Page 1
Engineering Operation & Maintenance XSD HS Saniflo Hygienic Series ™ Surge Dampener W h e r e I n n o v a t i o n F l o w s www.wildenpump.com WIL-12230-E-04 REPLACES WIL-12230-E-03...
t a b l e o F c o n t e n t s Section 1 cautions — Re ad FiRs t! . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Section 2 W ilden PumP designation sys tem .
S e c t i o n 1 c a u t i o n s — R e a d F i R s t ! CAUTION: do not over-lubricate air supply — CAUTION: The process fluid and cleaning fluids excess lubrication will reduce performance.
Page 4
S e c t i o n 2 W i l d e N d e s i g N a t i o N s y s t e m legeNd Xsd X / XX XX / XXX / xxxx HygieNiC seRies eQUaliZeR...
Page 5
S e c t i o n 3 H o w I t w o r k s — D A M P E N E r All reciprocating pumps experience a pressure fluctuation. The The Equalizer automatically sets and maintains the correct air ®...
S e c t i o n 4 D i m e n s i o n a l D r a w i n g s XS D1-½ Sa n i f l o DIMENSIONS iTem meTriC (mm) sTanDarD (inch) 11.2 10.2 12.0...
Page 7
S e c t i o n 5 X s D 1 ½ H s p e r f o r m a n C e These charts show discharge head fluctuations for resulting in a total pressure fluctuation of 96 psig a diaphragm pump with and without a dampener.
Page 8
X s D 2 H s p e r f o r m a n C e These charts show discharge head fluctuations for resulting in a total pressure fluctuation of 5.7 bar a diaphragm pump with and without a dampener. (82 psig) for each stroke.
Page 9
X s D 3 H s p e r f o r m a n C e These charts show discharge head fluctuations for bar (21 psig) and 7.1 bar (103 psig) resulting in a total a diaphragm pump with and without a dampener. pressure fluctuation of 82 psig for each stroke.
Page 11
S e c t i o n 6 S u g g e S t e d I n S t a l l a t I o n The model XSd1-1/2 Hygienic Series™ has a 38 mm (1-1/2”) Install the Equalizer ®...
Page 12
t R o u B l e S H o o t I n g 1) When there is a significant drop in the fluid discharge 2) Fluid leakage around the clamp band area is normally pressure, there will be a noticeable release of air stopped by tightening the clamp band bolts.
Page 13
S e c t i o n 7 S U R G E D A M P E N E R D I S A S S E M B L Y To o l s R e q u i r e d : CAUTION: Before any maintenance or repair is attempted, the compressed air line to the Equalizer ®...
Page 14
S U R G E D A M P E N E R D I S A S S E M B L Y Step 4 Step 5 Step 6 Loosen shaft assembly by using In either case, this will allow the Inspect shaft for nicks or abrasion.
Page 15
S U R G E D A M P E N E R D I S A S S E M B L Y Step 10 Step 11 In the event of an air leak, remove Using an O-ring pick remove the the regulator adaptor plate and Glyd-rings from air regulator body.
R E A S S E M B L Y H I N T S & T I P S ASSEmbly: SHAFT SEAl INSTAllATION: Upon performing applicable maintenance to the PRE-INSTAllATION air distribution system, the Equalizer can now ® • Once all of the old seals have been removed, the be reassembled.
S e c t i o n 8 C L E A N I N G - C I P The design of the pulsation dampener allows for ease • Suggested flow rate for the 38 mm (1-1/2") dampener: of cleaning. This equipment can be disassembled for 6.5 m /hr (3 gpm);...
S e c t i o n 9 E l a s t o M E r o p t i o n s Ultra-FlEx™ ElastoMEr diapHragM BaCK-Up diapHragM sip diapHragM diapHragM FDA NITRILE 04-1010-69 04-1020-52 xsd1-½ saniFlo FDA EPDM 04-1010-74 04-1060-54 04-1020-54...
Page 25
S e c t i o n 9 N O T E S Wilden PumP & engineering, llC Wil-12230-e-04...
Page 27
W a r r a n t y Each and every product manufactured by Wilden Pump and Engineering, LLC is built to meet the highest standards of quality. Every pump is functionally tested to insure integrity of operation. Wilden Pump and Engineering, LLC warrants that pumps, accessories and parts manufactured or supplied by it to be free from defects in material and workmanship for a period of five (5) years from date of installation or six (6) years from date of manufacture, whichever comes first.
Page 28
Where Innovation Flows 22069 Van Buren Street, PSG reserves the right to modify the information and illustrations contained in this document without prior notice. This is a non-contractual document. 10-2013 Grand Terrace, CA 92313-5607 A u t h o r i z e d P S G R e p r e s e n t a t i v e :...