Subscribe to Our Youtube Channel
Related Manuals for Smithco Fairway Ultra 15
Summary of Contents for Smithco Fairway Ultra 15
- Page 1 Parts & Service Operators Fairway Ultra 15 Model 12-750-A SN FWR15-200 June 2015 Product Support: Hwy SS & Poplar Ave; Cameron WI 54822 1-800-891-9435 productsupport@smithco.com...
-
Page 2: Table Of Contents
CONTENTS Introduction .......... 1-10 Introduction ................... 1-5 Introduction .................. 1 Safe Practices ................2 Specifications ................3 Setup ..................4-5 Service ..................5-7 Maintenance ................6-7 Storage ..................8 Diagrams ..................9-13 12-750 Wiring ............... 10-11 12-750 Hydraulics ..............12-13 Parts .................. -
Page 3: Introduction
Smithco product. Smithco Read this manual and all other manuals pertaining to the Fairway Ultra 15, FairWay Roller (FWR) carefully as they contain safety, operating, assembly and maintenance instructions. Failure to do so could result in personal injury or equipment damage. -
Page 4: Safe Practices
13. Never carry passengers. 14. Use parts and materials supplied by Smithco only. Do not modify any function or part. 15. Avoid sharp turns. Watch the tires of the tractor while turning to make sure they do not contact the drawbar of the Fairway Roller . -
Page 5: Specifications
SPECIFICATIONS FOR FAIRWAY ULTRA 15 WEIGHTS AND DIMENSIONS Folded Width x Length 78" (1,98 m) Folded Width x 147" (3.73 m) Overall Length Effective Rolling Width 180" (4,57 m) Overall Width 185" (4,70 m) Water Capacity 150 Gallons (567,8 l) -
Page 6: Setup
SETUP Battery not included. 1. Install an Automotive type 24F-12 Volt battery into the Power Box and secure with the battery hold-down. 2. Fill the power unit with approximately 1.50 Gal (5.68 liter) MileMaster 303 Tractor HYD Fluid or equivalent. 3. -
Page 7: Setup
SETUP 7. Test operation - Avoid operating on hard surface. STAND CLEAR 10' DURING ALL OPERATION A. Place main power switch in the "ON" position. B. Place hand switch in "LOWER" position and allow the unit to cycle completely. Unit will switch off automatically when it reaches roll pressure. - Page 8 OPERATION Hillside Operation Do NOT stop or start suddenly on any slope. Be especially cautious when changing direction. Do NOT operate on slopes greater than 20°. To Level Frame. 1. Connect hitch to tow vehicle 2. Adjust hitch as necessary to level roller frame. 3.
-
Page 9: Maintenance
Use No. 2 General Purpose Lithium Base Grease and lubricate after the first 10 hours of use then every 100 hours thereafter. The Fairway Ultra 15 has 20 grease fittings. When inserting grease, be careful not to ruin the seal, if this happens, replace the seal at once. Be sure to wipe grease fitting clean before injecting grease. - Page 10 MAINTENANCE WHEEL MOUNTING PROCEDURE 1. Set park brake on tow vehicle. Turn machine off and remove key. 2. Turn off main power switch on power box. 2. Block one of the other wheels. 3. Loosen nuts slightly on wheel to be removed. 4.
-
Page 11: Storage
BATTERY Batteries normally produce explosive gases which can cause personal injury. Do not allow flames, sparks or any ig- nited object to come near the battery. When charging or working near battery, always shield your eyes and always pro- vide proper ventilation. Battery cable should be disconnected before using “Fast Charge”. -
Page 12: Diagrams
WIRING DIAGRAM... -
Page 13: Parts
WIRING PARTS LIST REF# PART# DESCRIPTION QUANTITY 12-568 Toggle Switch 12-792 Switch Guard 12-578 Round Magnet 9043 Flag Connector 12-569 Wire Cable 12-573 Male Trailer Connector 12-572 Female Trailer Connector 8975 Circuit Breaker, 30 Amp 8977 Circuit Breaker Boot 30-042-06 Relay 12-585 Power Unit... - Page 14 HYDRAULIC DIAGRAM...
- Page 15 HYDRAULIC PARTS LIST REF# PART# DESCRIPTION QUANTITY 12-514 Front Hydraulic Cylinder 12-519 Center Hydraulic Cylinder 12-571 Rear Hydraulic Cylinder 12-589 Hydraulic Hose, 46" 12-593 Hydraulic Hose, 28" 12-592 Hydraulic Hose, 33" 12-586 Hydraulic Hose, 100" 12-588 Hydraulic Hose, 104.5" 12-587 Hydraulic Hose, 115"...
-
Page 16: Main Drawing
12-750 MAIN DRAWING... -
Page 17: Power Box
12-750 MAIN DRAWING REF# PART# DESCRIPTION QUANTITY 23-126 Hollow Hex Plug, #6 18-169 SAE Adapter 18-168 Straight Thread Elbow 12-584 Manifold 78-240 Trailer Jack 78-244 Adjustable " Clevis 12-760 Main Frame HB-58-11-500 Bolt, - 11 x 5 HNTL-58-11 Lock Nut, 12-568 Toggle Switch (Breakout on page 16) 12-792... - Page 18 POWER BOX DRAWING...
- Page 19 POWER BOX DRAWING REF# PART# DESCRIPTION QUANTITY 12-786 Power Box Cover HSM-10-32-100 Machine Screw, #10-32 x 1 HNFL-10-32 Flange Lock Nut, #10- 32 15-437-01 Keeper 74-231 Hinge HB-516-18-100 Bolt, -18 x 1 HNFL-516-18 Flange Lock Nut, - 18 12-598 Hydraulic hose, 31.5" 12-590 Hydraulic Hose, 33.5"...
-
Page 20: Left Front Ouboard Wing
LEFT FRONT OUTBOARD WING... - Page 21 LEFT FRONT OUTBOARD WING REF# PART# DESCRIPTION QUANTITY 12-514 Hydraulic Cylinder (* comes with clevis pins) 12-784 LH Outboard Wing 18-153 Bushing HG-14-28-180 Grease Fitting, - 28 x 180° 50-081 Rubber Bumper HNFL-38-16 Flange Lock Nut, - 16 12-791 Outboard Wing Limit HB-716-14-125 Bolt, -14 x 1...
-
Page 22: Left Rear Wing
LEFT REAR WING... - Page 23 LEFT REAR WING REF# PART# DESCRIPTION QUANTITY HP-18-200 Cotter Pin, HCP-100-325 Clevis Pin, 1 x 3 23-167 Male Elbow 12-571 Hydraulic Cylinder (* comes with clevis pins) HB-38-16-100 Bolt, - 16 x 1 HNTL-38-16 Lock Nut, 12-797 Pivot Shaft 12-762 Left Rear Wing 18-153 Bushing...
-
Page 24: Right Front Ouboard Wing
RIGHT FRONT OUTBOARD WING... - Page 25 RIGHT FRONT OUTBOARD WING REF# PART# DESCRIPTION QUANTITY 12-789 Brush Mount 12-788 Roller 12-798 Strip Brush Holder HRS-316-025 Rivet, 12-599 Strip Brush HB-516-18-100 Bolt, - 18 x 1 HW-516 Washer, HNFL-516-18 Flange Lock Nut, - 18 12-773 LH Brush Mount 75-511 Pillow Block HG-14-28-180...
-
Page 26: Right Rear Wing
RIGHT REAR WING... - Page 27 RIGHT REAR WING REF# PART# DESCRIPTION QUANTITY 50-081 Rubber Bumper HNFL-38-16 Flange Lock Nut, - 16 HNA-114-12 Axle Nut, 1 - 12 HP-18-200 Cotter Pin, 12-763 Right Rear Wing 18-153 Bushing HG-14-28-180 Grease Fitting, - 28 x 180° HB-38-16-100 Bolt, - 16 x 1 HNTL-38-16 Lock Nut,...
-
Page 28: Center Roller
CENTER ROLLER... - Page 29 CENTER ROLLER REF# PART# DESCRIPTION QUANTITY HB-516-18-100 Bolt, - 18 x 1 HW-516 Washer, HNFL-516-18 Flange Lock Nut, - 18 12-774 RH Brush Mount HB-58-11-200 Bolt, -11 x 2 HNTL-58-11 Lock Nut, - 11 75-511 Pillow Block HG-14-28-180 Grease Fitting, - 28 x 180°...
-
Page 30: Tank And Rear Wheels
TANK AND REAR WHEELS... - Page 31 TANK AND REAR WHEELS REF# PART# DESCRIPTION QUANTITY 12-770 Tank Strap 12-576 150 Gallon Tank HB-38-16-225 Bolt, -16 x 2 HW-38 Washer, HNTL-38-16 Lock Nut, 16-945 1" Double Thread Fitting 16-851 1" Nylon Close Nipple 18-448 1" PVC Ball Valve HB-12-13-150 Bolt, -13 x 1...
-
Page 32: Decal List
This is a list of decals located on the Ultra 15 Fairway Roller. Part number, description and location will help in reorder- ing decals. 12-779 Decal, On/Off 12-780 Decal, Warning 12-781 Decal, Fairway Ultra 15 12-799 Decal, Warning Stay Back 25-277 Decal, Battery Warning 25-286 Decal, Pinch Points 25-374 Decal, Smithco 12"... - Page 33 QUICK REFERENCE Battery Automotive type 24F-12 Volt (Smithco Part #33-216) Hydraulic Fluid 2 Gal (7,57liter) MileMaster 303 Tractor HYD Fluid (Smithco Part# 9042) CYLINDERS 12-519 Hydraulic Cylinder 15-519-01 Seal Kit 12-514 Hydraulic Cylinder 12-514-01 Seal Kit 12-571 Hydraulic Cylinder 12-571-01...
- Page 35 30 days from discovery of the condition. If you need help locating an Authorized Smithco Distributor, or if you have questions regarding your warranty rights or responsibilities, you may contact us at: Smithco Product Support Department 200 West Poplar Ave.
- Page 36 Smithco may require the return of failed parts or components in order to determine the validity of any warranty claim. Smithco will not be obligated to replace components of other manufacturers if inspection by the original component manufacturer indicates that failure was due to normal wear and tear, expected consumption through use or improper care or service.
Need help?
Do you have a question about the Fairway Ultra 15 and is the answer not in the manual?
Questions and answers