mr. steam MX5E Installation, Operation And Maintenance Manual
Steambath generator systems
Hide thumbs
Also See for MX5E:
- Installation, operation and maintenance manual (26 pages) ,
- Installation, operation and maintenance manual (26 pages) ,
- Instructions (2 pages)
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for mr. steam MX5E
Summary of Contents for mr. steam MX5E
- Page 1 Installation, Operation and Maintenance Manual Steambath Generator Systems Residential Models: MX4E, MX5E, MX6E ____________________ ____________________ IMPORTANT: Leave this material with the home owner. steam ® Feel Good Inc. ®...
-
Page 2: Table Of Contents
Installation, Operation and Maintenance Manual SERIAL NO. __________________________ MODELS: MX4E, MX5E, MX6E INSTALLER'S SECTION: Important Safety Information .....1-2 PRE-INSTALLATION INFORMATION Steam Room Guidelines . -
Page 3: Important Safety Information
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ I N S T A L L E R S E C T I O N IMPORTANT SAFETY INFORMATION As you follow these instructions, you will notice warning and Indicates a potentially hazardous situation, which, caution symbols. - Page 4 mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ IMPORTANT SAFETY INFORMATION (cont.) Applies to 1-6 1. This document contains important safety, operation 4. If acrylic, fiberglass or other non-heat resistant materials and maintenance information. Leave this document are used as part of the steam room enclosure, consult with the homeowner.
-
Page 5: Steam Room Guidelines
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ PRE-INSTALLATION CONSIDERATIONS STEAM ROOM GUIDELINES 4. The ceiling should be sloped and constructed to pre- To prevent slip and fall hazards non-skip strips vent dripping of condensate. must be installed on the steam room floor. 5. -
Page 6: Steam Generator
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ STEAM GENERATOR LOCATING THE STEAM GENERATOR Applies to 1-6 Applies to 12-18 1. Do not route iSteam, AirTempo, iTempo/Plus, iTempo OR 12. Provide a minimum of (18) inches on the left side and HomeWizard control wiring inside conduit together with 21"... -
Page 7: Correct Sizing
Room Vol. Gallons†† Dimensions* Wt. (lbs)** ⁄ ⁄ MX4E "L x 20 "H x 7 ⁄ "D ⁄ ⁄ MX5E 1075 "L x 20 "H x 7 ⁄ "D ⁄ ⁄ MX6E 1275 "L x 20 "H x 7 ⁄... -
Page 8: Clearance Specifications
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ STEAM GENERATOR CLEARANCE SPECIFICATIONS Applies to 1-2 1. Do not install MAX series inside a vanity or other small enclosed spaces. Do not install under the steam room bench. Installing the MAX steam generator in a small enclosed space may result in elevated temperatures and an inoperable steam generator. -
Page 9: Generator Dimensions
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ GENERATOR DIMENSIONS 18" for servicing Dimensions MX4E-6E (248) ⁄ (280) (419) ⁄ (527) ⁄ (34) ⁄ (60) ⁄ (150) ⁄ (150) ⁄ (200) ⁄ TO AVOID (48) ⁄ EQUIPMENT DAMAGE DO NOT (638) ⁄... -
Page 10: Parts Identification Diagram
All Models 29201CMS Heating Element 20 KW 240V MX4E MSTS Remote Temperature Probe All Models 29241BMS Heating Element 24 KW 208V MX5E for iTempo/Plus and AirTempo 29241CMS Heating Element 24 KW 240V MX5E 99012 Contactor 50A 3-pole All 3-Phase 29301BMS... -
Page 11: Plumbing
mr . steam ® Installation, Operation & Maintenance Manual _________________________________________________________________________ PLUMBING GENERAL DRAIN (cont.) Applies to 5-8 1. All plumbing shall be performed by a qualified licensed 5. A drain valve is provided to facilitate plumber and in accordance with applicable National and local maintenance and servicing. -
Page 12: Steam Supply Plumbing
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ STEAM SUPPLY PLUMBING ⁄ " NPT) Union STEAM ROOM STEAM GENERATOR Steam Supply Plumbing 6-12” Above Floor SteamHeads ALL DRAWINGS FOR ILLUSTRATIVE PURPOSES ONLY. Applies to 1-5 8. Pitch steam line 1/4" per foot towards steam head 1. -
Page 13: Electrical
Ampere Chart. If allowed by codes, NM cable may require a larger wire size than as listed on the chart. ____________________________________________ ______________________________________ 6. Connect suitably sized equipment grounding wire to MX5E 1075 ground terminal provided. Neutral (white) wire is not required for 208V and 240V units. -
Page 14: Wiring Diagrams
. steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ SINGLE PHASE 208/240 VOLT WIRING DIAGRAM MODELS MX4E, MX5E, MX6E POWER INPUT TRANSFORMER 2/4PL Terminal EXPRESS Block STEAM optional WATER FUSES FEED SOLENOID GROUND VALVE AutoFlush HEATER HomeWizard iGenie (optional) -
Page 15: Connecting Multiple Generators
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ CONNECTING MULTIPLE GENERATORS IN TANDEM Applies to 1-2 1. Install each unit as in a single installation. Install the two generators as close to each other as possible, while providing for all clearances as shown on page 6. 2. -
Page 16: Post-Installation Information Generator And Start-Up Checkout
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ POST INSTALLATION STEAM GENERATOR SYSTEM START-UP AND CHECKOUT 1. Turn the control ON. Follow specific instructions provid- 3. Steam will shut OFF when control counts down to zero. To shut steam ed with the controls. -
Page 17: Control Status Codes
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ CONTROL STATUS CODES The control (either iSteam ® , AirTempo ® , iTempo or iTempo/Plus ) may display a status code if the steam generator ® ® is not functioning properly. Code Code Meaning Probable Cause... -
Page 18: Control
A S S E S S O R I E S CONTROL INSTALLATION Refer to Installation Instructions for the specific control Applies to 1-5 Applies to 6-7 1. A peel and stick warning sticker must be read and per- 6. To avoid unintentional steambath operation, do not locate the con- manently affixed in a conspicuous location near the trol where other controls, accessories, shower heads, valves, body steam room. -
Page 19: Autoflush
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ ® Steam Generator OPTIONAL AUTOFLUSH 3 Pin Connector OPERATION for AutoFlush The optional AutoFlush System feature automatically drains the MrSteam generator following each use. A time delay allows the water to cool down (about two hours) before it drains by gravity for a safe and gentle operation. -
Page 20: Steam Heads
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ 1/8" minimum clearance required STEAMHEAD INSTALLATION when Acrylic Shield is used. See installation instructions provided Use Teflon ® Applies to 1-2 with the Acrylic Shield. equal sealant on pipe threads 1. -
Page 21: Condensation Pan
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ OPTIONAL CONDENSATION PAN Applies to 1-7 1. MrSteam strongly recommends the use of a condensation pan in the unlikely event of a plumbing leak. 2. Locate the condensation pan on a solid level surface and place the steam generator inside the condensation pan. -
Page 22: Important Safety Instructions
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ H O M E O W N E R S E C T I O N IMPORTANT SAFETY INFORMATION As you follow these instructions, you will notice warning and caution symbols. This blocked information is important for the safe and efficient installation and operation of this generator. -
Page 23: Setting The Temperature, Safety, And Operating Info
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ IMPORTANT SAFETY INFORMATION (cont.) (cont.) The peel and stick warning label located in 21. If acrylic, fiberglass or other non-heat resistant materials are this manual is an essential part of providing a safe environ- used as part of the steam room enclosure consult with the ment for steam room users. -
Page 24: Care Tips
mr . steam ® Installation, Operation & Maintenance Manual __________________________________________________________________________ CARE TIPS FOR ALL CONTROLS STEAM GENERATOR MAINTENANCE AND STEAMHEADS MrSteam steambath generators require little maintenance. Other than periodic draining, maintenance procedures are minimal. Every 2 1. Use only mild soap and water on a soft cloth to clean the control and steamhead. - Page 25 steam ® Feel Good Inc. ® www.mrsteam.com Products, information and specifications are subject to change without notice. Please call Sales & Support at 1.800.76.STEAM (East Coast) or 1.800.72.STEAM (West Coast) for more information. steam ® Sussman-Automatic Corporation ® I hello@mrsteam.com I www.mrsteam.com 43-20 34th Street, Long Island City, NY 11101 : 1 800 76 STEAM I 9410 S.
Need help?
Do you have a question about the MX5E and is the answer not in the manual?
Questions and answers