Razor Dirt Rocket SX500 Owner's Manual page 14

TROUBLESHOOTING GUIDE
Short run time/runs slow
Problem
Runs intermittently
Motor bike does not stop when applying
the brake
Motor bike makes loud noises or grinding
sounds
Rider weight
Battery not fully charged
Old/damaged battery
Improper battery maintenance
Tire is not properly inflated
Brakes are not adjusted properly
Possible Cause
Loose connection(s)
Motor or electrical switch damage
Brakes are not adjusted properly
Chain is too dry
Do not exceed the weight limit of 175 lb (79 kg) for SX500/MX500 and 220 lb
(100 kg) for MX650.
Charge unit for a full 12 hours.
Check all connectors. Make sure the charger connector is tightly plugged into
the charging port, and that the charger is plugged into the wall.
Secure unit, turn power ON with no weight on the unit, carefully lift up back
end and apply the throttle to engage the motor. If motor engages - replace
battery.
Charge battery periodically when not in use.
Do not store unit in freezing or below freezing temperatures. Freezing will
permanently damage the battery and greatly reduce ride time. Refer to page 7
"Charging the Battery".
Tire will lose some pressure over time. Verify correct tire pressure.
Refer to "Adjusting the Brakes" on page 8.
Solution
Check for loose connections/wires.
Contact customer service.
Refer to "Adjusting the Brakes" on page 8
Apply a lubricant, such as 3 in 1
12
or Tri-Flow to the chain.
TM TM