be 1� Unhook the two shock cords from both sides of the removed for service or replacement, it is important tank cover to open the top for access�... -
Page 53: Basic Rules For Lpg Safety
Exterior Basic Rules For LPG Safety WARNING A warning label is displayed in the cooking area reminding you to provide an adequate supply of fresh Do not bring or store LPG tanks, gasoline, or other air for combustion� The amount of oxygen supply in a flammable liquids inside the vehicle because a fire trailer is limited due to its compact design�... - Page 54 Exterior NOTES 6-10 2020 Basecamp...
-
Page 55: Towing
Section 7 TOWING TOWING � � � � � � � � � � � � � � � � � 7-1 Cooling System Overload � � � � � � � � 7-5 TOW VEHICLE � � � � � � � � � � � � � 7-2 Downhill and Non-level Driving �... -
Page 56: Tow Vehicle
Towing Tow Vehicle Brakes When buying a new vehicle to tow your trailer, we All trailers are equipped with Dexter Nev-R-Adjust suggest including towing options offered by most tow brakes� Please follow all maintenance procedures vehicle manufacturers� These include such things as a in the Dexter user’s manual provided in the owner’s heavy-duty alternator and radiator, heavy-duty springs packet�... -
Page 57: Breakaway Switch
A full load of water equals XXX kg or XXX lbs of cargo @ 1 kg/L (8.3 lb/gal) WARNING Airstream weighs the trailer as finished to arrive at the Do not use the breakaway switch as a parking trailer’s weight� That number is subtracted from the brake. -
Page 58: Weighing Your Trailer
Towing Weighing Your Trailer Place a piece of wood of approximately the same thickness as the bathroom scales on the ground in The illustration below shows how to weigh the trailer on line with the trailer hitch jack as shown� It should be so scales�... -
Page 59: Towing Tips And Information
Proceed on the highway We want every Airstream owner to be a safe and a little slower; resume normal driving after 10 minutes� courteous driver� A few hours of towing practice in a... -
Page 60: Downhill And Non-Level Driving
Towing Downhill and Non-level Driving Passing When going downhill in dry weather, downshift so On freeways or expressways, pick the lane you want engine compression will slow the whole rig down� Take and try to stay in it� Always maintain plenty of space dips and depressions in the road slowly and do not between you and the car ahead, at least the length of resume normal driving speeds until you are sure that... -
Page 61: Controlling Sway Or Fishtailing
Although Airstream has not intruded into the hitch Tongue weight manufacturer’s field of expertise and performed formal Refer to Weighing Your Trailer and Equalizing Hitch testing, we find the vast majority of Airstream owners Load Distribution in this section� purchase sway-control devices� Driving... - Page 62 Towing NOTES 2020 Basecamp...
-
Page 63: Maintenance
Section 8 MAINTENANCE MAINTENANCE � � � � � � � � � � � � � � 8-1 WATER PUMP � � � � � � � � � � � � �8-11 MAINTENANCE SCHEDULE � � � � � � � 8-2 Water Pump Access Locations �... -
Page 64: Maintenance Schedule
Maintenance Maintenance Schedule Every 5,000 miles or 90 days Hitch Ball Latch Lubricate with non-detergent WARNING motor oil. Hitch Ball Lubricate with hitch ball lube or Failure to maintain your trailer can cause pre- wheel bearing grease. mature and unexpected parts breakage and/or Roof Vent Elevator Lubricate with light household erratic operation that may be hazardous. -
Page 65: Suggested Maintenance And Replacement Parts
Maintenance Suggested Maintenance and Replacement Parts (Part numbers listed are Airstream part numbers and can be ordered by calling a certified Airstream dealer.) WARNING Always replace the bulb or light fixture with the correct bulb for that light or matching fixture. Failure to heed this warning could cause fire, property damage, personal injury, or death. -
Page 66: Exterior Care
The following exterior care products are recommended (PN - 365330-03 [10 oz tube-Gray]) - Use anywhere a by Airstream. Read and follow label directions. Exterior thicker bead of Gray sealant is required. sealant should be checked and resealed once a year. -
Page 67: Tires
Most Airstream dealers cannot make Never attempt to change any tire on the trailer adjustments to tires. An Airstream, or tire dealer that without securely chocking the trailer’s remaining handles that particular brand, must do this. If you wheels. -
Page 68: Tire Load And Inflation Information
Maintenance Tire Load and Inflation Information How Overloading Affects Your Tires Tire pressure is what enables your trailer tire to Maintaining proper tire inflation pressure is essential for support loads, thus, overloading can have serious both tire safety and performance. consequences. -
Page 69: Tire Inspection And Storage
Maintenance 6� Never drive on smooth tires. Tires should be Most trailers are towed at or near maximum loads removed when 2/32 in. of tread depth remains. In during hot weather and then left idle for months. In most states it is illegal to drive with less than 2/32 normal use, oils in the tire come to the surface during in. -
Page 70: Lug Nut Torquing
Airstream recommends driving on the spare tire at service, these extra loads can cause stress, which can a maximum of 50 MPH for up to 50 miles. -
Page 71: Rubber Torsion Axle Alignment Specifications
Maintenance The trailer axle(s) is bent upward in the middle. This 16� While rotating the wheel, tighten the spindle nut bend is normal and is how the camber is obtained. with a 12” wrench until there is a slight tension. Also, toe-in is built into the axle by very slight bends in Then back off one notch and install cotter pin. -
Page 72: Battery (Lead Acid)
Battery (Lead Acid) Battery Cleaning Battery maintenance is an important issue. Maintain a Your Airstream trailer is factory equipped with an clean battery top and check terminals and cables for Interstate battery (SRM-24). When solar panel tightness and cleanliness. A dirty battery will dissipate equipped an AGM GPL-24 battery will be installed. -
Page 73: Water Pump
Maintenance Water Pump Fresh Water Tank Draining The freshwater tank drain valve on all units is located Water Pump Access Locations under the trailer on the freshwater tank pan. A white The Basecamp has the pump and filter located under plastic petcock is located on the side of the pan for the roadside dinette seat. -
Page 74: Black/Gray Water Tank And Draining
Maintenance Sanitizing Potable water systems require periodic maintenance to deliver a consistent flow of fresh water. Depending on use and the environment the system is subject to, sanitizing is recommended prior to storing and before using the water system after a period of storage. Systems with new components, or ones that have been subjected to contamination should also be disinfected as follows:... -
Page 75: Winterizing And Storage
Maintenance Winterizing and Storage 8� Lower the front of the trailer as far as the jack will allow until water ceases to drain, then crank When storing your trailer for short or long periods, the jack up as high as it will go and allow any use the same precautions as you would in your own remaining water to drain out. -
Page 76: Exterior Doors
Close the water inlet * When using the stabilizers (for eliminating movement- and outlet valves. The valves are located under the not leveling) on your Airstream be sure to check the fit roadside dinette seat. of your doors before and after extending stabilizers. -
Page 77: Electrical Diagrams
Maintenance Electrical Diagrams 12-Volt Diagrams 8-15 2020 Basecamp... -
Page 78: 120-Volt/30- Amp Diagram
Maintenance 120-Volt/30- Amp Diagram The following electrical diagrams are representative of the National Electric Code (NEC) and Canadian Standards Association (CSA). All circuits are NEC with the exception of CSA circuits as specified in each respective table. Circuit 5, 15 Amp (GFCI) Main Circuit, 30 Amp Circuit 1, 20 Amp Dinette Receptacle... -
Page 79: Standard 30 Amp Circuit Breaker Layout
Maintenance Standard 30 Amp Circuit Breaker Layout • Circuit 5 - 15 Amp GFI - Galley, Refrigerator, CS End Table, Outside, Dinette Receptacles • Circuit 4 - 20 Amp GFI - Furnace/Water Heater System • Circuit 3 - 15 Amp - Microwave Receptacle •... - Page 80 The following diagram depicts the way Airstream wires bar to an area just behind the Seelevel Monitor display. the solar system on factory-installed units and is the The best way to reach the Cat 5 cable is to remove recommended wiring for use of the pre-wire system.
-
Page 81: Fresh Water Layout
Maintenance Fresh Water Layout 8-19 2020 Basecamp... -
Page 82: Faqs And Answers
AGM GPL-24 battery is installed. Appliances 4. Do you recommend using a surge protector 1. I am planning for a trip in my Airstream. How when plugged into shore power? should I get the refrigerator cooled down? Answer: Your Airstream is breaker protected. However,... - Page 83 Answer: An O-ring is placed on the threaded end of the 4. Can I use a nylon cover for my Airstream? pedestal legs to prevent overtightening when installing. Answer: Airstream does not recommend using any type Make sure the O-ring is in place and in good condition of cover.
- Page 84 Maintenance NOTES 8-22 2020 Basecamp...
- Page 85 Index Air Conditioner 5-12 Effects Of Prolonged Occupancy 3-8 Alarms 2-3 Electrical 5-7 Appliances 2-2, 5-11 Electrical, 110-Volt, City Power 5-9 Axle 6-5, Electrical Diagrams 8-15 Axles 8-8 Equalizing Hitch Load Distribution 7-5 Exhaust Fans 5-12 Exterior Shower 6-5 Backing Up 7-6 Battery 8-10 Battery Disconnect Switch 5-7 FAQs and Answers 8-20...
- Page 86 Index Maintenance Schedule 8-2 Tanks Microwave Ovens 5-14 Black/Gray Water Tank Dumping 8-12 Molds 3-9 Draining, Dumping, Cleaning 8-11 Monitor Panel 5-15 Drain System Cleaning 8-12 Fresh Water Tank and Draining 8-11 Tents 6-4 Thermostat 5-11 Nev-R-Lube Bearings 6-5 Tires 8-5 Toilet 5-6 Towing 2-2 Overnight Stop 3-7...
- Page 88 428 West Pike Street P.O. Box 629 Jackson Center, OH. 45334-0629 Phone: (937) 596-6111 Fax: (937) 596-6539 www.airstream.com...
Need help?
Do you have a question about the Basecamp 2020 and is the answer not in the manual?
Questions and answers