Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for OfiTE 170-95
Summary of Contents for OfiTE 170-95
- Page 1 With Magnetic Drive #170-95 - 115V #170-95-1 - 230V Instruction Manual Updated 6/24/2015 Ver. 2.0 OFI Testing Equipment, Inc. 11302 Steeplecrest Dr. · Houston, Texas · 77065 · U.S.A. Tele: 832.320.7300 · Fax: 713.880.9886 · www.ofite.com Copyright OFITE 2015 ©...
-
Page 2: Table Of Contents
Cell Cap Assembly ...............15 Maintenance ..................17 Fuses ..................17 Bearing Replacement ...............18 Appendix ..................21 Mag Drive ..................21 Top Cell Cap ................21 Warranty and Return Policy ............22 OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 3: Intro
Variable Speed Motor: up to 3,600 RPM Digital Temperature Controller: 100° to 500°F (38° to 260°C) Requires a Nitrogen source of at least 2,500 PSI OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 4: Components
Threaded Filter Press Cell Assembly, 500mL, Hastelloy #171-196-S Threaded Filter Press Cell Assembly, 500mL, SS #170-58 ½" Shaft Extension #170-59 1" Shaft Extension #170-60 1½" Shaft Extension OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 5: Safety
Always secure the pin with the lanyard. Quick-Connect Fitting Back Pressure Safety Pin Receiver Safety Retainer Pin with Lanyard (# 171-23-1) OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 6: Setup
5. Connect the input and output to a chiller/water source prior to heating the cell if the water cooling method will be used upon completion of the test. Chill Input Chill Output OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 7: Quick Start
21. After heat time, increase the top pressure to 500 PSI above the back pressure. 22. Open the bottom valve stem to initiate filtration. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... - Page 8 32. Unscrew the outlet cell cap. 33. Wash the filter cake and record the thickness to the nearest 1/32". 34. Clean and dry all components. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
-
Page 9: Operation
8. Place an o-ring in each of the two o-ring grooves on both valve stems. 9. Screw one valve stem into the outlet cell cap. Tighten the valve stem completely. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... - Page 10 14. Secure the top cap assembly in place with the spanner wrench (#170-95-313). 15. Screw a valve stem into the cell cap and tighten it completely. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
- Page 11 18. Plug the magnetic drive into the port on the back of the control box. Temperature Controller Pressure Quick-Connect Cell Temperature Fitting Thermocouple Mag Drive OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
- Page 12 Maintain this pressure on the fluid until the temperature is stabilized. 25. Turn the “Motor” switch on. Always make sure the Speed Control Knob is set to 0 before turning on the motor switch. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
- Page 13 34. Allow the filtrate to cool for at least five minutes. Open the outlet valve on the back pressure receiver to collect all of the filtrate in the graduated cylinder. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
- Page 14 42. Clean and dry the apparatus thoroughly after each use. Inspect all of the o-rings and replace any that show signs of wear or damage. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
-
Page 15: Data
“zero mark” at the very edge of the ruler is useful here. Cake descriptions may be subjective and such notations such as hard, soft, rubbery, and fine, etc. convey adequate information on cake quality. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 16: Cell Cap Assembly
(#171-190-040) and screw it into the port. Locking Ring Retaining Ring Rupture Disk (#171-190-023) (#130-81-040) (#171-190-027) Rupture Disk Retaining Ring Locking Ring O-ring OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... - Page 17 Top End Cap Valve Stem Adapter (#171-190-041) (#171-190-035-S) (#171-190-021) Rupture Disk (#171-190-027) O-ring, Viton (#170-13-3) Retaining Ring Locking Ring Valve Stem (#130-81-040) (#171-190-023) (#170-16) OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
-
Page 18: Maintenance
1. The instrument has two fuses that protect the electronic components which are located on the power cord receptacle: Fuses 10 Amp fuses (#122-077), Qty. 2 OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 19: Bearing Replacement
3. Carefully tap the bearings and spacer using the supplied bearing removal tool from one end of the cap to push them all out. 4. Inspect bearings for wear and tear. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... - Page 20 6. Reinstall the bearings one by one with the correct spring orientation very carefully with the bearing removal tool. Bottom OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
- Page 21 8. Insert the retaining ring. Inspect for damages to the bearing and repeat for the other bearings. 9. Reinstall the cap with anti-seize and Teflon on the NPT port to the mag ® drive cap. OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com...
-
Page 22: Appendix
4" Shaft Extension Propeller Appendix Top End Cap Top Cell Cap Rupture Disk Valve Stem Adapter ¼" NPT Adapter Retaining Ring Locking Ring O-ring, Viton OFITE, 11302 Steeplecrest Dr., Houston, TX 77065 USA / Tel: 832-320-7300 / Fax: 713-880-9886 / www.ofite.com... -
Page 23: Warranty And Return Policy
In the event that OFITE is requested to provide customized research and development for the buyer, OFITE shall use its best efforts but makes no guarantees to the buyer that any products will be provided. OFITE makes no other warranties or guarantees to the buyer, either express or implied,...