7.1-channel a/v receiver featuring hdmi 1080p video processing (v.1.4 with 3d, arc), 7.1 surround sound, works with iphone certification and bluetooth capability (2 pages)
Summary of Contents for Pioneer VSX-1128-K
Page 1
ORDER NO. RRV4420 VSX-1128-K AV Receiver VSX-1128-K VSX-1123-K VSX-70 VSX-1028-K THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model Type Power Requirement Remarks VSX-1128-K CUXE AC 120 V VSX-1123-K CUXESM AC 120 V VSX-70 CUXE AC 120 V...
PIONEER Service Manual. A subscription to, or additional copies of, Also test with plug reversed Earth PIONEER Service Manual may be obtained at a nominal (Using AC adapter ground charge from PIONEER. plug as required)
IC with heat-pad IC809 5V SW IC —————— IC with heat-pad FHDMI Assy IC1307 5V SW Power Supply IC —————— IC with heat-pad 1.3 SERVICE NOTICE • Discharging For more detail, please refer to "7. DISASSEMBLY - 1. Discharging". VSX-1128-K...
2. SPECIFICATIONS VSX-1128-K, VSX-1028-K VSX-1123-K Amplifier section Amplifier section Continuous average power output of 90 watts* per channel, min., at Continuous average power output of 90 watts* per channel, min., at 8 ohms, from 20 Hz to 20 000 Hz 8 ohms, from 20 Hz to 20 000 Hz with no more than 0.08 %** total harmonic distortion.
Page 7
IR signal..........High Active (High Level: 2.0 V) Quick start guide 12 V Trigger terminal........ø 3.5 Mini-jack (MONO) (VSX-1128-K, VSX-1028-K: 5707000007780-IL) 12 V Trigger output type........12 V, Total 150 mA (VSX-1123-K: 5707000007770-IL) RS-232C cable type ....... 9-pin, cross type, female-female...
3.3 PCB LOCATIONS WG-B ASSY BT ASSY AUDIO ASSY VIDEO ASSY BTCNT ASSY MAIN ASSY OPTCO ASSY D-MAIN ASSY CPU ASSY SMPS ASSY BRI-1 ASSY BRI-2 ASSY AMP7 ASSY GUI-L ASSY GUI-R ASSY HPMIC ASSY FHDMI ASSY INSEL ASSY FRONT ASSY VSX-1128-K...
Page 10
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. LIST OF ASSEMBLIES Mark Symbol and Description VSX-1128-K/CUXE VSX-1123-K/CUXESM VSX-70/CUXE VSX-1028-K/CUXE 1..PCB TTL ASSY MAIN...
ANALOG COMPONENT Video Decoder Analog Devices "ADV7181C" BT ASSY 24MHz 36.864MHz 25 MHz Media Processor BRIDGE CO Gate Array LAN PHY "DM860A" SMCS SEIKO EPSON ETHERNET "PE7008A" "LAN8720A" SDRAM-166 iPod Authentication 256Mb(32Mx8) APPLE SDRAM-166 (RENESAS) 256Mb(32Mx8) "337S3959" FLASH ROM VSX-1128-K...
Page 17
64Mb 256Mb COMPONENT - Pr ANALOG VIDEO BLOCK 22.5792MHz 24.576MHz 20 MHz 1st DSP Array DA808HS EPSON 08A" SDRAM-166 SeriFlash D-MAIN ASSY 16Mb 64Mb(8Mx16) Other ASSY TMDS DIGITAL VIDEO POWER SUPPLY BLOCK Diagram (DCDC,LDO) ANALOG VIDEO CLOCK DIGITAL AUDIO VSX-1128-K...
CPU Assy? replace the CPU Assy. Replace IC302 or Check Reset IC (IC302) replace the CPU Assy. on the CPU Assy. Replace the D-MAIN Assy. 4.4 V 4.2 V Pin 2 3 ms Pin 1 >1 ms Vout VSX-1128-K...
Page 25
+ side on the FRONT Assy? IC3001 or replace the FRONT Assy. Is there 5 MHz output from Relpace X3001, IC3001 or X3001 on the FRONT Assy? replace the FRONT Assy. Does FLT3001 have damage? Relpace the FRONT Assy. Relpace FLT3001. VSX-1128-K...
Page 26
If no signals on BRI-1 Assy, replace BRI-1 Assy. If no signals on CN1509, replace D-MAIN Assy. No Problem / No Damage Replace CP17 on the AUDIO Assy or CP19 on the MAIN Assy or replace the MAIN Assy or AUDIO Assy. VSX-1128-K...
Page 27
"SP:B ON ", check SBR, SBL channels. Check signals of problem channel on Check and repair AMP circuit of AMP7 Assy CP401 pins 3 (SL), 5 (C), problem channels 7 (SR) ,11 (SBL),13 (SBR) signals. or replace the AMP7 Assy. VSX-1128-K...
Page 28
(Other Analog OK) Replace IC809, IC1307 or Check CN9202 pin 5 3 V, pins 2, 3 USB in -> replace the FHDMI Assy. Digital signal on the D-MAIN Assy. Repair IC1801 (AK4588VQ) and its peripheral circuit or replace the D-MAIN Assy. VSX-1128-K...
Page 29
VIDEO Assy. Replace the D-MAIN Assy. No GUI Replace the D-MAIN Assy. No Replace the VIDEO Assy No Zone2 OSD Analog Video In -> Monitor Out? or replace the D-MAIN Assy. Replace IC1007, Q1012, Q1013 or replace the VIDEO Assy. VSX-1128-K...
Page 30
Others This is just for general reference and does not including every single case. 12V Trig 12V Trig Replace the CPU Assy. RS-232C RS-232C Remote control Replace the FRONT Assy. VSX-1128-K...
To detect the connected wireless LAN converter converter Over (Pin 27 of IC300) is overload. (over 600 mA) Current" detection [How to Enter Release Mode] During Standby mode, simultaneously press and hold the "TUNE ↓" and "MULTI-ZONE ON/OFF" keys for 5 seconds. VSX-1128-K...
Page 32
MHL equipment is detecition port is set to "L". acknowledged after second power-on. XMHLPERR Circuit FHDMI ASSY CN803 XMHLPERR C115 MHLPOW FRONT ASSY CPU ASSY D-MAIN ASSY V+3R3_E UCOM IC101 CP3002 CN3001 CN304 CN301 CN601 R742 R263 R3360 VSX-1128-K...
H O L D R E S E T times error is detected. R E S E T C L E A R ? [ ↑ ] [ENTER] [↓] R E S E T R E S E T ↓ Continued VSX-1128-K...
Page 37
CEC TEST : The function for making the HDMI output terminal to output 4 Hz square wave. If the square wave is output, the CEC line is considered to be normal. FAN TEST : The function for making the FAN to be forced to rotate. VSX-1128-K...
The display shows RESET? OK. 4 Press ENTER to confirm. OK appears in the display to indicate that the receiver has been reset to the factory default settings. • Note that all settings will be saved, even if the receiver is unplugged. VSX-1128-K...
1 V, using a tester. ∗ Be sure to connect the GND terminal of the tester to CN311 the chassis. ∗ If the voltage is still 1 V or higher, repeat Step (2). −30V 47 - 100 ohms (2 W or higher) VSX-1128-K...
Page 40
(7) Disconnect the HDMI cable. CN304 (JA9620) CN305 (8) Disconnect the one flexible cable and five CN9601 connectors. (CN304-CN306, CN3004, CN9202, CN9601) CN9202 JA9620 INSEL Assy Acetate tape (9) Unhook the two hooks. Front panel section (10) Remove the front panel section. VSX-1128-K...
Page 41
Acetate tape D-MAIN Assy AMP7 Assy WG-B Assy (9) Arrange the Heatsink section as shown Extension jig cable Extension jig cable AMP7 Assy in the photo below. (GGD1741) (GGD1740) (10) Connect the two extension jig cables. CP401 CN404 Diagnosis VSX-1128-K...
Page 42
D-MAIN Assy works normally even though no connection of HDMI cable. But when checking Front HDMI input, that HDMI connection is required. CN2114 CN2110 BRI-1 Assy CN302 Diagnosis CN303 Borad to board extension Conversion jig jig cable (GGD1848) (GGD1804 + GGD1802) VSX-1128-K...
Page 43
(CN304-306, 404, CP1 to 3, 401, 403 to 406) CN305 (4) Remove the six screws. AMP7 Assy (BBZ30P080FTC) ×9 (5) Remove the four screws. CP401 CN404 CP403 CP406 CP405 (BBZ30P180FTC) CP404 (6) Remove the MAIN Assy with CPU Assy and back chassis. ×3 MAIN Assy CPU Assy VSX-1128-K...
Please refer to [1.2 NOTES ON REPLACING PARTS], when the parts listed in the table is defective, replace whole Assy. Note 2: After replacing D-MAIN Assy, the unit needs to reset factory default settings. Refer to "Resetting the system" on "6.2 DEFAULT SETTINGS" , reset the unit. VSX-1128-K...
• Mismatching between the setting file and the specification of the A/V RECEIVER type to be loaded back • Error due to Checksum, Signature Check, and Size Check • Ejecting of USB device (during reading of the setting file) VSX-1128-K...
Page 46
OFF. (If Load is executed with the setting ON, the assignment information for each HDMI input will be cleared.) Procedures for turning OFF the HDMI control setting r HOME MENU r 4.System Setup r e.HDMI Setup r Control OFF VSX-1128-K...
3. Connect the USB Memory to the USB terminal (A type) of the front panel. [Procedure] 1. While holding down "TUNE↑" key on the front panel, press "STANDBY ON/OFF" key and moves to the UPDATE PANEL mode. 2. The updating process is as follows. VSX-1128-K...
Page 48
[PRESET→] Update Confirmation U P D A T E [PRESET←] [←] [→] Update Confirmation U P D A T E Y E S [ENTER] File searching A c c e s s i n g UPDATE FILE searching completed VSX-1128-K...
Page 49
Update time is fluctuated by contents of the update. It will take about 26 minutes at the maximum. (Actual time is from 3 minutes to 26 minutes.) Time required for updating varies, because only the programs that require updating will be updated. [Confirmation] Enter UPDATE PANEL mode and check that the programs have been updated. VSX-1128-K...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION Poly bag packing style Tape (clear) Cord AC Safety Brochure SPEAKER CAUTION Sheet AAA size IEC R03 dry cell batteries VSX-70 only VSX-1128-K...
Page 53
NSP 10 Warranty Card See Contrast table (2) NSP 11 Label VRW1629 12 Power Cord See Contrast table (2) (2) CONTRAST TABLE VSX-1128-K/CUXE, VSX-1123-K/CUXESM,VSX-70/CUXE and VSX-1028-K/CUXE are constructed the same except for the following: VSX-1128-K VSX-1123-K VSX-70 VSX-1028-K Mark Symbol and Description...
9.2 EXTERIOR SECION Binder Binder Sheet Main ch HP plate Plate F/USB Heatsink VSX-1128-K...
Page 55
VSX-1128-K, VSX-1123-K Binder VSX-1028-K only Sheet speaker VSX-70 only VSX-70 only Acetate tape ×30 Main chassis Binder Binder Binder Binder Binder Silicon adhesive (GYA1011) Silicon grease (GEM1057) Heatsink VSX-1128-K...
Page 56
27 Cable HDMI 230 mm L304231190030-IL 28 Cable, Flat Card 1.0M N711271122480-IL 29 Cable, Flat Card 1.0M N711330922480-IL 30 Pioneer Badge B (PLS) See Contrast table (2) 31 Cabinet Assy 3008211846020-IL 32 Front Panel See Contrast table (2) 33 Back Chassis...
Page 57
(2) CONTRAST TABLE VSX-1128-K/CUXE, VSX-1123-K/CUXESM,VSX-70/CUXE and VSX-1028-K/CUXE are constructed the same except for the following: VSX-1128-K VSX-1123-K VSX-70 VSX-1028-K Mark Symbol and Description /CUXE /CUXESM /CUXE /CUXE MAIN Assy 7028073111040-IL 7028073111040-IL 7028073111010-IL 7028073111040-IL VIDEO Assy 7028073113040-IL 7028073113040-IL 7028073113010-IL 7028073113070-IL SMPS Assy...
KIA7812API 1N4007 TO CHASSIS A-12V AGND AGND 1N4007 RB551V-30 TO CHASSIS ACWP 1N4007 5267-03A KIA7912PI 0R22(1) 10N-K C106 ZJ24B • NOTE FOR FUSE REPLACEMENT LBAS16HT1G OPTION CAUTION - FOR CONTINUED PROTECT RT1N237C LBAS16HT1G REPLACE WITH SAME TYPE ACWP LBAS16HT1G VSX-1128-K...
R 1 0 3 R 1 0 1 EMDQ0 1 0 0 0 p / 5 0 EMDQ15 D Q 0 DQ15 (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) * C 2 0 9 4700p/50 EMDQ1 EMDQ14 V D D Q 1 VSSQ4...
10.3 D-MAIN ASSY (2/10) 2/10 D-MAIN ASSY V+5_EV (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) V + 3 R 3 _ H H H (1/4) (7028073151080-IL: VSX-1028-K) I C 6 1 1 9/10 TC74VHCT126AFK C 7 6 4 0 . 1 u / 1 6...
Page 63
R 7 2 6 X12VERR * C N 6 0 3 * C N 6 0 7 GNDD A K N 7 0 6 9 - A AWX1330: VSX-1128-K/CUXE, VSX-1123-K/CUXESM, VSX-70/CUXE REG ONLY AWX1352: VSX-1028-K/CUXE Rear Side AWX1648: VSX-1123-K/SYXE8 AWX1647: VSX-923-K/SYXE8, VSX-923-S/SYXE8, VSX-923-K/PWVXE8...
Page 65
3/10 D-MAIN ASSY (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) JACK8203 (7028073151080-IL: VSX-1028-K) HDMI IN 5 J A 9 6 0 4 A K P 7 2 6 8 - A V+5_R4 R T 4 HDMI BD IN J A 9 6 2 0...
R 1 4 6 0 R 1 6 5 7 *R1653 R 1 6 6 0 R1455 R1647 G N D G N D R1457 R1655 IC1616 IC1601 TC74VHC08FK TC74VHC08FK GNDD GNDD D1LRCK D1LRCK to HDMI IN 3/10 5/10 VSX-1128-K...
Page 69
5/10 D-MAIN ASSY (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) (7028073151080-IL: VSX-1028-K) HDMI OUT 1 J A 1 6 0 1 A K P 7 2 6 8 - A C1630,C1638 L1609 REG-H:ACH7354-1(220uF/6.3V) V+3R3_HHH ATH7064-A Data2+ TXT0X2+ L 1 6 0 5 A T L 7 0 1 0 - A...
10.8 D-MAIN ASSY (7/10) 7/10 D-MAIN ASSY (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) (7028073151080-IL: VSX-1028-K) 2/10 MASTER CLOCK BUFFER CONT_GA V+3R3_DSP C 1 5 6 3 C 1 8 2 8 CRYSTAL V T L 1 1 2 9 - A 0 . 1 u / 1 6...
Page 73
: Audio Signal Route (Center ch) G N D 2 (SBL) G N D 1 : Audio Signal Route (Surround Back L ch) *KN1801 (SW) : Audio Signal Route (Subwoofer ch) GNDD (ZOL) : Audio Signal Route (Zone L ch) 7/10 VSX-1128-K...
R 9 3 4 6 G N D 2 NET_AUDIO 8/10 * R 9 3 5 3 G N D 1 GNDD NWJPG A S S 7 1 1 3 - 1 4/10 9/10 24MHz GNDD GNDD X9201 REG-H_CU:ASS7113-1 GNDD VSX-1128-K...
Page 79
9/10 D-MAIN ASSY (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) (7028073151080-IL: VSX-1028-K) AWX1330: VSX-1128-K/CUXE, VSX-1123-K/CUXESM, VSX-70/CUXE AWX1352: VSX-1028-K/CUXE AWX1648: VSX-1123-K/SYXE8 AWX1647: VSX-923-K/SYXE8, VSX-923-S/SYXE8, VSX-923-K/PWVXE8 V+3R3_NWVDD AYW****- /J * I C 9 2 0 5 K9F1G08U0D-SCB0-K N C 1 N C 4 8 N C 2...
10.11 D-MAIN ASSY (10/10) AWX1330: VSX-1128-K/CUXE, VSX-1123-K/CUXESM, VSX-70/CUXE AWX1352: VSX-1028-K/CUXE AWX1648: VSX-1123-K/SYXE8 AWX1647: VSX-923-K/SYXE8, VSX-923-S/SYXE8, VSX-923-K/PWVXE8 V+5R6_EV V+5_EV V+3R3_HHH ACH7337-1:100uF/16V D 9 5 0 4 @DUMMY C N 9 5 0 1 ACH7352-1:100uF/6.3V 1 S S 3 5 5 RAQ045P01...
Page 81
10/10 D-MAIN ASSY (7028073151010-IL: VSX-1128-K, VSX-1123-K, VSX-70) (7028073151080-IL: VSX-1028-K) DSP/CODEC POWER BLOCK IC9510 V+3R2_DSP V+5R6_DDD MM3529A33P V+3R3_DSP CODEC AVDD5V @DUMMY RAQ045P01 Q9516 V+5_DAC1 V+5R6_EV IC9555 L 9 5 5 5 V D D V O U T R 9 5 3 2...
BT_RX/U_TX R644 BT_TX/U_RX R643 C637 100N-K C641 100N-K PLATE_SCREW P601 The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. VSX-1128-K...
Page 95
(FL) : Audio Signal Route (Front L ch) (SL) : Audio Signal Route (Surround L ch) : Audio Signal Route (Center ch) (SBL) : Audio Signal Route (Surround Back L ch) VSX-1128-K...
10.22 SMPS ASSY SMPS ASSY (70280733610O0-IL: VSX-1128-K, VSX-1123-K, VSX-1028-K) (70280733610F0-IL: VSX-70) F101 FUSE OPTION VERSION F101 GBL206(LRC) 100V, 110V, 120V, 110-127V / 220-240V T8AL/250V 220V, 220-230V, 220-240V T6.3AL/250V CX100 CN901B F100 L100 3.15A LF4ZBE273H FROM AC CORD CN901W NOT USED...
Page 103
2] Before returning the set to the customer make appropriate leakage current or resistance measurements to determine the exposed parts are prorerly insulated from the supply circuit. VSX-1128-K...
For further information for respective desti- nations, be sure to check with the sche- matic diagram. 2. View point of PCB diagrams. Connector Capacitor SIDE A SIDE B P.C.Board Chip Part TO MAIN TRANS TO MAIN T VSX-1128-K...
Page 105
J115 J109 J130 C102 C103 C101 J112 J117 CP21 CAUTION : REPLACE WITH SAME TYPE FUSE(S). ATTENTION : UTILISER UN FUSIBLE DE RECHANGE DE MEME TYPE. F33 / F34 GND4 T4A / 250V TO MAIN TRANS TO MAIN TRANS VSX-1128-K...
Page 106
SIDE B MAIN ASSY CP19 CP17 Q9-Q13 Q2-Q6 VSX-1128-K...
JP130 POWKEY S3005 S3006 S3007 S3013 S3009 S3008 S3014 SPEAKERS CONTROL CONTROL BAND MULTI ZONE-ON MULTI ZONE-OFF CP3501A CN7202A S3001 S3004 S3002 S3003 AUTO/ALC/DIRECT STANDARD ADV SURR CN7202A HPMIC ASSY C3693 CN7202B INSEL ASSY S3401 S3402 M N O VSX-1128-K...
→ CN9*** → IC → D9*** → CN9*** → IC9*** → D9*** → CN9*** LIST OF ASSEMBLIES Mark Symbol and Description VSX-1128-K/CUXE VSX-1123-K/CUXESM VSX-70/CUXE VSX-1028-K/CUXE 1..PCB TTL ASSY MAIN 7025HK1207020-IL 7025HK1207020-IL 7025HK1207040-IL 7025HK1208010-IL 2..MAIN ASSY (PCB SUB ASSY MAIN) 7028073111040-IL...
Page 134
Not used L103090090040-IL Not used INSEL ASSY 7028073123040-IL and 7028073123010-IL are constructed the same except for the following: Mark Symbol and Description 7028073123040-IL 7028073123010-IL D3029 LED, round Not used K500036000160-IL S3401 Switch G180501000010-IL Not used S3402 Switch Not used G180501000010-IL VSX-1128-K...
Page 135
70280733610F0-IL CN9100 CN. wafer 7.92 mm L108396030010-IL Not used Mark No. Description Part No. Mark No. Description Part No. IC 610,1509,1806 TC74VHC126FK PARTS LIST (VSX-1128-K) IC 611 TC74VHCT126AFK IC 612,1502 TC74VHCT08AFKS1 MAIN ASSY IC 614,616,9208 TC7SH08FUS1 SEMICONDUCTORS IC 901,910 TC74LCX541FK...
Page 136
MISCELLANEOUS JA 2101 TER,RCA 6PIN G603610A0001Y-IL FHDMI ASSY JA 2102 TER,RCA 4PIN G602421E0002Y-IL SEMICONDUCTORS JA 2103 TER,RCA 4PIN G602421E0046Y-IL IC 808 J127380100050-IL IC 8202 PCA9517DGK RESISTORS R 374,377 C060033065050-IL MISCELLANEOUS JA 600 CN,PLUG CONTACT G480400201010-IL JA 8082 CN.WAFER L109100190140-IL VSX-1128-K...